Quick Reference Guide
To use, bend the manual back and
match the desired chapter below against
the block spot showing at the edge of
thaws pages =p
General Information E ]
Scheduled Maintenance BB
; Engine BEY
Non-scheduled
Chassis
Maintenance
|
| Electrical BB
Engine mG
Disassembly
Chassis Ed
Appendix E)
Supplement-1984 Model E)
Supplement-1985 Model E JSAFETY AWARENESS
Whenever you see the symbols shown below, heed
their instructions! Always follow safe operating and
maintenance practices.
This warning symbol identifies special instructions or
procedures which, if not correetly followed, could
result in personal injury, or loss of life,
‘This caution symbol identifies special instructions or
procedures which, if not strictly observed, could result
in damage to or destruction of equipment.
“NOTE"
This note symbol indicates points of particular interest
for more efficient and convenient operation.
LIST OF ABBREVIATIONS
ABDC
AC
ATDC
BBDC
BDC
BTDC
ampere(s) Ib pound(s)
after bottom dead center m meter(s)
alternating current min minute(s)
after top dead center N newton(s)
before bottom dead center Pa pascall(s)
bottom dead center Ps horsepower
before top dead center psi pound(s) per square inch
degree(s) Celcius r revolution
direct current rpm revolution(s) per minute
faradt(s) TDC top dead center
degree(s) Fahrenheit TIR total indicator reading
foot, feet v volt(s)
gram(s) w watt(s)
hour(s) 2 ohms)
liter(s)
Read OWNER’S MANUAL before operating