ASTM specifications are presumed to be cheaper and easier to procure than the corresponding ASME specifications, which are also acceptable. Where metric sizes are required, specify the metric version e.g. ASTM A 27 becomes ASTM F 568M grade 8. Bolt blanks are also suitable.
ASTM specifications are presumed to be cheaper and easier to procure than the corresponding ASME specifications, which are also acceptable. Where metric sizes are required, specify the metric version e.g. ASTM A 27 becomes ASTM F 568M grade 8. Bolt blanks are also suitable.
Direitos autorais:
Attribution Non-Commercial (BY-NC)
Formatos disponíveis
Baixe no formato DOCX, PDF, TXT ou leia online no Scribd
ASTM specifications are presumed to be cheaper and easier to procure than the corresponding ASME specifications, which are also acceptable. Where metric sizes are required, specify the metric version e.g. ASTM A 27 becomes ASTM F 568M grade 8. Bolt blanks are also suitable.
Direitos autorais:
Attribution Non-Commercial (BY-NC)
Formatos disponíveis
Baixe no formato DOCX, PDF, TXT ou leia online no Scribd
C steel Casings Sheet ASTM A 1011 CS Type B C or C Mn All Plate ASTM A 36 steel Plate ASTM A 572 - 50 (4 ) Rolled sections ASTM A 36 Rolled sections ASTM A 572 - 50 (4 ) Round bar AISI 1021 Forgings ASTM A 668 class D ( 9) Castings ASTM A 27 grade 65-35 Tiebar pins Bolt blanks ASTM F 568M grade 8.8 (2, 7) Bolts Bolts ASTM A 325 type 1 (2, 5)
1 Cr 0.5 Mo All Plate ASTM A 387-11 class2
Bar ASTM A 739 – B 11 (3) Forgings ASTMA 182-F12class2 Pins, Slings Round Bar ASTM A 193 - B16 (2, 8)
2.25 Cr 0.5 Mo All Plate ASTM A 387-22 class2
Bar ASTM A 739 - ·B22 (3) Forgings ASTM A 182-F22class3
Austenitic Low Sheet, Plate ASTM A 666 – 304 (6)
strength Bolt ASTM A 193 - B8 class1 High Sheet, Plate ASTM A 666 – 316 (6) strength Bolt Special consideration
Notes(l) It is presumed ASTM specifications are cheaper and easier to
procure than the corresponding ASME specifications, which are also acceptable. Where metric sizes are required, specify the metric version e.g. ASTM A 27 becomes ASTM A 27M. (2) Must not be welded, even to retain nuts. Supplied quenched & tempered. Must be re- heat-treated after hot or cold working to restore properties. (3) Round or rectangular bar. (4) When strength rather than deflection or vibration is the critical criterion. Check availability for small quantities. (5) Where small (up to 1~") inch series bolting is suitable and does not interface with standard metric parts. Otherwise use metric ASTM F 568M grade 8.8 bolts. (6) In the annealed condition. The same material to ASTM A 240 may also be specified. (7) Use ISO metric sizes to avoid redesigning interfacing standard parts. Table 2.1.2(2) bolt blanks are also suitable. (8) With a supplementary requirement that the minimum 0.2% proof stress at room temperature is 640 MPa. (9) With supplementary requirement S4 if welding is intended. Note that as this could result in higher carbon than European practice, an appropriate welding procedure should be used.