Escolar Documentos
Profissional Documentos
Cultura Documentos
com
www.orphancameras.com
Framesizermm
.24X36
P e r f o r a t e d f i l m w i d t h , m m .. .
Numberof framesfor one loading
.
,
,
.
.
.
,35
.36
Focalplaneshutterspeeds
.
a
www.orphancameras.com
.
.
I to l/1000s"8''
(automatic),
(byband)andslow
shutterspeed
28.3
r.l5
+2,5
KO 3.5x0.6
tlq
www.orphancameras.com
Lens
Nominal focal length, mm
Relative aperture range
Focusing range, m
Field of view, grades
Lens stiating thread
Lens mount thread for light
f ilters
Seat for sun shade,mm
Overall dimensionsof camera
without case,mm
Mass of camera without case' kg
INDUSTAR-50or JUPITER'8
50
50
tlz to Il22
f/3.5to f/16
I tO
r. oon
I tO
45
M39XI
45
M39XI
CnM35.5X0.5
937
.. @"
CnM40.5X0.5
o 42
143x88x94
0.6
0.7
www.orphancameras.com
www.orphancameras.com
www.orphancameras.com
www.orphancameras.com
I6-svn.iu'ril,'"*|ever;
I4-exposure,ir:Hjn#'ltjflTfil
button;
www.orphancameras.com
www.orphancameras.com
10
5 . I . C A M E R AL O A D T N G
Turn off the screwon the casebottom and remove
the camerafrom the case.
Raisetwo locking clips on the camerabase plate
and turn them as far- as they will go; mov6 the
coveralong its groovesand tdke it ofT the camera.
Placethe cassettewith film in the seat and put
it
'
on the cassette
spoolguide.
.
-of
Full the film end-out
the cassetteas long as to
the cameraedge,insert it in the take-upspoil slot.
see that a sprockettooth would enter a pdrforation
hole.
Insert the detachablecover into the cameraguide
groo.ves
a.qdmove it as far as it will go. GivE the
locking clips half a turn till stop anl then sink
them into their recesses.
set the shutter,-press
the releasebutton.on setting
the shutterthe film movesbv oneframe.To'advance
part of f ilm to' the f ilm gate set and
unexposed
releasethe shuttertwo times.
n
www.orphancameras.com
www.orphancameras.com
Before releasingthe shutter after the sec.ondsetting
set f igure "0". 6f titg exposurecounter dial against
the in?ex mark on the shutter setting lever.
lf ltre film is wound tightly in the cassette,the film
rewind knob will rotale when the shutter is b.ilg
u.t. Sfiouia the film be wound loose in the cassette,
itte t nob will fail to rotate at the initial frames.
Now vou can put the camera into its case' Do not
i;;g.f io tighien up the tripod screw in the case
bottom.
IG
5 . 2 .S HU T T E RS P E E DS E T TN
T2
5 . 3 .L E N SA P E R T U R ES E T T I N G
aperturevaluewith the indexmark (dot) by rotating
Matctra selected
the ring with an aperturescaleof JUPITER-8lens (or the ring with
the indexmark of INDUSTAR-50
lens).
For convenience
eachof the indicateillenseshas two equivalentaper'
ture scalesand two corresponding
indexmarks,
t3
www.orphancameras.com
www.orphancameras.com
5,4, FOCUSING
Objectshaving sharp contoursshouldbe selected
1,4
IOr IOCUSlng.
Watching through the range-viewfinder eyepiece,
turn the diopter adjustment lever to obtain the
sharpestimage of an object in the eyepiece.
In the centre of the viewfinder field of view there
can be seen a yellowish rectangle with a double
image of the object being viewed in it. Turn the lens
ring to match the two images of the same
focusing
-Keep
in mind that the image should be
object.
foCusedin the centre of the yellowish field.
The image can be focusedby the lens distancescale
calibrate-d in metres as well. In such a case the
distance to the object being photographedshould
be known beforehand.
