Escolar Documentos
Profissional Documentos
Cultura Documentos
Boss
Use this option to create a boss on a planar surface or datum plane.
Basic Parameters of a Boss Where do I find it? Toolbar FeatureBoss Menu InsertDesign FeatureBoss
Boss
drive24ward (meslab.org/mes)
Create a boss
1. From the Boss dialog select a planar placement face or datum plane on which to locate the boss. The system displays a preview in the graphics window of the boss and its dimensions using the current parameters. If you selected a datum plane, you can use the Reverse Side Boss button to switch the direction of the vector. Note You can enter values for the parameters discussed in the following steps before you select the planar placement face. Note When you change a value in one of the parameter fields discussed below, pressing the Return or Enter key updates the graphics window preview of the boss with the new value. 3. 4. 5. 6. 7. Enter a value for the Diameter. Enter a value for the Height. Enter a value for the Taper Angle. When you are ready to create the boss, click OK or Apply. Use the Positioning dialog to precisely locate the boss.
Boss
drive24ward (meslab.org/mes)
Boss
drive24ward (meslab.org/mes)