Você está na página 1de 1

ASSEMBLY/INSTALLATION INSTRUCTIONS

FIXTURE HOOD
1. Before beginning the assembly/installation, carefully
unpack and identify parts, referring to the illustration.

2. Turn the electrical power to the installation point OFF


at circuit breaker.

3.Locate the CAGE onto the BAR and make the STUDS
through the holes on the BAR. Thread the LOCK
BALLS onto the STUDS and hand tighten until snug to
LOCK SCREW secure the CAGE.

4.Slip down the GLASS PANEL to the inside of the CAGE.


TAB Locate the TABS onto the top edge of the GLASS
PANEL and match the holes on them with the mounting
holes on the top edge of the CAGE. Use screw driver,
thread the LOCK SCREWS into the mounting holes
and hand tighten until snug to secure the GLASS
GLASS PANEL PANEL.

5. Install the Lamp into the Socket Base by aligning the


pins on the Lamp with the keyholes in the Socket Base.
Once they are aligned, gently push the Lamp into the
keyholes and twist the Lamp to lock it in place.

6.Locate the FIXTURE HOOD onto the top edge of the


CAGE and match the mounting holes on the bottom of
it with the holes on the top edge of the CAGE. Use
screw driver, thread the LOCK SCREWS into the
LOCK
mounting holes and hand tighten until snug to secure
SCREW them.

CAGE 7.Carefully fit the POST FITTER over the end of the
POST(not supplied), making sure the POST FITTER is
fully seated. Mark the drill point for the (3)MOUNTING
SCREWS, using (3)MOUNTING HOLES as reference.
After marking hole locations, remove FIXTURE from
STUD POST and drill 1/8" pilot holes for screws.

8. Making the wiring connections:


Using wire connectors (not supplied), connect the
WHITE SUPPLY WIRE from the POST to the WHITE
LAMP FIXTURE WIRE; connect the BLACK (or RED)
SUPPLY WIRE from the POST to the BLACK FIXTURE
WIRE. Connect the SUPPLY GROUND WIRE to the
SOCKET BASE FIXTURE GROUND WIRE. Wrap each connection with
approved electrical tape.
BAR
9. Coat the top 1" of the CLEAR SILICONE CAULK (not
supplied) and position the POST FITTER onto the
POST. Be sure to seat it completely, aligning the holes
in the FITTER with the 1/16" PILOT HOLES drilled into
(3)SCREWS LOCK BALL the POST. Secure the FIXTURE to POST with
(3) MOUNTING SCREWS (supplied).
POST FITTER
FIXTURE SUPPLY 10. Restore power to installation point ON. Retain this
WIRES and sheet for future reference.
HOUSE SUPPLY WIRES GROUND WIRE
and GROUND WIRE

POST(not supplied)
This fixture includes a photo cell, which is an automatic daylight shut-off
switch.

Please call our toll-free Consumer Hotline if you have


IF IN DOUBT ABOUT ELECTRICAL INSTALLATION, questions about this product: 1-800-645-3184 IS-HC9011FL
CONSULT A LICENSED ELECTRICIAN! Revised 2005- 02- 14

Você também pode gostar