Escolar Documentos
Profissional Documentos
Cultura Documentos
age : Title should be typed with a Times New Roman font size of 18 in capital letters; the name of the department and the Subject Code & Title with a font size of 16; the name of the college and place with a font size of 20 and all other text with a font size of 14 in the title page. The student and the guide should sign at the places provided in the front page. Margins: o Top and bottom edge o Left side o Right side
CHAPTERS INTRODUCTION LITERATURE REVIEW PROBLEM DESCRIPTION METHODOLOGY / EXPERIMENTAL SET-UP TOOLS/TEST SYSTEMS/PLATFORMS EXPECTED OUTCOME REFERENCES APPENDIX
: : :
25 mm 35 mm 25 mm
*Depending upon the problem chosen, the above chapters title shall be slightly modified in consultation with GUIDE.
The chapter titles should be right justified and typed in BOLD Upper case of font size 16 and numbered as 1, 2, etc.. The sections headings should be in BOLD Upper case of font size 14. For example the sections in chapter 1 numbered as 1.1, 1.2, etc. The sub sections headings should be in BOLD Title Case of font size 14. For example the sub sections in section 1.1 numbered as 1.1.1, 1.1.2, etc. The text of the report should be typed in Times New Roman of font size 13 with 1.5-line spacing. The paragraph should begin with a tab of 10 mm. The page numbers in numerals should be typed on the bottom right corner of the page in alignment with the paragraph, starting from the INTRODUCTION CHAPTER onwards.
The reference should be indicated within the text as : Author name (year) (Note: affix et al. to the first author name, if the authors are more than two) The figures/ photographs should be numbered with relevant to the chapters. For example, figure 4.2 is the second figure in the fourth chapter. Every figure/photograph should have a caption. It should be typed with the figure number below the figure/photograph left justified to the figure (in small letters with title case and BOLD).
The tables should be numbered with relevant to the chapters. For example Table 3.1 is the first table in the third chapter. Every table should have a caption. It should be typed with the table number above the table left justified to the table (in small letters with title case and BOLD).
The equations should also be numbered and should be shown at the right end close to the margin as For example 1.5 is the 5th equation in Chapter 1. . . . . .(1.5)
The expansion of all abbreviations and symbols should be given at its first occurrence in the report. References The references shall be listed in the alphabetical order of the first author name. Each
reference shall be given in the following format. Author(s) name, Title of Journal Paper/Book, Journal name/Publisher name, Volume number, Year. Page number. Example:
Journal papers: Avcibas., Memon N. and Sankur B., Steganalysis using image quality metrics, IEEE Transaction on Image Processing, Vol.4, Issue 12, January 2003, pp 231-238. Conference papers:
The minimum number of pages for the report is 10 and the maximum is 15.
Note: Review III shall be only Demonstration, i.e verifying the actual simulation Results / S/W coding and output or Experimental results in person by the Reviewers & Guide. In all the review the award of marks by the reviewers is based on the PPT preparation, Delivery of content, Technical content in the work, Answering to the Queries asked by reviewers and quality of report, i.e. documentation. PPTs shall be prepared on the given template only. Avoid animations. All the Figures /Equations etc. must be drawn/prepared by the student themselves while preparing PPT/Report. be viewed seriously. If it is H/W project, student themselves shall fabricate in the Dept. lab and not to buy any Ready made available setup / Fabricate Outside through Private Agencies/Suppliers. If found, they are not fabricated by student, the project will be rejected summarily. After the successful completion of work, prepare a paper and send for publication in the International Conference / International or National journal as per the suggestion from the Guide. Proper acknowledgement to the Management & Principal of the College, Faculty and Staff involved in the Work should be mentioned in the paper. Copying Figures / Equations and paste in the PPT/Report and any form of plagiarism in PPT preparation / Report writing will