Escolar Documentos
Profissional Documentos
Cultura Documentos
Condux’s sole liability and the purchaser’s sole remedy for a failure of goods
under this limited warranty, and for any and all claims arising out of the
purchase and use of the goods, shall be limited to the repair and replacement
of the goods that do not conform to this warranty.
CONDUX
Condux International, Inc. • P.O. Box 247 • 145 Kingswood Road • Mankato, MN 56001 USA
1-507-387-6576 • 1-800-533-2077 • FAX 1-507-387-1442
Internet: http://www.condux.com © Copyright 1998, Condux International, Inc
Printed in USA ®
Literature Part Number: 08690099
Revision Number: 1.10 CONDUX
5 Blue Heron Drive Collegeville, PA 19426 (610) 831-5020 Fax: (610) 831-5012
www.comstarsupply.com
5 Blue Heron Drive
Comstar Supply, INC Collegeville, PA 19426
Think Cable... Think Comstar Phone: 610-831-5020
Fax: 610-831-5012
1-866-326-6782 www.comstarsupply.com
Installation Procedure
!DANGER: The chart recorder is an electrical 8. Reattach ECB panel
device. Electric shock hazards exist that could to case. Attach Chart
result in severe personal injury or death. Observe Recorder to case.
the following precautions: 9. Reconnect power
• Do not expose electronic control box or chart recorder to supply and test
water. electronic control box
for proper operation.
• Do not disassemble chart recorder (no user-serviceable parts
inside). Refer servicing to qualified personnel.
• The electronic control box power switch should be in the OFF
position before connecting or disconnecting any cords.
• The electronic control box must be disconnected from all
power supplies before chart recorder is installed. Figure 1. Power Inverter
!WARNING: Read and understand all procedure !DANGER: The chart recorder is an electrical
and safety instructions before using the Condux® device. Electric shock hazards exist that could
Electronic Control Box Chart Recorder. Failure to result in severe personal injury or death.
do so may result in personal injury or property
damage. Save this user’s guide for future reference.
ADVERTENCIA !ADVERTENCIA: Favor de leer y comprender
todas las instrucciones de operación y seguridad
antes de usar el Condux® Electronic Control Box
Instrucciones
de Operación Chart Recorder. Si Ud. no comprende las
instrucciones favor de consultarle a su jefe.
5 Blue Heron Drive Collegeville, PA 19426 (610) 831-5020 Fax: (610) 831-5012
www.comstarsupply.com