Escolar Documentos
Profissional Documentos
Cultura Documentos
Keywords
Antenna Selection
Directional Antenna
Yagi PCB Antenna
2.4 GHz Antenna
Introduction
OTA Measurements
CC2xxx
CC8520
SWRA350
Page 1 of 28
1
1
2
3
4
5
5
5
6
7
8
9
10
10
10
11
11
17
23
Abbreviations
AN
AUT
CPW
CTIA
DK
DN
EB
EIRP
EM
EM
IFA
ISM
LOS
NHPRP
NHPRP45
OTA
PCB
RF
RL
SWR
TI
TRP
VSWR
YAGI
Application Note
Antenna Under Test
CoPlanar Waveguide
Cellular Telecommunications Industry Association
Development Kit
Design Note
Evaluation Board
Effective Isotropic Radiated Power
Electro Magnetic
Evaluation Module
Inverted-F Antenna
Industrial, Scientific, Medical
Line of Sight
Near Horizon Partial Radiated Power
Near Horizon Partial Radiated Power within 45 degrees angle
Over The Air
Printed Circuit Board
Radio Frequency
Return Loss
Standing Wave Ratio
Texas Instruments
Total Radiated Power
Voltage Standing Wave Ratio
Directional Antenna (Original invented by YAGI & UDA)
SWRA350
Page 2 of 28
Board Description
The antenna described in this document is a Yagi-Uda commonly named as Yagi and is a
directional antenna with approximately 7dBi gain. Impedance of the antenna input is 50
which allows easy matching to most networks.
Since PCB vendors manufacturing processes, customer board thickness and application
board surroundings vary it is a safe option to include a pi-filter network at the feed point. If
the pi-filter network is not required then a zero ohm resistor can be inserted. The
compensating network allows for detuning caused by enclosing the antenna in plastic and
other objects in close vicinity of the antenna. For further information on impedance matching
and impedance measurements, refer to AN058 [1].
Bandwidth and the impedance measurements are shown in Section 4.1. Radiation pattern is
shown in Section 4.2.
The printed Yagi antenna shown in Figure 2 was designed with a 3D magnetic simulator for
antennas. The antenna has a single ended feed input of 50 and this single ended
transmission line is converted to a two-wire feed via the integrated balun, as shown in the red
circle in Figure 2 and Figure 5.
The feed dipole element is fed with a two-wire transmission line, and the ground plane,
printed on all four layers of the PCB, acts as the reflector. The arms of the feed dipole
element are printed on separate layers; the bottom arm stays on the second (Internal,
Antenna Bottom) layer, see Figure 4 and Figure 6; while the top arm and all of the directors
reside on the top layer (Top, Antenna Top), see Figure 3 and Figure 6.
SWRA350
Page 3 of 28
Figure 5. Balun Transition from 50 Microstrip Line to 50 two wire dipole feed
There is a printed balun in the Yagi antenna design and this can be seen in the red circle in
Figure 2 and Figure 5; this is required to feed the 50 two wire dipole (Top, Antenna Top
Layer) from a 50 microstrip line (Inner, Antenna Bottom Layer). The balun consists of three
sections with a narrowing linear taper shown in more detail in Figure 5.
3.1
SWRA350
Page 4 of 28
Measurements
4.1
4.1.1
S11 Measurements
Bandwidth
Page 5 of 28
Impedance
Figure 8. 2.4 GHz Yagi Antenna Test Board 4L, 1.6mm - PCB Stack-Up
Referring to Figure 8, the impedance match for 2.40 GHz(Marker 2), 2.44 GHz(Marker 3) & 2.48
GHz(Marker 4) is good and within VSWR of 1.4. This good match can be seen when the wanted
frequency markers (2.40 GHz(Marker 2), 2.44 GHz(Marker 3) & 2.48 GHz(Marker 4)) are in the centre of
the Smith chart.
