Escolar Documentos
Profissional Documentos
Cultura Documentos
Flatness tolerances
Flatne ss tole rance s for she e ts/plate s are indicate d in the table s down-be low and are e x pre sse d as a pe rce ntage of the le ngth L and /or the width W and/or the m e asure d chord le ngth L. De viation from flatne ss is m e asure d as shown in the figure s using a lightwe ight straighte dge and a fe e le r gauge , while the she e t or plate is re sting on an horizontal base plate concave side upwards. d = De viation from flatne ss l = le ngth of buck le (chord)
www.alumeco.com/Technical_information/Tolerances/Plate/sheet_tolerances.aspx?Printerfriendly=2
1/2
04/04/13
A lumeco A /S Nsbyve j 26 5000 O de nse C Danm ark Te le fon: +45 6617 8117 Fax : +45 6614 5871 Em ail: m ail@alum e co.dk
www.alumeco.com/Technical_information/Tolerances/Plate/sheet_tolerances.aspx?Printerfriendly=2
2/2