Escolar Documentos
Profissional Documentos
Cultura Documentos
page 1 of 5
FamilyFun FamilyFun.com
page 2 of 5
FamilyFun FamilyFun.com
page 3 of 5
Step 2: Fold each bell along the center dashed line and cut out the bell along the outer dashed grey line. Do this for all 4 bells. Then cut out both of the round clappers.
Step 4: Unfold one bell and place it (picture side down) on a table or at surface. Cover the left folded side with glue.
Step 5: Cut a thin piece of ribbon or string about 14 inches long. Place the ribbon or sting onto the glued surface as close to the middle as possible. Place it so that about an inch and a half sticks out at the bottom of the bell and the rest sticks out of the top.
FamilyFun FamilyFun.com
page 4 of 5
Step 7: Place another bell (picture side down) on a table or at surface. Spread glue onto the right half of the bell. Next, place the long half of the ribbon or string onto the glued surface as close to the middle as possible, this should create a loop between the bells.
Step 8: Place the fourth bell (picture side up) onto the bell with the glue. Press down so that the ribbon sticks between those 2 bells. Fold back the aps that are not glued together.
Step 9: Spread glue over the remaining blank sides of the bells. Then bring the bells together so that the edges match up. Press rmly so the bell stays together.
FamilyFun FamilyFun.com
page 5 of 5
FamilyFun FamilyFun.com
page 1 of 4
FamilyFun FamilyFun.com
page 2 of 4
FamilyFun FamilyFun.com
page 3 of 4
Step 2: Fold each piece of the ornament along the middle dashed line so the picture is on the outside. Next cut out all 3 reindeer ornament pieces along the outer dashed line.
page 1 of 5
FamilyFun FamilyFun.com
Step 3: Cut a ribbon or sting about 9 inches long. Fold the string in half and tape or staple it together at the ends.
Step 4: Unfold one ornament piece and place it (picture side down) onto a table or at surface. Cover the left side of the ornament piece with glue. Place the end of the ribbon or sting into the glue as close to the center of the ornament as possible and press down rmly.
FamilyFun FamilyFun.com
page 4 of 4
Step 6: Spread glue onto the remaining white aps of the ornament, then press the last reindeer piece of the ornament into the glue so that the edges match up. Your ornament is nished!
FamilyFun FamilyFun.com