Escolar Documentos
Profissional Documentos
Cultura Documentos
Parrot Bluetooth car kits Cable adapter guide For Ford vehicles
The cable adapter listed in this document can used to install following Parrot car kits and are available through Halo:
Parrot CK3000Evolution
Parrot MK6000
Use this document to check the cable adapter you would need to order to install seamlessly a Parrot kit in a Ford vehicle.
07/08/2007
1/11
See page 5 and 6 for connection diagrams. See page 9 for more information on the pin out.
07/08/2007
2/11
See page 5 and 6 for connection diagrams. See page 10 for more information on the pin out.
07/08/2007
3/11
See page 5 and 6 for connection diagrams. See page 11 for more information on the pin out
07/08/2007
4/11
07/08/2007
5/11
Same procedure for Parrot MK6000 Please note that there is no separate microphone to install with the 3200LS-Color PLUS. This diagram is showing an installation using the Parrot mute-box. A line-in output is also available on the Parrot 3200LS and MK6000. Please refer to the technical documentation of the radio for a connection through the line-in.
07/08/2007
6/11
If you install a car kit with display, you should read the message good bye on your display when turning off ignition after a few seconds. For all other kits, you can control the LED status (turned off after a few seconds) or the disconnection with a previously paired mobile phone. If not, invert polarity as shown on the picture.
07/08/2007
7/11
Additional pining information MK6000 and 3200LS (on kit connector side)
07/08/2007
8/11
07/08/2007
9/11
07/08/2007
10/11
07/08/2007
11/11