Escolar Documentos
Profissional Documentos
Cultura Documentos
2012 ZTE Corporation. All rights reserved. ZTE CONFIDENTIAL: This document contains proprietary information of ZTE and is not to be disclosed or used without the prior written permission of ZTE. Due to update and improvement of ZTE products and technologies, information in this document is subjected to change without notice.
TABLE OF CONTENTS
1 2 3 3.1 3.2 3.2.1 3.2.2 3.3 4 4.1 4.1.1 4.1.2 4.2 4.3 4.4 5 6 Overview ............................................................................................................ 4 Features ............................................................................................................. 5 System Architecture .......................................................................................... 6 Product Physical Structure ................................................................................... 6 Hardware Architecture ......................................................................................... 6 ZXV10 W300 LED................................................................................................ 6 ZXV10 W300 Interface ......................................................................................... 8 Software Function ................................................................................................ 8 Technical Specifications ................................................................................. 13 Physical Indices ................................................................................................. 13 Mechanical Dimension ....................................................................................... 13 Weight ............................................................................................................... 13 Power ................................................................................................................ 13 Working Environment ......................................................................................... 13 Cerfication.......................................................................................................... 13 Networking....................................................................................................... 15 Glossary ........................................................................................................... 16
FIGURES
Figure 3-1 Figure 3-2 Figure 3-3 Figure 5-1 ZXV10 W300 Structure ..................................................................................... 6 ZXV10 W300 LED............................................................................................. 6 ZXV10 W300 interface ...................................................................................... 8 ZXV10 W300 network topology chart ...............................................................15
TABLES
Table 3-1 Table 3-2 ZXV10 W300 LED............................................................................................. 7 ZXV10 W300 interface ...................................................................................... 8
Overview
ZXV10 W300 is an ADSL access device to support multiple line modes. It supports ADSL2/ADSL2+ and is backward compatible to ADSL, even offers auto-negotiation capability for different flavors (G.dmt, T1.413 Issue 2) according to central office DSLAMs settings (Digital Subscriber Line Access Multiplexer). It provides four 10/100Base-T Ethernet interfaces. It supports IEEE 802.11 b/g/n 1*1 Wi-Fi interfaces.
Utilizing the high-speed ADSL connection, the ZXV10 W300 can provide user broadband
connection to the Internet. Wi-Fi speed can up to 150Mbps.
Moreover, it also provides secure wireless encryption modes and firewall to protect network security and support remote network management through TR-069 and Web GUI.
Features
Support (G.dmt/T1.413/ADSL2/READSL2/ADSL2+) Supply 10/100BaseT Ethernet interface (MDI/MDIX) Support IEEE 802.11 b / g / n(1*1),speed up to 150Mbps Support Bridge or Router mode High reliability, easy to operate, low power consumption Support NAT/PAT Support UPnP Support configuration setting through Web GUI Support DHCP server Support virtual server
Optional
Backup the configuration file to the local computer and also can upload the saved file to ZXV10 W300
A wide input voltage range, can reach to 100V to 240V (base on linear power supply)
3
3.1
System Architecture
Product Physical Structure
Figure 3-1 ZXV10 W300 Structure
3.2
3.2.1
Hardware Architecture
ZXV10 W300 LED
Figure 3-2
Off Power Green/Red Red Flash Green On Off DSL Green Flash On Off Flash
Power off Software upgrade Power on No signals are detected The MODEM is trying to be in the activation status The MODEM has been activated. The system is under the Bridge mode or the ADSL has not been connected There are some data packets passing the MODEM The system is under the Route mode and the ADSL has been connected. The MODEM IP data packet can be normally transceiver (For example, the built-in PPPOE has been established and the dynamic IP address has been obtained). Device attempted to become IP connected and failed (no DHCP response, no PPPoE response, PPPoE authentication failed, no IP address from IPCP, etc.) The Ethernet interface is in the non-communication status Data is received or sent on the Ethernet interface The Ethernet interface is in the communication status The Wi-Fi interface is in the OFF status Data is received or sent on the Wi-Fi interface The Wi-Fi interface is in the ON status
Internet
Green
On
Red
3.2.2
Figure 3-3
Power interface. Connect it to the power adapter. Power switch Wi-Fi switch RJ-45 connection interface: Connect it to the PC computer or other network devices using the network cable. RJ-11 connection interface: The equipment is connected to the ADSL line or splitter via the telephone line. This button is on the bottom of modem. In the power-on state, you can restore the system to the default configuration by using a thin needle to press this slot for three seconds or for three executive times.
