Escolar Documentos
Profissional Documentos
Cultura Documentos
Users Manual
FCC Statement
Federal Communication Commission Interference Statement This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to Part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment generates, uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one of the following measures: Reorient or relocate the receiving antenna. Increase the separation between the equipment and receiver. Connect the equipment into an outlet on a circuit different from that to which the receiver is connected. Consult the dealer or an experienced radio/TV technician for help.
FCC Caution Any changes or modifications not expressly approved by the party responsible for compliance could void the user's authority to operate this equipment. This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation. For product available in the USA/Canada market, only channel 1~11 can be operated. Selection of other channels is not possible. This device and its antenna(s) must not be co-located or operation in conjunction with any other antenna or transmitter. IMPORTANT NOTE FCC Radiation Exposure Statement: This equipment complies with FCC radiation exposure limits set forth for an uncontrolled environment. This equipment should be installed and operated with minimum distance 20cm between the radiator & your body.
ii
Table of Contents
Table of Contents
1. Introduction ................................................................................................1 1.1 Overview ..............................................................................................1 1.2 Firmware Upgrade and Tech Support ..................................................2 1.3 Features...............................................................................................3 1.4 Wireless Operation Modes...................................................................4
1.4.1 Access Point Mode ................................................................................................ 4 1.4.2 Client Mode ............................................................................................................. 5 1.4.3 Bridge Mode ............................................................................................................ 6 1.4.4 WDS Repeater Mode............................................................................................. 7 1.4.5 Universal Repeater Mode ..................................................................................... 7 1.4.6 WISP Router Mode ................................................................................................ 8 1.4.7 WISP + Repeater Mode ........................................................................................ 9 1.4.8 AP Router Mode ..................................................................................................... 9 1.4.9 WDS Station (Bridge Send Beacon) ................................................................. 10
2. Installing the AP60 ...................................................................................11 2.1 Package Content ...............................................................................11 2.2 Knowing your AP60 ...........................................................................12 2.3 Hardware Installation .........................................................................13 2.4 LED Table ..........................................................................................15 2.5 Restore Settings to Default ................................................................16 3. Configuring the AP60 ..............................................................................17 3.1 Important Information.........................................................................17 3.2 Prepare your PC ................................................................................18 3.3 Introduction to IP Finder.....................................................................19 3.4 Introduction to Web Management......................................................21
3.4.1 Getting into Web Management .......................................................................... 21 3.4.2 Main Menu ............................................................................................................. 21
Table of Contents
4. Wireless Settings .....................................................................................26 4.1 About Wireless Modes .......................................................................26 4.2 General Wireless Functions...............................................................28
4.2.1 Regulatory Domain .............................................................................................. 29 4.2.2 Band ....................................................................................................................... 29 4.2.3 SSID ....................................................................................................................... 29 4.2.4 Multiple SSID ........................................................................................................ 30 4.2.5 Site Survey ............................................................................................................ 30 4.2.6 Signal Survey ........................................................................................................ 31 4.2.7 Channel Width ...................................................................................................... 32 4.2.8 Channel Sideband ................................................................................................ 32 4.2.9 Channel .................................................................................................................. 32 4.2.10 Broadcast SSID .................................................................................................. 33 4.2.11 WMM .................................................................................................................... 33 4.2.12 Data Rate ............................................................................................................ 34 4.2.13 Wireless Client Limit .......................................................................................... 34 4.2.14 Client Mode Security Settings .......................................................................... 34 4.2.15 AP Mode Security Settings ............................................................................... 36 4.2.16 WPS ..................................................................................................................... 39 4.2.17 Access Control .................................................................................................... 40
5. Wireless Menu: Router Mode Settings...................................................46 5.1 Router Mode Settings under Wireless Menu .....................................46
5.1.1 WAN Port ............................................................................................................... 48 5.1.2 Virtual Server Settings ......................................................................................... 49 5.1.3 DMZ ........................................................................................................................ 49 5.1.4 Dynamic DNS ....................................................................................................... 50 5.1.5 DoS (Denial of Service) ....................................................................................... 50 5.1.6 URL Filter ............................................................................................................... 51 5.1.7 MAC Filter .............................................................................................................. 52 5.1.8 IP Filter ................................................................................................................... 52 5.1.9 Routing ................................................................................................................... 53
AirLive AP60 Users Manual
ii
Table of Contents
6. System Configurations............................................................................56 6.1 Menu Structure ..................................................................................56 6.2 LAN Interface Setup ..........................................................................57
6.2.1 DHCP Settings ...................................................................................................... 57 6.2.2 Set Static DHCP ................................................................................................... 58 6.2.3 Domain Name ....................................................................................................... 58 6.2.4 802.11d Spanning Tree ....................................................................................... 58 6.2.5 Clone MAC Address............................................................................................. 59 6.2.6 Enable AirLive IP Finder Management ............................................................. 59
6.3 Time Settings .....................................................................................59 6.4 Password Settings .............................................................................60 6.5 Wireless Scheduling ..........................................................................60 6.6 Watchdog...........................................................................................61 6.7 Firmware Upgrade .............................................................................62 6.8 Configuration Save and Restore........................................................63 6.9 Factory Default ..................................................................................64 7. Device Status Menu .................................................................................65 7.1 Menu Structure ..................................................................................65 7.2 Device Information .............................................................................66 7.3 Statistic ..............................................................................................67 7.4 Client Table ........................................................................................67 7.5 Log.....................................................................................................68 8. Bandwidth Control ...................................................................................69 8.1 What is Bandwidth Control?...............................................................69 8.2 Configure the Bandwidth Control .......................................................71
8.2.1Control by IP Address ........................................................................................... 73 8.2.2Control by MAC Address ...................................................................................... 73
9. Emergency Firmware Recovery .............................................................75 9.1 How Emergency Upgrade Works?.....................................................75 9.2 Emergency Upgrade Procedure ........................................................76 10. Frequent Asked Questions ...................................................................78
iii
AirLive AP60 Users Manual
Table of Contents
iv
1. Introduction
1. Introduction
1.1 Overview
The AP60 is a wireless multi-function router based on 150Mbps wireless-b/g/n 2.4GHz radio technologies. The Wireless Access Point is equipped with four 10/100 Mbps Auto-sensing Ethernet ports for connecting to LAN and also for cascading to next Wireless Access Point. Passive PoE Port You can supply power through Ethernet cable to AP60 using the passive PoE port. The AP60s passive PoE port can accept 12V to 24V power from a passive PoE switch (such as AirLive POE-FSH8PW) or a passive PoE DC Injector (AirLive POE-1P). 9 Wireless Modes The AP60 has 9 different wireless operation modes. Therefore, it can perform different functions such as AP, Bridge, Client, Repeater, Router and more.
1
AirLive AP60 Users Manual
1. Introduction
Long Distance Radio The AP60 features a long distance and wide coverage radio. It has potential to provide greater coverage than ordinary AP/Router. However, the output power is set to comply with your country regulation. Please do not use more power than allowed in your country. Versatile Management The AP60 comes with a user friendly interface that can access through web browser. There is a setup wizard to help you setup quickly. The IP finder utility can help you to find your AP. Whether it's for own, office, hotspot, or WISP environments, the AirLive Wireless-B/G/N AP Router family brings you the maximum performance and security for today's high speed wireless network.
1. Introduction
1.3 Features