SWRA350
Page 6 of 28
Radiation Pattern
SWRA350
Page 7 of 28
OTA Test Results for 2400 MHz, 2440 MHz & 2480 MHz
Frequency
Total Radiated Power
Peak EIRP
Directivity
Efficiency
Efficiency
Gain
NHPRP 45
NHPRP 45 / TRP
NHPRP 45 / TRP
NHPRP 30
NHPRP 30 / TRP
NHPRP 30 / TRP
NHPRP 22.5
NHPRP 22.5 / TRP
NHPRP 22.5 / TRP
UHRP
UHRP / TRP
UHRP / TRP
LHRP
LHRP / TRP
LHRP / TRP
Front/Back Ratio
PhiBW
PhiBW Up
PhiBW Down
ThetaBW
ThetaBW Up
ThetaBW Down
Boresight Phi
Boresight Theta
Maximum Power
Minimum Power
Average Power
Max/Min Ratio
Max/Avg Ratio
Min/Avg Ratio
Best Single Value
Best Position
2400.000 MHz
-0.70 dBm
7.22 dBm
7.92 dBi
-0.70 dB
85.20 %
7.22 dBi
-4.58 dBm
-3.88 dB
40.90 %
-7.69 dBm
-7.00 dB
19.96 %
-9.23 dBm
-8.53 dB
14.02 %
-1.59 dBm
-0.90 dB
81.34 %
-7.99 dBm
-7.29 dB
18.66 %
14.16
360.0 deg
360.0 deg
360.0 deg
82.1 deg
33.5 deg
48.6 deg
135 deg
15 deg
7.22 dBm
-14.96 dBm
1.17 dBm
22.18 dB
6.05 dB
-16.13 dB
6.82 dBm
Phi = 180 deg;
Theta = 0 deg;
Pol = Hor
2440.000 MHz
-1.44 dBm
7.18 dBm
8.62 dBi
-1.44 dB
71.70 %
7.18 dBi
-5.88 dBm
-4.43 dB
36.05 %
-9.28 dBm
-7.83 dB
16.48 %
-10.81 dBm
-9.37 dB
11.57 %
-2.22 dBm
-0.77 dB
83.68 %
-9.32 dBm
-7.87 dB
16.32 %
15.77
360.0 deg
360.0 deg
360.0 deg
76.0 deg
29.3 deg
46.7 deg
135 deg
15 deg
7.18 dBm
-16.28 dBm
0.85 dBm
23.46 dB
6.33 dB
-17.13 dB
6.65 dBm
Phi = 90 deg;
Theta = 0 deg;
Pol = Ver
2480.000 MHz
-2.35 dBm
7.13 dBm
9.48 dBi
-2.35 dB
58.24 %
7.13 dBi
-6.97 dBm
-4.63 dB
34.46 %
-9.25 dBm
-6.90 dB
20.41 %
-10.40 dBm
-8.06 dB
15.65 %
-3.28 dBm
-0.93 dB
80.71 %
-9.49 dBm
-7.15 dB
19.29 %
15.25
360.0 deg
360.0 deg
360.0 deg
63.6 deg
33.5 deg
30.1 deg
240 deg
0 deg
7.13 dBm
-16.81 dBm
0.39 dBm
23.94 dB
6.75 dB
-17.20 dB
6.85 dBm
Phi = 90 deg;
Theta = 0 deg;
Pol = Ver
Table 1. OTA Test Results for 2400 MHz, 2440 MHz & 2480 MHz
As can be seen from Table 1, the gain of the antenna is similar across the whole 2.4 GHz ISM
band. The efficiency is highest at 2400 MHz and as the frequency increases the efficiency drops
slightly.
For an explanation of each measurement result, please refer to the Antenna Selection Guide,
AN058 [1].
SWRA350
Page 8 of 28
Summary
Antenna gain is just a measure of the antenna directivity and an antenna can only ever
radiated the power that is entered into the antenna. No amplification is achieved via high gain
antennas. When the antenna gain characteristic increases, the main radiation lobe becomes
longer and narrower (more directive).
Typically for a system with mobile units it is desirable to have an omni-directional radiation
pattern such that the performance will be approximately the same regardless of which
direction the units are pointed relative to each other. A concern of using directional antennas
is that the positioning of the transmitter and receiver unit must be known in detail. If this
information is not known then it is could be better to consider to use a more omni-directional
antenna design such as the inverted-F antenna [3]. If the positioning of the transmitter and
receiver unit is fixed then this directional antenna is an excellent choice.
To assist in the decision which antenna should be used the Comprehensive Antenna
Selection Guide is available [1]. The Antenna Selection Quick Guide [7] is also available and
is shown in Figure 11.
SWRA350
Page 9 of 28
7
7.1
References
[1]
[2]
[3]
[4]
[5]
[6]
[7]
General Information
Document History
Revision
SWRA350
Date
2010-10-14
Description/Changes
Initial release.