3.3
Software Function
Supports ADSL Standards ANSI T1.413 Issue 2 ITU G.992.1 (G.dmt) Annex A ITU G.992.2 (G.lite)
ITU G.992.3 (G.dmt.bis) Annex A/Annex L ITU G.992.5 Annex A ITU G.994.1 (G.hs) Fast path and Interleave path Dynamic rate adaptation
Supports ATM Feature Payload Encapsulation: PPPoE(RFC2516), PPPoA(RFC2364), Bridge, DHCP, STATIC, IPoA ATM cell over ADSL, AAL5 Multi Protocol over AAL5 (RFC 1483/2684) RFC 2684 Bridge RFC 2684 Route ATM Forum UNI 3.1/4.0 Permanent Virtual Circuits(PVCs) Supports UBR, CBR, rt-VBR and nrt-VBR traffic classes Supports VPI range 0-255, VCI range 32-65535 Up to 8 PVCs maximum RFC 2684 LLC- SNAP/VC MUX ITUT I.610 ATM OAM F4/F5 Loopback
PPP Function PAP(RFC 1334)/CHAP(RFC 1994) Multiple PPPoE sessions Always on/ On demand/ Manual connection
Wi-Fi Feature Operation Frequency:2.4GHz Support IEEE802.11g , IEEE802.11b and IEEE802.11n standards(1*1) Support WEP64/128 and WPA-PSK / WPA2-PSK Support Hide ESSID Support multiple ESSIDs Configure RTS/CTS; Fragmentation Threshold; Beacon Interval Support WMM Operating Channels:11 (US), 13 (Europe) IEEE 802.11i (Security) WDS (Optional) WPS(Optional) 802.1X (Optional) Muti-SSID (Optional) WiFi Community (Optional)
Security Denial of Service (DoS) protection: Ping of Death, SYN Flooding, ARP flooding, Spoofing, LAND, Smurf Prevent port scanning IP address filtering Mac address filtering Support URL filtering based on keywords; (Optional)
10
Port and protocol filtering Stateful packets inspection(SPI) DMZ, WAN access control Port forwarding (Virtual Sever) Http basic and digest authenticaton, certificate based authentication User Privilege: Administrator and User Support NAT and firewall enabling/disabling
IP QoS Supports packet classification based on: IP source address/IP source subnet mask IP destination address/IP destination subnet mask Destination TCP/UDP port number or range of port numbers MAC source address DSCP/TOS field Protocol type 802.1P and DSCP remarking based on packet classification 4 Priority Queue Strict Priority
11
Optional
Support User Access Levels Support CLI Support Telnet management Support TFTP and HTTP firmware upgrade Support TFTP and HTTP configuration file upload and download Factory setting reset Support system log Support F4/F5 SEG, ETE OAM Diagnostic Tool for ADSL and IP Ping Support manual upgrade of software and configuration through local web-based management interface
Support remote firmware and configuration upgrade accessible through web-based management interface and TR069 ACS
12
4
4.1
4.1.1
Technical Specifications
Physical Indices
Mechanical Dimension
145.0mm(L) x 107.6mm(W) x 29.3mm(H) (W300 case) 215mm(L) x 155mm(W) x 65mm(H) (W300 box)
4.1.2
Weight
206g (not include attachment and power adapter) 500g (include attachment and power adapter)
4.2
Power
The whole maximum power consumption is less than 5W .
4.3
Working Environment
Operating temperature: 0 ~40
Humidity: 20%~90%
~70
4.4
Cerfication
CE
13
Wi-Fi
14
Networking
Figure 5-1 ZXV10 W300 network topology chart
15
Glossary
Abbreviations AAL5 ADSL ATM BAS CHAP DHCP DNS DSL DSLAM IP ISP LAN LLC NAT PPP PPPoA PPPoE PVC TCP UPnP Full Characteristics ATM Adaptation Layer 5 Asymmetric Digital Subscriber Line Asynchronous Transfer Mode Broadband Access Serve Challenge Handshake Authentication Protocol Dynamic Host Configure Protocol Domain Name Server Digital Subscriber Line Digital Subscriber Line Access Multiplexer Internet Protocol Internet Service Provider Local Area Network Logical Link Control Network Address Translation Point-to-Point Protocol PPP over AAL5 PPP over Ethernet Permanent Virtual Circuit Transmission Control Protocol Universal Plug and Play
16