Escolar Documentos
Profissional Documentos
Cultura Documentos
AN7164
30 W BTL audio power amplifier
s Overview
The AN7164 is an integrated circuit designed for 30 W (VCC = 21 V, 8 ) output power amplifier. High power output (BTL 30 W), low distortion and low noise are realized. High reliability is obtained due to various kinds of protectors built in. Furthermore, on-off of output is possible from standby terminal.
7.70.3
Unit : mm
12 (10.0)
3.6
29.750.30
28.00.3
20.00.3
(1.27)
(1.3)
R1.8
High power output Low distortion, Low noise Low shock noise when power supply is turned-on, off Built-in standby function Built-in protection circuits (Temperature, Overcurrent, Load short circuit, Output GND short circuit)
0.6
s Features
(10.0)
+0.15
(12.5)
1.450.15
1.20.1
HSIP012-P-0000A
s Applications
Stereo, Karaoke, TV
s Block Diagram
11
12
VCC
Input circuit
Driver circuit
10
Ripple filter
Protection circuits for Temp. Overcurrent, Load short, Output-GND short SEPP output circuit 7
Input circuit
Driver circuit
GND
GND
1.800.15
3.50.3
29.60.3
AN7164
s Pin Descriptions
Pin No. 1 2 3 4 5 6 Ripple filter Negative feedback (ch.2) GND (Input side) Negative feedback (ch.1) Input Standby Description Pin No. 7 8 9 10 11 12
Description Output (ch.1) Bootstrap (ch.1) GND (output side) Output (ch.2) Bootstrap (ch.2) Supply voltage (VCC)
Unit V A W C C
Note) *1 : Ta = 25C except power dessipation, operating ambient temperature and storage temperature. *2 : Without signal *3 : j-c = 2.0 (C/W)
Min 49.5 24 45
Unit mA mV mV % dB W dB A
Note) *1 : Measurement through the DIN audio filter. *2 : Power supply ripple 120 Hz Sine wave, 1V[rms]
AN7164
Standby-on (i.e. an application of 5 V to pin 6) under a high temperature may cause no-output due to the malfunction of rapid discharging circuit of the ripple filter. To avoid this, it is necessary to forcibly flow a current of 1 mA into pin 1 at standby-on.
s Technical Information
PD Ta curves of HSIP012-P-0000A PD T a
65 62.5 60 55 50 Infinite heat sink Rth (jc) = 2C/W Rth (ja) = 42C/W
12
11 10 100 F 2.2
0V 5V
This datasheet has been download from: www.datasheetcatalog.com Datasheets for electronics components.