Escolar Documentos
Profissional Documentos
Cultura Documentos
SPECIFICATION
MODELEDA-31054FFJRA
EARDATEK
1. FEATURES
z
z z
z z z z z z z
3-band hybrid NIM tuner for ATSC and QAM standard Broadcast reception 48MHz to 862MHz full frequency range coverage Meets all relevant north American DTV standards and requirements, including: ATSC A/53 ATSC recommended practices A/74 TM ITU-T J.83 Annex B(DOCSIS , OpenCable) OpenCable/UDCP Brazil ensembles A,B,C,D,E Exceptional reception performance Superior multi-path performance in ATSC mode Very robust sync recovery Superior low noise, high sensitivity and ACI rejection performance +3.3V and +1.2V DC supply voltage Active RF Loopthrough option Optional with DC-power output through input connector (e.g. indoor antenna supply) Parallel and serial MPEG_TS Output 6MHz bandwidth filter selectable. Low power consumption
2. Black Diagram
IF AGC
LIF
TDA18219
SDAT SCLT
DRX3933J
TS1 output
SDA
E-mailsales@eardatek.com
RF_in
LIF
SCL
TDA18219
RF_out
SDAT SCLT
DRX3933J
TS2 output
IF AGC
MODELEDA-31054FFJRA
EARDATEK
3. Ordering Information
Model Name: E D A 31054 FF J R A
Version:
A A Version
E-mailsales@eardatek.com
MODELEDA-31054FFJRA
EARDATEK
4. Environmental conditions
SYMBOL PARAMETER CONDITIONS MIN MAX UNIT
Store and transportation Conditions TAMB RH gB gS Ambient temperature Relative humidity Bump acceleration Shock acceleration Vibration amplitude Operation conditions
TAMB
% m/s2 m/s2 mm %
RH
Limiting values under operation conditions The tuner can be guaranteed to function properly under the following conditions.
SYMBOL PARAMETER DC supply Valtege to external active antenna (optional) PIN MIN TYP MAX. UNIT
VANT IL VRF ITU VTU ITU Vdemod Idemod Vcore Icore VSCL VSDA ISDA
24 2 150 3.1 4 3.2 11 3.2 13 1.1 25 24 -0.3 -0.3 -1 3.3 40 3.3 480 3.3 60 1.2 600 3.4 60 3.4 560 3.4 80 1.3 800 5.25 5.25 5
V mA V mA V mA V mA V mA V V mA
Max. permissible
current
RF amplifier DC supply voltage Relevant supply current Tuner PLL supply voltage Relevant supply current Tuner demodulator supply voltage Relevant supply current DC supply voltage of demodulator core Relevant supply current Serial clock input voltage Serial data input voltage Serial data input current
Note: The filtering caps 470uF and 0.01uF must be connected to all the DC supply input pins of the tuner as short distance as possible on the main board.
E-mailsales@eardatek.com
MODELEDA-31054FFJRA
EARDATEK
5. SPECIFICATION DATA
If not otherwise stated the electrical performance refers to: z z z z z ambient temperature relative humidity supply voltages RF-input termination RF-output termination 22 60% 2 10% 5V 0.1V 75 ohms 75 ohms
MIN Frequency ranges Bandwidth AGC range Image Rejection OSC Voltage at aerial input(f<1000MHz) RF-input return loss (75ohms) In-channel return loss
TYP
MAX
862MHz
30dBuV
Overloading causing 1dB gain compression Noise figure (at nom. Gain) ESD protection of terminals Surge protection at RF-input OSC. Phase noise (1kHz) (10kHz) Overall voltage gain
7 dB
-80dBc/Hz -85dBc/Hz 77 dB
LOOP-THROUGH CHARACTERISTIC (RF in to RF out ) Frequency Range Power gain Noise Figure 2nd order intermediation 3rd order intermediation Return Loss @75
Conditions
Min.
Typ.
Max.
48MHz @75 80dBuV input level 90dBuV input level 75 termination at RF out - freq 70 MHz freq > 70 MHz -2dB 136dBuV 121dBuV 6dB 8dB
20dBV 30dBV
E-mailsales@eardatek.com
MODELEDA-31054FFJRA
EARDATEK
ATSC 8VSB DEMODULATOR Signal Modulation/Coding Conditions Modulation Roff-Off factor Symbols Rate Trellis Coding Interleaving Modes Reed Solomon Min. Typ. Max. Unit 8VSB 0.1152 10.762238MS/s Yes, 2/3 rates I = 52, J = 4 (207,187)GF 256, 8-Bits Symbols 65 -83 -8
Desired=-53dBm,UD=DTV Desired=-68dBm,UD=DTV Desired=-53dBm,UD=NTSC Desired=-68dBm,UD=NTSC 15.5 15.5 2.5 2.5 -33 -40 -44 -48 -52 -56 Desired=-68dBm,UD=DTV or NTSC
Total RF+IF AGC range Sensitivity Maximum Input Level Co-channel Rejection (D/U Ratio)
dB dBm dBm dB
N+/-1 channel Rejection (D/U Ratio) Taboo channel Rejection (D/U Ratio) N+/-2 N+/-3 N+/-4 N+/-5 N+/-6 to N+/-13 N+/-14 N+/-15
Bust Noise
Desired=-68dBm,UD=DTV Desired=-68dBm,UD=NTSC
-57
-50 -50
Burst duration=165us,frequency=10Hz
-5
16 7.5 5 2 1 2 3 16
dB dB
E-mailsales@eardatek.com
MODELEDA-31054FFJRA
EARDATEK
QAM DEMODULATOR Signal Modulation/Coding Conditions ITU-T J.83 Annex B Min. 64/256QAM Typ. Max. Sensitivity 64QAM 256QAM C/N 64QAM 256QAM Adjacent Rejection 64QAM 256QAM 6.9MS/s, BER 2x10-4 -66dBm -62dBm Pin = -45dBm, 6.9MS/s, BER 2x10-4 24.0dB 30.0dB 26.5dB 32.5dB -25dB -21dB
6. APPLICATION NOTES
6.1 Tuner I2C interface
SCL SDA
TDA18219
DRX3933J
NIM1
I2C Master
9 8
SCL
SDAT1
TDA18219
SDA
DRX3933J
NIM2
EDA-31054
E-mailsales@eardatek.com
MODELEDA-31054FFJRA
EARDATEK
EDA-31054 series tuners comply to the 5V I2C-Bus specification. The host processor communicates with dual demodulator DRX3933J via an I2C -compatible interface and write/read PLL register via I2C repeater of demodulator DRX3933J . Dual demodulator I2C addresses are 0x52 and 0x54. Tuner PLL I2C address is 0xC2.Demodulator Crystal Frequency: 20.25MHz. Tuner PLL Crystal frequency: 16.0MHz.
