Escolar Documentos
Profissional Documentos
Cultura Documentos
1. Introduction:
Present day process plant piping systems use various fluids at various conditions of pressure and temperature. The piping engineer has to design the systems to ensure reliability and safety throughout designed plant life. The piping systems are subjected to combined effects of fluid internal pressure, its own weight and restrained thermal expansion. The elevated temperature also affects the pipe strength adversely. Therefore the task of the engineer is: i) to specify an adequate wall thickness to sustain the internal pressure with safety. ii) To select a piping layout with an adequate flexibility between points of anchorage to absorb its thermal expansion without exceeding allowable material stress levels, also reacting thrusts and moments at the points of anchorage must be kept below certain limits. iii) To limit the additional stresses due to the dead weight of the piping by providing suitable supporting system- effective for cold as well as hot conditions. All these objectives are achieved by: a) Assuming adequate support to prevent excessive sag and stresses in piping system. b) Incorporating sufficient flexibility to accommodate stress resulting from changes in pipe length due to thermal effects and movement of the connection at the ends of the pipe. c) Designing the piping system to prevent its exerting excessive forces and movements on equipment such as pumps and tanks or on other connection and support points. The stress engineer of a piping design department performs the necessary calculations to ascertain that the various requirements due to internal pressure, thermal expansion and external weight are satisfied. Various computer packages are available in the market, which perform the required rigorous analysis. These analyses are basically static analyses. There are situations where stresses are introduced into the piping systems due to dynamic loading situations like reciprocating compressor vibration, safety valve discharge etc. However it is the static analysis which most of the pipe stress engineers perform and are acquainted with. Now the present day computer packages that are being used (CEASAR-II, CAEPIPE, PIPEPLUS etc.) are quite comprehensive and if the piping configuration and pipe data are fed properly, comprehensive analysis are done through the computer packages. This has improved pipe stress analysis job productivity immensely. However sometimes this has led to a decline in the knowledge about the basics of pipe stress analysis especially in situation where the stress analysis engineer after acquiring some sort of skill in the use of the analysis package does not make effort to learn about the basics of pipe stress. Some of the ideas about the basics of pipe stress have been enumerated herein.
b) At elevated temperatures at which creep is more likely the stress in the pipe material shall itself to the rupture strength i.e. 8/5 th Sh = 1.6 Sh. Therefore stress range = 1.6f(Sc = Sh) However, the code limits the stress range conservatively as 1.25f(Sc + Sh) which includes all stresses i.e. expansion stress, pressure stress, hot stresses and any other stresses inducted by external loads such as wind and earthquake, f is the stress range reduction factor for cyclic conditions as given below: To determine the stress range available for expansion stress alone we subtract the stresses inducted by pressure stress and weight stress which itself cannot exceed sh. Therefore the range for expansion stress only is SA = f(1.25 Sc + 0.25 Sh) VALUES OF FACTOR f Total number of full f factor Temp. Cycles over expected life 7,000 and less 1 14,000 and less 0.9 22,000 and less 0.8 45,000 and less 0.7 100,000 and less 0.6 250,000 and less 0.5
Where Ai is inside cross sectional area of pipe, Am is the metal area, P is the pressure.
vendors are always equal to or greater the values as per the respective applicable code. Various computer packages now have equipment nozzle check features. However the pipe stress engineers are advised to study the specific applicable codes also as this will give them a further insight for solving specific problems related to equipment nozzle loading.