Escolar Documentos
Profissional Documentos
Cultura Documentos
ABSTRACT
An observable trend exists to test whether scouts are starting to communicate the
location and characteristics of the newly found food. If learning is successful, the number of
attracted foragers follows an increasing curve fit through time. The geometry of the footprints
left by the bees during foraging indicates their food preferences. As an application, training the
stingless bees to feed on nectars can help in the development of pollination, but sufficient effort
is crucial in determining the best balance of factors needed to attract the bees.
INTRODUCTION
A complex system, such as a bee colony or a set of bee colonies (Beekman &
Wilkinson, 2004), is said to be nonlinear. This means that the occurrence of a certain
event may not be linearly related to the occurrence of another event. Bees may have
different behaviors toward the same set of events.
15th Beekeepers’ Network Conference and Techno-fora July 2009
A complex system is open, i.e. it is subject not only to the internal environment
but also to the external environment. Bee colonies are open systems, and they are
affected by many environmental factors. One of these factors is weather. Bee behavior is
affected by changes in the climate. However, bee colonies are adaptable systems. Given
an appropriate environmental conditions, bees can adapt to changes. Adaptability is a
characteristic of most complex systems.
Training bee colonies to feed on unfamiliar food type is one of the major
concerns of researchers, beekeepers and agriculturists. If researchers need to study the
foraging behavior of bees, sometimes the researchers need to introduce a new food type
to the colony. If the weather is not suitable for the bees to search for food in an open
field, beekeepers usually give the colonies artificial food such as sucrose. Agriculturists
use bees for pollination of certain crops which may not be familiar to the bees. Hence, it
is a necessity to train the bees to learn the newly introduced food types prior to doing
large activities concerning bee foraging behavior.
EXPERIMENT PROPER
There were four related experimental designs and two independent experimental
designs. The same set of colonies was used in the related experiments, while different
colonies were used for the independent experiments. Independent experiments were
done to verify the results of the related experiments.
15th Beekeepers’ Network Conference and Techno-fora July 2009
For the related experiment 1, three colonies were placed in an open field. Feeders
were placed at a distance 1m from and with the same level of height as the beehive
opening of each colony. 40%, 50% and 60% sucrose concentrations with a drop of
vanilla were placed in each feeder. The setup was conducted for three consecutive
sunny days, starting 6AM to 4PM.
The experiment showed that an open field is not a good enabling environment
for training. For the duration of the experiment, only one bee attempted to visit the
feeders. The intuitive hypothesis for this situation is that an open field provides the bees
plenty of food choices to choose from, and thus, this makes training inappropriate.
For the related experiment 2, three colonies were placed in a closed room where
there is no direct sunlight coming through the windows. Feeders were placed at a
distance 1m from and with the same level of height as the beehive opening of each
colony. 40%, 50% and 60% sucrose concentrations with a drop of vanilla were placed in
15th Beekeepers’ Network Conference and Techno-fora July 2009
each feeder. The setup was conducted for three consecutive sunny days, starting 6AM
to 4PM.
The experiment showed that a closed room (with no direct sunlight) is not a
good enabling environment for training. For the duration of the experiment, no bee
attempted to visit the feeders. In fact, bees tend not to come out of their beehive. The
intuitive hypothesis for this situation is that sunlight is one of the important enabling
factors for training.
FIGURE 3: Design of the Related Experiment 3 (closed room, with direct sunlight)
For the related experiment 3, three colonies were placed in a closed room with
direct sunlight coming through the windows. Feeders were placed at a distance 1m
from and with the same level of height as the beehive opening of each colony. 40%, 50%
and 60% sucrose concentrations with a drop of vanilla were placed in each feeder. The
setup was conducted for three consecutive sunny days, starting 6AM to 4PM.
Related Experiment 3 showed that a closed room (with direct sunlight) is not a
good enabling environment for training. For the duration of the experiment, only five
bees attempted to visit the feeders. However, compared to the closed room with no
sunlight, now bees tend to come out of their beehives. The problem is bees did not
search for food; instead the bees flew to the windows pursuing to come out of the room.
The intuitive hypothesis for this situation is that sunlight affects the activeness of the
bees; however, bees should not be controlled in a closed room in order for them to fly
freely.
