Prototype Dimensions Photo Sensor experiment Current Measurement will be available within the week Google Site - Find the speed at which the turbine will turn - Find at what distance will the prototype be from the source, 3D Desk Fan - characterizing the turbine speed as the prototype is affected by a controlled wind source.
Prototype Dimensions Photo Sensor experiment Current Measurement will be available within the week Google Site - Find the speed at which the turbine will turn - Find at what distance will the prototype be from the source, 3D Desk Fan - characterizing the turbine speed as the prototype is affected by a controlled wind source.
Direitos autorais:
Attribution Non-Commercial (BY-NC)
Formatos disponíveis
Baixe no formato PDF, TXT ou leia online no Scribd
Prototype Dimensions Photo Sensor experiment Current Measurement will be available within the week Google Site - Find the speed at which the turbine will turn - Find at what distance will the prototype be from the source, 3D Desk Fan - characterizing the turbine speed as the prototype is affected by a controlled wind source.
Direitos autorais:
Attribution Non-Commercial (BY-NC)
Formatos disponíveis
Baixe no formato PDF, TXT ou leia online no Scribd
2. Explored Different Characteristics of the New Prototype Turbine Speed Experiment Prototype Dimensions Photo Sensor Experiment Current Measurement 3. Google Site Will be available within the week AIMS – Find the speed at which the turbine will turn – Find at what distance will the prototype be from the source, 3D Desk Fan – characterizing the turbine speed as the prototype is affected by a controlled wind source Horizontal Arrangement Vertical Arrangement DATA For Cylinder Fan: Height = 20.5 cm Height from Bottom to middle = 10.5 cm Diameter = 16.3 cm Thickness of Fan Divisions = 0.2 cm Height of Each Division = 9.5 cm 36 Divisions equally spaced.
For Top Wood:
Width = 24.5 cm Length = 20.4 cm Thickness = 1.85 cm
For Side Wood:
Width = 20.6 cm Height = 17.3 cm Thickness = 4.2 cm The set up is done by connecting a 200 ohm resistance (load) in series with the Multi-Meter in order to make a suitable connection for the configuration. The experiment is done on both the motors available as connected in the prototype available. http://sites.google.com/site/ateneowindteam/