Escolar Documentos
Profissional Documentos
Cultura Documentos
Sandy, UT 84070
P: 801.872.7976
F: 801.841.3393
S T R AT E G I C A L LY E N G I N E E R E D E: info@rukse.com
INSTRUCTIONS:
1) Raise front of vehicle and support with 3/8” Nylock Nut 3/8” USS Flat
jack stands. Washer
3/8” x 1 1/2” Bolt 90-2039 Spacer
2) Remove factory sway bar links, a tie rod
puller may assist in removing the tapered
stud type of upper mount. The lower Frame Sway Bar End
factory bolt will be re-used.
3/8” Nylock
3) Install bushing and sleeves into new Nut
links.
3/8” SAE
4) Install adapters onto sway bar as 3/8” x 2 1/2” Bolt Washer
shown, note offset of mount to provide
clearance on driver side between sway
bar and frame. 3/8” ID Sleeve
NOTE: On vehicles with stem mount Driver Side View
sway bar links the spacer 90-2039 will From Front of
be installed in the hole in the end of the Vehicle
sway bar. Late model vehicles with the
articulating stud will not use the
90-2039. Do not tighten hardware. Factory Bolt
Replace in same
5) Install sway bar extension links on to Stock
Direction as Removed
adapter, it will be necessary to rotate Lower
adapter to install bolts. Install lower Mount
factory bolts and tighten all hardware.