FIGURE 5: Design of the Related Experiment 4 (opened windows, with direct sunlight)
For the related experiment 4, three colonies were placed in a room with opened
windows and where there is direct sunlight coming through the windows. Feeders
were placed at a distance 1m from and with the same level of height as the beehive
opening of each colony. 40%, 50% and 60% sucrose concentrations with a drop of
vanilla were placed in each feeder. The setup was conducted for three consecutive
sunny days, starting 6AM to 4PM.
The experiment showed that a room (with opened windows and direct sunlight)
is a good enabling environment for training. Related experiment 4 is a result of an
accident happened while doing Related Experiment 3. Accidentally, one of the
windows was opened and after 4 minutes, bees started to forage in the prepared
feeders. To repeat Related Experiment 4, Independent Experiment 1 (with three
replicates) was carried out and the result was successful. The intuitive hypothesis in the
Related Experiment 3 is now verified, i.e. sunlight and a not-so-controlled condition are
some of the enabling factors for training the bees.
15th Beekeepers’ Network Conference and Techno-fora July 2009
The researchers thought that it is not the room that influenced the success of
Related Experiment 3 and Independent Experiment 1, but the idea of having a guided
environment. The bees still need to feel the freedom of flying, in a natural environment-
like setting, while guiding them to learn. The result of Independent Experiment 2 is
more notable than Related Experiment 3 and Independent Experiment 1. There are
more bees that foraged in the feeders set up during Independent Experiment 2. Using
Two-Sample Kolmogorov-Smirnov Test (Nonparametric), at 95% confidence level,
results of Independent Experiment 1 and 2 have significant difference.
The result of the experiments can be used for future researchers regarding the
effect of bee pollination in a greenhouse garden. There are many factors to consider in
training the bees, some of them are the food itself (e.g. sucrose concentration), sunlight
and light direction, space of the food location, and weather.
APPARENT PATTERNS
An observable trend exists to test whether scouts are starting to communicate the
location and characteristics of the newly found food. If learning is successful, the
number of attracted foragers follows an increasing curve fit through time.
15th Beekeepers’ Network Conference and Techno-fora July 2009
Successful scouting can be predicted through the visiting patterns of the scouts.
Given a feeder distance of 1m from the beehive, a successful scout will initially inspect
the newly discovered feeder for more than 1 minute duration. The successful scout will
then subsequently visit the feeder for approximately 1 hour. The duration of the
subsequent inspections is decreasing until it level-off as shown in Figure 7.
Another apparent pattern that can be seen during the foraging activity of Trigona
biroi is the geometry of their footprints. Trigona species leave olfactory cues in every
visited feeder (Villa & Weiss, 1990; Boogert et al., 2006). However, existing studies only
focus on the chemistry of this cues or footprints. In day to day beekeeping, chemical
analysis of the footprints is impractical; hence, analysis of the physical properties, such
geometrical characteristics, of the footprints is preferable.
Using ImageJ, the fractal dimension of the footprints was analyzed. The result of
the box counting analysis showed that the footprints are indeed fractal. The footprints
15th Beekeepers’ Network Conference and Techno-fora July 2009
of Trigona biroi can now be added in the list of fractals in nature. The fractal dimension
of the footprint sample, shown in Figure 9, is 1.7393.
Binarize
References:
Beekman, M., & Wilkinson, I.F. (2004). What can social insects teach us about marketing. Australia
New Zealand Marketing Academy Annual Conference, Wellington, December, 2004.
Scheiner, R., Page, R. E., & Erber, J. (2004). Sucrose responsiveness and behavioral plasticity in
honeybees (Apis mellifera). Apidologie, 35, 133-142.
Villa, J. D., & Weiss, M. R. (1990). Observations on the use of visual and olfactory cues by Trigona spp
foragers. Apidologie, 21, 541-545.
Boogert, N. J., Hofstede, F. E., & Monge, I. A. (2006). The use of food source scent marks by the
stingless bee Trigona corvina (Hymenoptera: Apidae): the importance of the depositor.s identity.
Apidologie, 37, 366-375.
Rasband, W. ImajeJ 1.42q. National Institutes of Health, USA.