SWRA350
Page 10 of 28
Appendices
OTA Test Results for Frequency 2400.000 MHz
RP_2400.000_tot
Azimuth
(deg)
0.00
15.00
30.00
45.00
60.00
75.00
90.00
105.00
120.00
135.00
150.00
165.00
180.00
195.00
210.00
225.00
240.00
255.00
270.00
285.00
300.00
315.00
330.00
345.00
360.00
Elevation
0 deg
(dB)
6.34
6.50
6.62
6.66
6.63
6.53
6.40
6.22
6.21
6.34
6.55
6.73
6.88
7.01
7.04
7.03
6.97
6.79
6.56
6.40
6.31
6.27
6.25
6.33
6.47
Elevation
15 deg
(dB)
5.60
5.45
5.45
5.60
5.87
6.19
6.50
6.81
7.09
7.22
7.17
7.01
6.76
6.47
6.21
5.93
5.81
5.79
5.95
6.18
6.32
6.36
6.24
5.95
5.63
Elevation
30 deg
(dB)
3.71
3.37
3.96
4.89
5.74
6.35
6.67
6.67
6.47
6.08
5.70
5.26
5.08
5.05
5.17
5.41
5.54
5.64
5.64
5.46
5.20
4.81
4.32
3.78
3.63
Elevation
45 deg
(dB)
-0.44
-0.59
0.19
1.53
2.83
4.18
4.95
5.44
5.52
5.10
4.43
3.44
2.58
2.02
2.00
2.31
2.72
3.14
3.41
3.37
2.94
2.36
1.56
0.60
-0.27
Elevation
60 deg
(dB)
-7.12
-7.15
-5.35
-2.60
-0.47
1.12
1.89
2.22
2.05
1.30
0.40
-0.72
-1.58
-1.94
-1.49
-0.46
0.26
0.50
0.31
-0.23
-0.98
-2.25
-3.76
-5.45
-6.63
Elevation
75 deg
(dB)
-13.92
-12.82
-11.29
-10.31
-9.29
-8.14
-6.42
-5.08
-4.49
-4.76
-6.19
-8.17
-9.96
-9.53
-8.30
-6.77
-5.39
-4.30
-3.90
-4.87
-6.90
-9.86
-12.40
-14.32
-14.96
Elevation
90 deg
(dB)
-10.52
-9.89
-9.80
-9.40
-6.71
-3.93
-2.31
-2.16
-3.17
-5.74
-8.59
-11.68
-12.65
-11.06
-8.36
-5.74
-3.63
-2.95
-3.13
-4.22
-5.93
-8.17
-10.12
-11.02
-10.44
Elevation
105 deg
(dB)
-10.06
-10.98
-11.27
-10.73
-8.43
-5.18
-3.18
-2.09
-2.33
-3.82
-5.97
-8.78
-11.89
-13.90
-9.05
-4.69
-1.91
-0.26
0.34
-0.17
-1.48
-3.87
-6.26
-8.82
-9.92
Elevation
120 deg
(dB)
-6.46
-5.05
-4.74
-3.91
-2.67
-1.52
-1.21
-1.91
-3.50
-6.36
-9.04
-11.10
-10.83
-9.97
-9.29
-7.87
-6.80
-5.58
-5.31
-5.72
-6.47
-7.63
-8.25
-7.65
-6.24
Elevation
135 deg
(dB)
-2.04
-2.65
-3.07
-3.48
-3.36
-3.20
-3.31
-3.46
-3.98
-4.76
-5.87
-6.47
-5.97
-4.84
-4.59
-4.59
-4.73
-4.75
-4.43
-4.20
-3.74
-3.13
-2.38
-1.89
-1.90
Elevation
150 deg
(dB)
-4.80
-6.29
-7.12
-7.23
-7.00
-6.51
-6.50
-6.53
-6.59
-7.00
-7.12
-7.32
-7.04
-5.88
-4.67
-4.02
-4.14
-4.52
-4.84
-5.08
-4.77
-4.35
-4.17
-4.42
-5.31
Elevation
165 deg
(dB)
-6.86
-7.60
-8.26
-8.93
-9.63
-10.34
-10.59
-10.07
-9.39
-8.34
-7.68
-7.41
-7.33
-7.77
-8.18
-8.53
-8.72
-9.23
-8.80
-8.08
-7.35
