Escolar Documentos
Profissional Documentos
Cultura Documentos
The output of an nFET is used to drive the gate of another nFET as shown in fig 2.1. Assume that Vdd = 3.3V and Vtn = 0.60V. Find the output voltage Vout when the input voltages are at the following values a) Va = 3.3V and Vb = 3.3V; b) Va = 0.5V and Vb = 3.0V; c) Va = 2.0V and Vb = 2.5V; d) Va = 3.3V and Vb = 1.8V.
Consider the 2-input XOR function a) Design an XOR gate using a 4:1 mux b) Modify the circuit of (a) to produce a 2-input XNOR. c) A full adder accepts inputs a, b and c and calculates the sum bit a (xor) b (xor) c Use your MUX- based gates to design a circuit with this output.
Design a CMOS logic gate for the function F = a.b + ac + bd Using smallest number of transistors.
Consider the logic described by the diagram in fig 2.2. A single, complex logic CMOS gate is to be designed for F. a) Construct the nFET array using the logic diagram. b) Apply bubble pushing to obtain the pFET logic. Then construct the pFET array using rules.
Fig 2.2 7 An AOAI logic gate is described by the schematic in fig 2.3 a) Construct the nFET array using the logic diagram. b) Apply bubble pushing to obtain the pFET logic. Use the diagram to construct the pFET rules.
Fig 2.3
A pFET logic array is shown in fig 2.4. Construct the logic diagram using the pFET logic equations. Then construct the nFET circuit.
Fig 2.4 9 Design the 4:1 multiplexor circuit that implements the function in equation of problem no. 8 by using TG switches
10
Use an AOI22 gate to design a 2:1 MUX. Inverters are permitted in your design
11
12
Suppose that Vdd = 5V and Vtn = 0.7V. Find the output voltage Vout of the nFET in Fig 2.5 for the following input voltage values a) Vin = 2V b) Vin = 4.5V c) Vin = 3.5V d) Vin = 0.7V
Fig.2.5
13
Consider the two- FET chain in fig 2.6. The power supply is set to a value of Vdd = 3.3V and the nFET threshold voltage is Vtn = 0.55V. Find the output voltage Vout at the right side of the chain for the following values of Vin a) Vin = 2.9V b) Vin = 3.0V c) Vin = 1.4V d) Vin = 3.1V.
14
Use smallest number of transistors in your design Design a CMOS logic circuit that implements F = a + b c + abc Using series-parallel logic. The objective is to minimize the transistor count Construct a CMOS logic gate for the function G = x ( y + z ) + y start with the minimum-transistor nFET network, and then apply bubble pushing to find the pFET wiring.
15
16