Escolar Documentos
Profissional Documentos
Cultura Documentos
Questions 1. The number of normal stress and shear stress component respectively in a stress tensor defining stress at a point in three dimensions are (A) 3 and 6 (B) 6 and 3 (C) 3 and 3 (D) 6 and 6 2. The state of a metal undergoing plastic deformation is expressed as
P 5 3 3 10 0 0 0 0 5
Stress components are expressed in MPa. Find the value of estimated field stress. Using Von-mises yield theory (A) 15 (B) 22.07
(C) 30 (D) 25 3. A shaft of length 4 m and diameter 50m is rigidly held at two ends, such that it is not subjected to any angular rotation. A small bracket of layer 0.75 m at the centre carries a load of 150N . The maximum value of tensile stress in the bar in N/mm2 is
/// ///////
4m
A
/// ///// //
0.75
150N
(A) 6.84 (B) 3.42 (C) 9.86 (D) 13.68 4. Two cantilever beams are supported as shown in the diagram. Beam AC carries a uniformly distributed load of 4kN/m. Reaction experienced at beam BC at contact point with roller is
4k N/m A 2 C 2 B
(D) 5.
7 2
A 1mm thick wire passes over a pulley of radius 25mm . If Youngs modulus for wire is 250GPa and pulley is frictionless, then maximum stress produced in wire is
25
(C) 250MPa (D) 600MPa 6. A bracket is fitted on wall as shown above Youngs modulus for the material is E and moment of inertia is I throughout. Vertical deflection produced atA due to load P is
3l
C 2l
P
(A)
18 Pl 3 11 EI
12 Pl 3 (B) EI
9 Pl 3 (C) 4 EI
6 Pl 3 (D) EI
7.
A beam carries a point load at its middle, as shown in the diagram value of shear in section CD is
4kN
8.
h d
10. For arrangements given below, which has the maximum energy to store if an equal force is applied on all four (A) A
4 10 4 15
4
(B) B
4
(C) C
(D) D
8 12 8 7 8 18 22
(a)
(b)
(c)
(d)
Keys (1) a (2) d (10) d (3) a (4) b (5) b (6) b (7) d (8) a (9) c
For detailed solutions and next topic for sample questions, visit : www.enggsolutions.in