Escolar Documentos
Profissional Documentos
Cultura Documentos
A. STATIC ANALYSIS
Computation of Static Design Base Shear done by Program using the following formula,
where :
Seismic Zone Factor, z = 0.15 ( Zone 2A )
Soil Profile Type, S = SC ( Very Dense Soil and Soft Rock )
Ca = 0.18 ( Acceleration Seismic Coefficient )
Cv = 0.25 ( Velocity Seismic Coefficient )
Importance Factor, I = 1.0 ( Special Occupancy Structures )
Overstrength Factor, R = 5.5 ( Building Frame System / Shear Wall / Concrete )
Structure Period, T = Method B ( Program Calculated )
Seismic Weight, W = Wd (Dead load only)
B. DYNAMIC ANALYSIS
Computation of Dynamic Design Base Shear done by Program using the UBC ' 97 Response
Spectrum curve with the following site specific values,
WIND LOAD;
CODE REFERENCE : ASCE-2002
Computation of Design Wind Pressure done by Program using the following data:
Method 2-should be used
Basic wind Speed ( V ) = 45 m/sec =(105 mph)
Exposure category = C
Importance factor ( I ) = 1
Directional factor ( Kd ) = 0.85
External pressure coefficient (Cp) = 0.8 / 0.5 windward /leeward
Topograghical factor (Kzt) = 1
Gust factor = as per ASCE code
the four wind load cases stated in the code are considered