6.2 Tuner PLL programming(I2C address:0xC0) Please refer to TDA18219 datasheet and the reference driver for the programming. 6.3 ATSC/QAM Demodulator Part DRX3933J Programming (I2C address: 0x52 and 0x54) Note: Please refer to DRX3933J datasheet and the reference driver DRX3933Jdrv.c for programming. The Demodulation is controlled via an I2C compatible serial interface. This interface does the following: Provides the means for an external I2C master to control the demodulation through the primary I2C port. Supports 7-bit device addressing Supports software based I2C masters with irregular clocking and long delays, as well as high speed I2C masters Provides a secondary I2C port to control an external slave device (e.g. tuner) Provides a way for a master on the primary interface to control the tuner slave device while blocking packets not addressed to the tuner device
Provides a means to power-down and awake the demodulation under control of a master on the first Interface. The device driver utilizes low-level read/write I2C functions to control the device. But the DVBT/DVBC/ATV/FM demodulator not only is a sophisticated device with multiple hardware blocks that can be controlled via programmable registers , but also has a built-in System Controller - a dedicated microcontroller that can dynamically control the various building blocks of the IC. So the complete driver software with the demodulation is provided to instead of the register map. The use of this driver necessary for the following reasons: Many settings are time critical and cannot be given in a random order. Many parameters (e.g., Signal Quality) are calculated by the software and are not available in registers that can be read. The driver uploads microcode (updates) to the demodulation after power-up. The driver provides the following functionality: Full initialization of the demodulator, including optional initialization of the tuner attached to the demodulator Standard selection and channel selection on the device, including optional programming of the tuner Gathering of status information and channel information from the device A complete channel-scanning framework.
E-mailsales@eardatek.com
MODELEDA-31054FFJRA
EARDATEK
When using the driver, application programmers or system integrators do not need to study the register maps of the demodulator. Instead, only the following steps are necessary: Setting-up a few simple data structures Passing the data structures to the driver using a few simple function calls. In this way, an application programmer can very quickly and easily achieve fully optimized demodulator performance.
TS output
RF out
E-mailsales@eardatek.com
MODELEDA-31054FFJRA
EARDATEK
8. EDA-31054FFJRA Tuner Pin Definition :
PIN No. 1 2 3 4 5,6,7 8 9 10 11 12 13 14,15,,21 22 23 24 25 26 27,28 29 30 31 32 33,34,,40 PIN NAME NC DC extension B1 B2 NC SDA SCL NC B3 NC B4 D01,D11,D71 CLK1 D/P 1 STR1 ERR1 RESET NC CLK2 STR2 D/P 2 ERR2 D72,D62,D02 PIN DESCRIPTION Not Connected. DC Power supply via RF_in port to external unit +3.3V Power Supply for RF Loopthrough and amplifier +3.3V Power Supply for PLL1 and PLL2 Not connected IC DATA Line IC CLOCK Line Not connected +3.3V Power Supply for Link IC Not connected +1.2V DC Power Supply for Link IC Parallel TS Output1 data lines. D71 is Serial TS Output1 data line No.1 Transport stream byte clock output. No.1 Data Mark Output1: Data Output, 0: Parity Output No.1 output of synchronization byte signal. No.1 Error mark: 1for the incorrect error occurred. Reset. Please input 0 for Reset. Not connected No.2 Transport stream byte clock output. No.2 output of synchronization byte signal. No.2 Data Mark Output1: Data Output, 0: Parity Output No.2 Error mark: 1for the incorrect error occurred. Parallel TS Output2 data lines. D72 is Serial TS Output2 data line
E-mailsales@eardatek.com
10
MODELEDA-31054FFJRA
EARDATEK
9. Dimension for mounting
EDA-31054FFJV Vertical Tuner Dimension:
1 1
6 1
3 . 9 6
5 . 7 2 1
3 . 9 3 . 0 4
m m 0 . 2 D
2 1
K E T A D R A E
0 1 8 . 1 7 . 3
8 . 2 4 5 . 0
0 4 * 0 5 . 8 0 2
1 . 2
1 . 4 2 . 4
E-mailsales@eardatek.com
5 0 . 5 2 4 . 4
7 . 3
4
3 1 2
6
5 4
2 1
7 9 6 0 1 8
0 1
9 73 35 33 31 93 27 52 23 12 29 71 15 31 11 1 0 4 6 3 2 3 8 2 4 2 0 2 6 1 2 1 8 3 4 2 0 3 6 2 2 2 8 1 4 1
11
MODELEDA-31054FFJRA
EARDATEK
EDA-31054FFJR Horizontal Tuner Dimension:
E-mailsales@eardatek.com
12