Escolar Documentos
Profissional Documentos
Cultura Documentos
Department of Mechatronics
Subject: COMMUNICATION SYSTEM
Sub Code: 10MT665
QUESTION BANK
Chapter 1
1
With a neat block diagram explain the basic building blocks of a communication system.
Mention the Significance of Fourier Series and Fourier Transform in communication system..
10
Chapter 2
11
12
Write a note on thermal noise. And mentions properties of thermal noise voltage
Define noise figure .derive noise figure of a two part device.
Chapter 3
19
Briefly explain the generation of AM using square law modulator giving relevant waveforms
24
A transmitter radiates 35kw,when =85, calculate the carrier power & power of each SB.
33
An audio frequency b/g 10 sin [2 X10 5t] . assume the modulation index 0.2. calculate the side
band frequency, amplitude of each side band, bandwidth & total power delivered through a load of
600 .
32.
Derive equations for modulation index, efficiency and total power carried for a single tone
amplitude modulation.
39. The antenna current of an AM transmitter is 8 A when only the carrier is sent, but it increases
to 8.93 A when the carrier is sinusoidally modulated. Determine the antenna current when the
depth of modulation is 0.8.
40. When a broadcast AM transmitter is 50% modulated, its antenna current is 12 A. What will the
current be when the modulation depth is increased to 0.9?
41. The input impedance at the base of a certain 10 kW commercial broadcasting station antenna
is 50 resistive. For single-tone modulation, the rms ammeter at the base of the antenna reads
16 A. Determine the percentage of modulation.
42. A certain transmitter radiates 9 kW with the carrier unmodulated, and 10.125 kW when the
carrier is sinusoidally modulated. Calculate the modulation index. If another sine wave,
corresponding to 40 percent modulation, is transmitted simultaneously, determine the total
radiated power.
43. The antenna current of an AM broadcast transmitter modulated to a depth of 40% by an audio
sine wave, is 11 A. It increases to 12 A as a result of simultaneous modulation by another
audio sine wave. What is the modulation index due to this second wave?
44. A 360-W carrier is simultaneously modulated by two audio waves with modulation
percentages of 55 and 65, respectively. What is the total sideband power radiated?
45. The output current of a 60% modulated AM generator is 1.5 A. To what value will this current
be if the generator is modulated additionally by another audio wave whose modulation index
is 0.7? What will be the percentage power saving if the carrier and one of the sidebands are
now suppressed?
46. A 60 dB AM transmitter is to be modulated simultaneously by two audio waves of indices 0.5
and 0.7. What is the total current if the antenna resistance is 75?
47. An SSB transmission contains 80 kW. It is required that the system be replaced by a standard
amplitude-modulated signal with the same power content. Determine the power content of
each of the sidebands in the new system if the percentage modulation is 80%.
48. The antenna current of an AM broadcast transmitter modulated to a depth of 38.5% by an
audio wave is 10.5 amperes. It increased by 4% as a result of simultaneous modulation caused
by another wave. Determine the percent modulation caused by the second wave.
49. At a certain depth of modulation, the power used is 22% of the total power when the carrier is
suppressed. If another simultaneous wave is added and the carrier and one of the sidebands are
suppressed, the power saved is 85%. What are the modulation indices?
50. For a modulating signal of maximum bandwidth 20kHz and a carrier frequency of 2Mhz
calculate the minimum and maximum frequencies when the signals are amplitude modulated
by the following methods
a.
DSB-AM
b.
DSB-SC
c.
SSB-AM
51. Calculate the modulation index of a carrier waveform of amplitude 10V and a sinusoidal
modulating signal of 3.5V
52. Describe the diode demodulator and explain the function of each component. Why cannot a
normal diode such as the 1N4148 be used as a demodulator?
53. Describe the operation of the ring modulator. What will happen if the diodes are mismatched?
Draw diagrams how the AM waveforms are produced.
54. A square wave of amplitude 2V will be Amplitude modulated with a carrier waveform of
amplitude 6V. Calculate the resultant modulation index.
55. Explain how message signal can be
receiver.
detected from AM
56. Give Time Domain and frequency domain Equation for AM.
57. Derive Time and frequency Domain Equation For DSBSC
Chapter 4
58. Explain the non linearity modulation in FM
59. Explain FM stereo multiplexing.
60. Give the CARSONs rule for finding BW in FM
61. Write a note on generation of FM signal using Direct method.
62. Write a note on generation of FM signal using indirect method.
63. Write Time domain Equation of Narrowband FM
64. Write Time domain Equation of Wideband FM
65. Write Frequency domain Equation of Narrowband FM
66. Write Frequency domain Equation of Wideband FM
67. Give the Difference between Narrow band and Wideband FM
Chapter 5
68. Explain Detection of message signal from FM signal using PLL.
69. Explain Detection of message signal from FM signal using indirect method.
70. Explain Slope detector method of finding Message signal from modulated signal.
Chapter 6
71. Explain TDM in detail.
72. Discuss in brief working PCM.
73. Show that quantization SNR for sinusoidal s/g is 1.8 + 6N.
74. A 10 khz sinusoidal with amplitude IV peak is quantized to have SNR of about 45db. Find the
number of both required/sample, bit rate and B.W.
75. A telephone s/g with B.W 4KHZ is digitized into an 8 bit PCM Sampled at nyquist rate.
Calculate PCM transmission B.W .
76. Explain the delta modulation.
77. Write a note on Quantization noise
78. Find the Signal to quantization noise ratio for Sinusoidal message signal.
79. Give the difference between uniform and non uniform quantization.
80. Show that quantization SNR for sinusoidal s/g is 4.8 + 6N.
81. Give the difference between midtread and mid raiser Quantization.
82. Explain A-Law and U- Law
83. Give the Drawback of uniform Quantization.
84. Encode the bits 11001011 using i) Manchester code ii) NRZ-R
85. Explain Robust Quantization.
Chapter 7
86. Find the Probability error of BASK
87. Find the Probability error of BFSK
88. Find the Probability error of BPSK
89. Find the Probability error of BQPSK
90. Explain the Transmitter and Receiver of BASK
91. Explain the Transmitter and Receiver of BPSK
92. Explain the Transmitter and Receiver of BFSK
93. Explain the Transmitter and Receiver of BQPSK
Chapter 8
94. What is RADAR? Explain in brief with block diagram blocks present in RADAR.
95. With a neat block diagram explain monochrome TV transmitter & receiver.
96. Give the RADAR Range Equation.
97. Explain the Working concept of RADAR
98. Explain Color TV transmitter and Receiver
99. Explain RADAR Transmitter .
100.Explain RADAR Receiver.