Escolar Documentos
Profissional Documentos
Cultura Documentos
1/4
WING-NEEDLE EDGING THIS IS A WING-NEEDLE DESIGN SET. PLEASE CHECK WITH YOUR DEALER THAT YOUR MACHINE CAN USE A WING-NEEDLE BEFORE PURCHASING THIS DESIGN SET Materials Hoop Size: 5 x 7 inches Wing-Needle for the wing-needle stitching - please get the correct one for your machine Normal Needle for the embroidery Marathon Threads according to Colour Chart 2 - 4 layers of Water-Soluble Stabilizer. (wss) I use 2 layers as it works for me. Half inch Ribbon of your own choice Polyester Cotton Fabric. Magic Tape/Pins/Fabric Adhesive. Please use for fabric placement on stabilizer. I prefer using a combination of Magic Tape and Pins Method 1. Hoop wss.
Wing-Needle Edging.htm
5/18/2011 / 10:47 AM
No title
2/4
3. Cut fabric a little larger than the design OR cut a strip of fabric the required length for continuous embroidery. Hold the Fabric in place firmly with Magic Tape, Pins or Fabric Adhesive.
Wing-Needle Edging.htm
5/18/2011 / 10:47 AM
No title
3/4
5. Trim the fabric back to the edging. 6. Now stitch the Satin-stitch edging.
7. Stitch the Ribbon Buttonholes where applicable. 8. Using the Colour-Chart stitch out the embroidery.
9. NOW change the normal embroidery needle to the Wing-Needle to do the Wing-Needle stitching.
Wing-Needle Edging.htm
5/18/2011 / 10:47 AM
No title
4/4
10. Complete the design. If doing continuous hooping - please use the Placement Method. 11. Rinse design to remove the wss. Dry and Press. Slit open Buttonholes and thread the ribbon through. Happy Stitching Bargainembstore http://www.bargainembstore.com
Wing-Needle Edging.htm
5/18/2011 / 10:47 AM