The viewfinder enablesto see the limits of picture.
For correct framing bring your eye as close to the
eyepiece as possib-le;in do doing . the - yellowish
r6cfanele should be piaced in the ceitre of the viewf inderTietAof view. if the aboverules are not follo'
wed, framing is likely to be wrong i. e. the limits
www.orphancameras.com
15
www.orphancameras.com
5.5.PHOTOGRAPHING
To take a picture do the foltowing:
a) load the camera;
b) take the cap off the lens;
c) set the lens aperture (if required put a light
filter or a sun shadeon the lens);
d) set the shutter;,
e) set a required shutter speed;
f) watching through the eyepieceof the range-viewf inder, point the camera at the object, adjust the
eyepieceaccording to your eye and focus the lens;
g) smoothly press the shutter release button.
NOTE. When using shutter speeds slower than
ll30 s it is recommendedto mount the camera on
a tripod and to screw a cable release into of the
releasebutton bush.
16
5 . 6 .C A M E R A U N L O A D I N G
When the exposurecounter shows figure 36 rewind
the film into- the cassette.For this almr
a) remove the case;
b) turn the shutter disengaging bush in the clockwise direction as far as if will ko;
c) pull the film rewind knob up-wardsand rotate it
in the arrow direction till the feel of the applied
force indicatesthat the film end has left the take-up
spool;
d) take the cover of f the camera and remove the
cassette;
e) turn the shutter disengaging bush counter.
clockwiseas far as it will go.
lever lails to set in action the
If the shutter settine
-after
rewinding the film, turn
shutter mechanism
the releasebutton clockwise as faias it will go or
turn the shutter setting lever simultaneouslyholding
the sprocket. Set the shutter and relese it to check
the niechanismoperation.
Mount the cover on the camera or load the camera
cassette with f ilm according to pawith another"Camera
loading".
ragraph 5.1.
www.orphancameras.com
T7
www.orphancameras.com
6.1.SELF-TIMEROPERATIN9
The self-timeris used when one wishesto photographoneself.For this aim do the following:mount
the cameraon a tripod, set the shutterand set the
self-timerby turning the self-timerleverdownwards
as far as it will go.
Set a requiredapertureand shutterspeed;selectan
object and focus the lens.
Press the self-timer releasebutton and take your
place in front of the lens. The shutter operatesin
no lessthan 9 secondsafter pressingthe button.
Thb ZORKI-4K cameraallows to use flash lamps
when taking picturewith the help of the self-timer.
18
6 . 2 .P H O T O G R A P HNI G
WITH FLASH LAIITPS
To take pictures in conditions of poor illumination
ifmtt- iirfipr are used. For this aim plug a tip. of
;ilasdGtitp connectingcord into the iamera socket'
"M" of the synchro'
To use a flash bulb set letter
nization scale against the dot on the camera plate'
'is
to be used, letter :'X"
When an electronic flash
strouiAbL set against the index dot of the synchronization scale.
The shutter speed of USO is better to use when
when gating
photographing'with flash lamps, i:.!:.
"8" is not desi'
is f uli Handlcontrolled exposure
iabie when using ttash lanips, since a considerable
amount of stray Tight gets into the camera and may
result in a blurred image.
NOTE. When photographing without flash lamps,
the synchronizition 5cale position may be free.
19
www.orphancameras.com
www.orphancameras.com
6 . 3 .L E N S C H A N G I N G
z0
R E F E R E N CTEA B T E
of sensitivityunits of differentsensitometric
systemsfor photographic
rnaterialsof normal contrast(y:0.8*,1.0)
rocT-ASA 16 20 25 32 40 50 65 80 r00 130 160200 250 320 400 500
DIN
13 t4 15 16 t7 18 19 20 2t 22 23 24 25 26 27 28
Vneshtorgizdat
No. 5159M
Ord. 383
2T
www.orphancameras.com