Escolar Documentos
Profissional Documentos
Cultura Documentos
7:2009
AS/NZS 3750.7:2009
AUSTROADS
This is a free 6 page sample. Access the full version at http://infostore.saiglobal.com.
COPYRIGHT
© Standards Australia/Standards New Zealand
All rights are reserved. No part of this work may be reproduced or copied in any form or by
any means, electronic or mechanical, including photocopying, without the written
permission of the publisher.
Jointly published by Standards Australia, GPO Box 476, Sydney, NSW 2001 and Standards
New Zealand, Private Bag 2439, Wellington 6020
PREFACE
This Standard was prepared by the Joint Standards Australia/Standards New Zealand
Standards Committee CH-003, Paints and Related Materials to supersede
AS/NZS 3750.7:1994.
The objective of this Standard is to specify requirements for aluminium paint used on steel
structures. It forms part of a series of product standards for paints referred to in
AS/NZS 2312, Guide to the protection of structural steel against atmospheric corrosion by
the use of protective coatings.
The terms ‘normative’ and ‘informative’ have been used in this Standard to define the
application of the appendix to which they apply. A ‘normative’ appendix is an integral part
of a Standard, whereas an ‘informative’ appendix is only for information and guidance.
This is a free 6 page sample. Access the full version at http://infostore.saiglobal.com.
3 AS/NZS 3750.7:2009
CONTENTS
Page
APPENDICES
A PURCHASING GUIDELINES.................................................................................... 9
B INFORMATION ON THE USE AND APPLICATION OF ALUMINIUM PAINT.. 10
C MEANS FOR DEMONSTRATING COMPLIANCE WITH THIS STANDARD ..... 11
D REFERENCED DOCUMENTS ................................................................................ 13
E PREPARATION OF PANELS FOR TESTING RESISTANCE TO WATER AND
WEATHERING......................................................................................................... 15
AS/NZS 3750.7:2009 4
1.1 SCOPE
This is a free 6 page sample. Access the full version at http://infostore.saiglobal.com.
This Standard specifies requirements for a single pack bright aluminium finish paint
intended to protect iron and steel against corrosion. It may be suitable for application by
brush, roller or spray. This paint will provide heat reflectance and medium-term protection
from corrosion to suitably primed steelwork located in an industrial atmospheric
environment.
NOTES:
1 Appendix A contains recommendations and advice on information that should be provided by
the purchaser at the time of enquiry or order.
2 Care should be taken that aluminium paint is not used in an acidic or caustic environment.
Additional information on the use and application of aluminium paint is provided in
Appendix B.
3 Alternative methods for determining compliance with this Standard are contained in
Appendix C.
1.3 DEFINITIONS
For the purpose of this Standard, the definition below and those given in AS/NZS 2310
apply.
1.3.1 Aluminium paint
A finish coating designed to provide corrosion protection to suitably primed steel when
applied to a dry film thickness of 25–35 µm per coat.
COPYRIGHT
This is a free preview. Purchase the entire publication at the link below: