Escolar Documentos
Profissional Documentos
Cultura Documentos
Refer to the exhibit. Which statement is information that can be derived from the command output that is show
The transmitting interface of the multicast source is serial 0/0.
The serial 0/0 interface of the router is the only known path to the multicast source.
The reverse path was learned via a static unicast route statement.
Final del formulario
The multicast traffic will be forwarded to all segments of the network including the RPs and the designated
routers.
The multicast traffic will be forwarded to all network segments including the RPs and RP mapping agents.
The multicast traffic will be forwarded only to the segments of the network with active receivers that have
explicitly requested multicast data.
Final del formulario
as a solicited report to the multicast group when the device first intends to receive a multicast stream
in response to a membership query from another host within the multicast group
as an unsolicited report to the router periodically to ensure multicast streams will continue to be forwarded
Final del formulario
Router R1 will act as a mapping agent for the multicast group 224.0.0.0/4 that is operating in a sparse mo
Router R1 will act as an RP using 10.0.0.3/32 as the RP address for the multicast group 224.0.0.0/4 that i
operating in a dense mode.
Router R1 will act as an RP using 10.0.0.3/32 as the RP address for the multicast group 224.0.0.0/4 that i
operating in a sparse mode.
Router R1 will act as a source of the multicast traffic that is directed to the 224.0.0.0/4 multicast group.
Router R1 will act as a destination router for the multicast traffic that is sent to the 224.0.0.0/4 multicast gr
Final del formulario
6 Principio del formulario
Refer to the exhibit. What two conclusions can be drawn from what is shown of the partial output of the show i
mroute command ? (Choose two.)
The multicast group is operating in dense mode.
Router1 is the RP
Refer to the exhibit. Which two multicast routing statements are true? (Choose two.)
Assuming that the neighbor of this router has the same priority configured, then the router has the higher
address on the link.
The frequency at which PIM hellos and PIM queries are sent has been altered from the default of 30 seco
This router is the DR because its default priority has been altered.
Final del formulario
GLOP addresses and limited scope addresses are two types of IP multicast addresses.
IP address 224.0.1.1 is a globally scoped address that has been reserved for Network Time Protocol (NTP
Pinging IP address 224.0.0.1 will get all multicast-capable hosts on the network to reply.
Final del formulario
Refer to the exhibit. On the basis of the output in the exhibit, which statement is true?
Router R1 itself is the RP for the multicast group 224.1.1.1.
Router R1 interfaces are configured in PIM dense mode.
Incoming multicast traffic on interface Ethernet0/0 gets dropped because of RPF failure.
Outgoing multicast traffic on interface Ethernet0/1 gets dropped because of RPF failure.
Final del formulario
Refer to the exhibit. On the basis of the information in the exhibit, which two multicast statements are true? (C
two.)
The neighbor at IP address 10.3.35.1 is the next-hop address toward the RP.
The output is an example of a shared distribution tree with a multicast group address of 224.0.255.3.
The router advertises itself as the RP by sending messages to the 224.0.1.39 address.
Final del formulario