Escolar Documentos
Profissional Documentos
Cultura Documentos
1.2
Relevant identified uses of the substance or mixture and uses advised against
Identified uses : Laboratory chemicals, Manufacture of substances
2. 2.1
HAZARDS IDENTIFICATION Classification of the substance or mixture Classification according to Regulation (EC) No 1272/2008 [EU-GHS/CLP]
Skin irritation (Category 2) Eye irritation (Category 2) Specific target organ toxicity - single exposure (Category 3)
2.2
Signal word Hazard statement(s) H315 H319 H335 Precautionary statement(s) P261 P305 + P351 + P338
Warning
Causes skin irritation. Causes serious eye irritation. May cause respiratory irritation.
Avoid breathing dust/ fume/ gas/ mist/ vapours/ spray. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. none
R-phrase(s) R22 R36/37/38 S-phrase(s) S26 S36 Harmful if swallowed. Irritating to eyes, respiratory system and skin.
In case of contact with eyes, rinse immediately with plenty of water and seek medical advice. Wear suitable protective clothing.
2.3 3. 3.1
: :
3-Chloropropan-1-ol
CAS-No. EC-No. 627-30-5 210-992-9 -
4. 4.1
If inhaled
If breathed in, move person into fresh air. If not breathing, give artificial respiration. Consult a physician.
If swallowed
Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Rinse mouth with water. Consult a physician.
4.2
4.3
5. 5.1
5.2
5.3
5.4
Further information
Use water spray to cool unopened containers.
6. 6.1
ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures
Use personal protective equipment. Avoid breathing vapors, mist or gas. Ensure adequate ventilation. Remove all sources of ignition. Evacuate personnel to safe areas. Beware of vapours accumulating to form explosive concentrations. Vapours can accumulate in low areas.
6.2
Environmental precautions
Prevent further leakage or spillage if safe to do so. Do not let product enter drains.
6.3
6.4
7.
7.1
7.2
7.3
8. 8.1
EXPOSURE CONTROLS/PERSONAL PROTECTION Control parameters Components with workplace control parameters
8.2
Skin protection
Handle with gloves. Gloves must be inspected prior to use. Use proper glove removal technique (without touching glove's outer surface) to avoid skin contact with this product. Dispose of contaminated gloves after use in accordance with applicable laws and good laboratory practices. Wash and dry hands. The selected protective gloves have to satisfy the specifications of EU Directive 89/686/EEC and the standard EN 374 derived from it.
Body Protection
impervious clothing, The type of protective equipment must be selected according to the concentration and amount of the dangerous substance at the specific workplace.
Respiratory protection
Where risk assessment shows air-purifying respirators are appropriate use a full-face respirator with multi-purpose combination (US) or type ABEK (EN 14387) respirator cartridges as a backup to engineering controls. If the respirator is the sole means of protection, use a full-face supplied air respirator. Use respirators and components tested and approved under appropriate government standards such as NIOSH (US) or CEN (EU).
9. 9.1
PHYSICAL AND CHEMICAL PROPERTIES Information on basic physical and chemical properties
a) Appearance Form: clear, liquid Colour: colourless b) c) d) e) f) Odour Odour Threshold pH Melting/freezing point Initial boiling point and boiling range Flash point Evaporation rate no data available no data available no data available no data available 160 - 162 C - lit.
g) h) i) j)
explosive limits k) l) Vapour pressure Vapour density no data available no data available 1,131 g/cm3 at 25 C no data available no data available
m) Relative density n) o) Water solubility Partition coefficient: noctanol/water Autoignition temperature q) Decomposition temperature r) s) t) Viscosity Explosive properties Oxidizing properties
p)
no data available
no data available
9.2
10. 10.1
10.2
Chemical stability
no data available
10.3
10.4
Conditions to avoid
Avoid moisture. Heat, flames and sparks.
10.5
Incompatible materials
Strong oxidizing agents, Strong acids, Strong bases
10.6
11. 11.1
Skin corrosion/irritation
no data available
Carcinogenicity
IARC: No component of this product present at levels greater than or equal to 0.1% is identified as probable, possible or confirmed human carcinogen by IARC.
Reproductive toxicity
no data available
Aspiration hazard
no data available
Potential health effects Inhalation Ingestion Skin Eyes Signs and Symptoms of Exposure
To the best of our knowledge, the chemical, physical, and toxicological properties have not been thoroughly investigated. May be harmful if inhaled. Causes respiratory tract irritation. May be harmful if swallowed. May be harmful if absorbed through skin. Causes skin irritation. Causes serious eye irritation.
Additional Information
RTECS: UA8930000
12. 12.1
12.2
12.3
Bioaccumulative potential
no data available
12.4
Mobility in soil
no data available
12.5
12.6
13. 13.1
Contaminated packaging
Dispose of as unused product.
14. 14.1
14.2
14.3
14.4
Packaging group
ADR/RID: III IMDG: III IATA: III
14.5
Environmental hazards
ADR/RID: no IMDG Marine pollutant: no IATA: no
14.6
15.
REGULATORY INFORMATION
This safety datasheet complies with the requirements of Regulation (EC) No. 1907/2006.
15.1
Safety, health and environmental regulations/legislation specific for the substance or mixture
no data available
15.2
16.
The above information is believed to be correct but does not purport to be all inclusive and shall be used only as a guide. The information this document is based on the resent state of our knowledge and is applicable to the product with regard to appropriate safety precautions. It does not represent any guarantee of the properties of the product. guidechem shall not be held liable for any damage resulting from handling or from contact with the above product. See reverse side of invoice or packing slip for additional terms and conditions of sale.