Escolar Documentos
Profissional Documentos
Cultura Documentos
UltraPly TPO
Description:
Firestone UltraPly TPO is a flexible Thermoplastic Polyolefin roofing membrane that is produced with polyester weft-inserted reinforcement. This heat weldable TPO membrane is available in 45 mil (1.1 mm) and 60 mil (1.5 mm) thicknesses in 8 (2.4 m), 10 (3 m) and 124 (3.76 m) widths. The colors available are white, tan or gray. This reflective membrane is suitable for a variety of low slope applications.
TM
TIS #201
Preparation of Substrate:
1. 2. 3. Substrates must be clean, dry, smooth, and free of sharp edges, fins, loose or foreign materials, oil, grease, and other materials that may damage the membrane. All roughened surfaces that can damage the membrane shall be repaired as specified to offer a smooth substrate. All surface voids greater than 1/4" (6.3 mm) wide shall be properly filled with an acceptable fill material.
Method of Application: 1.
2. Firestone UltraPly TPO membrane is installed as continuous roofing or waterproofing layer on the roof. Rolls are overlapped (side laps and end laps) prior to the heat welding of the seam areas. Install the UltraPly TPO Roofing System in accordance with current Firestone UltraPly TPO specifications, details and workmanship requirements.
Storage: Store away from sources of punctures and physical damage. Assure that structural decking will support the loads incurred by material when stored on rooftop. The deck load limitations
should be specified by the project designer. Store away from ignition sources as membrane will burn when exposed to open flame.
Precautions: Exercise caution when lifting, moving, transporting, storing or handling membrane rolls to avoid sources of punctures and
possible physical damage. Contact your Technical Coordinator at 1-800-428-4511 for specific recommendations regarding chemical or waste product compatibility with Firestone UltraPly TPO Membrane. Refer to Material Safety Data Sheets (MSDS) for safety information
Packaging:
.045 UltraPly TPO and .060 UltraPly TPO
Lengths 100 (30.5 m)/200(61 m) 100 (30.5 m)/200(61 m) 100 (30.5 m)/200(61 m) 100 (30.5 m)/200(61 m)
Compliance:
Post Consumer Recycled Content: Pre Consumer Recycled Content: Manufacturing Location: 0% 15% Wellford, SC Tuscumbia, AL
CCMC 13348-R
Firestone Building Products 250 W. 96th Street, Indianapolis, IN 46260 Sales: (800) 428-4442 Technical (800) 428-4511 www.firestonebpco.com
S723-RFS-112
12.8.2011
Units
In(mm) In(mm) Lb(N) % Lb(N) F(C) --F(C) % % % % % % kJ/m
Performance Minimum
0.039(1) 0.015(1) 220(975) 15 55(245) -40(-40) Pass 670 h @ 240F (116C) 90, minimum 90, minimum 60, minimum 1, maximum 1, maximum 3, maximum 10,080, minimum
---------
Reflectivity:
Solar Reflectance Thermal Emittance SRI Rated Product ID Licensed Manufacturer ID Classification
Compliance:
Solar Reflectance Thermal Emittance Solar Reflectance Index (SRI)
Test Method
ASTM E903 ASTM E408 ASTM E1980
White
0.81 0.95 102
Tan
0.63 0.95 77
Gray
0.37 0.95 43
Energy Star
Initial Solar Reflectance Aged Solar Reflectance (3 years) Cleaned prior to aged test? Initial Emittance
White
0.79 0.78 Yes 0.85
Tan
0.60 0.54 No 0.81
Please Contact your Firestone Technical Coordinator at 1-800-428-4511 for further information.
This sheet is meant to highlight Firestone products and specifications and is subject to change without notice. Firestone takes responsibility for furnishing quality materials which meet published Firestone product specifications. Neither Firestone nor its representatives practice architecture. Firestone offers no opinion on and expressly disclaims any responsibility for the soundness of any structure. Firestone accepts no liability for structural failure or resultant damages . Consult a competent structural engineer prior to installation if the structural soundness or structural ability to properly support a planned installation is in question. No Firestone representative is authorized to vary this disclaimer.
Firestone Building Products 250 W. 96th Street, Indianapolis, IN 46260 Sales: (800) 428-4442 Technical (800) 428-4511 www.firestonebpco.com
S723-RFS-112
12.8.2011