Escolar Documentos
Profissional Documentos
Cultura Documentos
Important!
This document contains information about Melco Control Panel Software, Release 2001-10. This information may not be included in the machine operation manual. Please read these release notes carefully before installing software on your machine. Thank You.
To check which MCPS program and RSA versions are currently running on your machine, perform the following simple procedure: 1. In the MCPS Control Panel screen, click the Advanced button. 2. The Program Version and RSA version numbers are identified in the upper left area of the Advanced screen which is now showing.
13348, Rev G
1 of 5
2 of 5
Installation Options:
As with many things, there is more than one way to accomplish a task. The same is true with installing updated embroidery machine software. Although Melco recommends the first installation option, we realize you may want to use the alternate second option. Refer to the attached pages for the two installation options available for reinstalling this updated MCPS software release. Then use whichever method is most comfortable to you.
Installation Option #1
Install new MCPS software without removing the previous version from the Start Up Group - This is Melcos recommendation. 1. Exit MCPS, restart windows without starting MCPS. 2. Insert Disk #1 of the MCPS software. 3. Click Start at the bottom left of the Windows screen. 4. Select Run and type a:setup. 5. Click OK and follow the on-screen instructions: Welcome - click Next Software License Agreement - read carefully, then click Yes (or No) Select Components: check Program files, check RSA files - click Next Insert Disk #2 when prompted - click OK (If an error message appears asking if you want to replace file BC450RTL.DLL, click NO. This file does not need to be replaced.) MCPS icon to appear on desktop - click Yes 6. Remove disk.#2 Restart the computer - click Yes, click OK Note: If your machine is networked, you should enable ethernet in the MCPS Config program before running MCPS.
13348, Rev G
3 of 5
Installation Option #2
Remove current version of MCPS software from the the Start Up Group before installing the new software. Remove MCPS from Start Up Group 1. Click Start at the bottom left of the Windows screen. 2. Select Settings and then Task Bar and Start Menu. 3. Click the Start Menus Program tab. 4. Click the Remove button and locate the Start Up folder. 5. Open the Start up folder and highlight MCPS. 6. Click Remove, and click on Yes to any dialog asking if you are sure. 7. Click Close, then OK to return to the Windows desktop. Install new MCPS software 1. Insert Disk #1 of the MCPS software 2. Click Start at the bottom left of the Windows screen. 3. Select Run and type a:setup. 4. Click OK and follow the on-screen instructions: Welcome - click Next Software License Agreement - read carefully, then click Yes (or No) Select Components: check Program files, check RSA files - click Next Insert Disk #2 when prompted - click OK MCPS icon to appear on desktop - click Yes 5. Remove disk.#2 Restart the computer - click Yes, click OK 6. Click Start at the bottom left of the Windows screen. 7. Select Programs / Melco Apps / MCPSConfig. 8. Choose machine type and click OK. Note: If your machine is networked, you should enable ethernet in the MCPS Config program before running MCPS.
4 of 5
13348, Rev G
5 of 5