Escolar Documentos
Profissional Documentos
Cultura Documentos
Service, Wrtsil Finland Oy Engine section 05 Maintenance tools Engine type Ref. WFIS Date Issue Document No. 3205S057GB Page 1(2)
W32
28.06.2005 02
New design
Original design
800 158
New design
800 158 001
800 158
800 020
800 157
800 157 002
Do not stand in front of the hydraulic tools when operating them. Replace the screws and nuts of the original design before reaching 250 loading cycles. The screws and nuts of the new design must be replaced before reaching 1000 loading cycles.
P.O. Box 252 (Tarhaajantie 2) FIN-65101 Vaasa, Finland P.O. Box 50 (Stlarminkatu 45) FIN-20811 Turku, Finland
Telecop. +358 6 356 7355 Telecop. +358 6 356 7339 Telecop. +358 10 709 3279 Telecop. +358 10 709 3410
Contact your local Wrtsil Service Network office. Wrtsil Service Network and owners / operators of engines concerned. Until further notice, replacing issue 01 dated 14.03.2002.
2005 Wrtsil Finland Oy All rights reserved No part of this publication may be reproduced or copied in any form or by any means (electronic, mechanical, graphic, photocopying, recording, taping or other information retrieval systems) without the prior written permission of the copyright holder. Wrtsil Finland Oy makes no representation, warranty (express or implied) in this publication and assumes no responsibility for the correctness, errors or omissions for information contained herein. Information in this publication is subject to change without notice. Unless otherwise expressly set forth, no recommendation contained in this document is to be construed as provided due to a defect in the engine, but merely as an improvement of the engine and/or the maintenance procedures relating thereto. Any actions by the owner/operator as a result of the recommendations are not covered under any warranty provided by Wrtsil and such actions will thus be at the owners/operators own cost and expense. NO LIABILITY WHETHER DIRECT, INDIRECT, SPECIAL, INCIDENTAL OR CONSEQUENTIAL, IS ASSUMED WITH RESPECT TO THE INFORMATION CONTAINED HEREIN. THIS PUBLICATION IS CONFIDENTIAL AND INTENDED FOR INFORMATION PURPOSES ONLY.