-6.94
-6.66
-6.61
-6.66
SWRA350
Elevation
180 deg
(dB)
-7.72
-8.25
-8.73
-9.60
-10.02
-10.43
-10.24
-9.71
-8.79
-7.85
-7.33
-7.32
-7.68
-8.14
-8.81
-10.06
-10.97
-11.03
-11.29
-10.07
-9.28
-8.16
-7.63
-7.40
-7.67
Page 11 of 28
Elevation
0 deg
(dB)
6.27
6.30
5.71
4.37
2.16
-1.88
-10.32
-9.13
-1.23
2.82
5.00
6.28
6.82
6.80
6.17
4.80
2.59
-1.43
-9.54
-10.48
-1.84
2.17
4.33
5.73
6.32
Elevation
15 deg
(dB)
5.49
5.39
4.78
3.44
1.13
-3.61
-14.43
-6.13
-0.01
3.46
5.24
6.29
6.61
6.39
5.62
4.00
1.52
-3.40
-14.10
-8.14
-1.54
2.04
3.89
4.99
5.40
Elevation
30 deg
(dB)
3.46
3.27
3.02
2.18
0.49
-3.08
-10.69
-10.51
-2.41
1.55
3.52
4.56
4.96
4.83
4.24
2.99
0.82
-2.87
-10.26
-13.54
-4.92
-0.94
1.17
2.43
3.08
Elevation
45 deg
(dB)
-0.71
-0.70
-0.98
-2.04
-4.07
-8.62
-20.13
-7.69
-2.50
0.36
1.75
2.37
2.31
1.79
0.93
-0.66
-3.12
-7.75
-16.91
-12.07
-6.55
-3.63
-2.12
-1.23
-0.86
Elevation
60 deg
(dB)
-7.93
-7.87
-8.46
-9.34
-10.74
-13.53
-16.96
-11.11
-6.92
-4.15
-2.78
-2.12
-1.97
-2.39
-3.35
-4.59
-6.25
-9.44
-14.47
-20.97
-14.96
-11.39
-9.54
-8.47
-7.94
Elevation
75 deg
(dB)
-16.99
-16.80
-17.95
-21.03
-18.04
-15.60
-13.70
-12.17
-10.67
-9.66
-9.78
-10.00
-10.55
-10.34
-10.55
-11.64
-13.50
-16.15
-17.99
-18.49
-18.92
-20.53
-20.90
-19.01
-17.62
Elevation
90 deg
(dB)
-11.57
-10.72
-11.37
-12.66
-12.52
-11.96
-12.17
-13.86
-15.70
-15.66
-14.59
-14.16
-13.77
-13.78
-12.78
-12.24
-12.03
-13.47
-16.12
-18.08
-17.56
-16.66
-15.13
-13.03
-11.60
Elevation
105 deg
(dB)
-11.21
-12.37
-13.49
-14.82
-13.77
-13.72
-14.99
-18.18
-21.03
-19.43
-18.92
-18.25
-17.20
-15.76
-15.67
-17.07
-18.08
-16.13
-13.44
-11.18
-9.86
-9.87
-10.42
-10.88
-11.05
Elevation
120 deg
(dB)
-6.89
-5.25
-5.55
-6.29
-7.01
-8.29
-10.58
-15.61
-20.28
-16.27
-13.88
-12.74
-11.72
-11.65
-12.85
-14.88
-17.77
-20.07
-17.67
-15.08
-13.65
-12.96
-11.61
-9.27
-6.82
Elevation
135 deg
(dB)
-2.14
-3.07
-4.30
-6.13
-8.23
-11.59
-15.66
-17.24
-12.66
-9.63
-8.16
-7.28
-6.48
-6.02
-6.98
-9.07
-12.29
-16.85
-17.49
-12.11
-8.78
-5.76
-3.62
-2.31
-2.00
Elevation
150 deg
(dB)
-5.17
-7.19
-9.00
-11.28
-14.19
-16.46
-16.36
-14.31
-12.39
-11.02
-9.67
-8.41
-7.42
-6.28
-5.71
-6.04
-7.75
-10.89
-15.45
-16.45
-10.91
-7.43
-5.64
-4.96
-5.70
Elevation
165 deg
(dB)
-7.17
-8.06
-9.41
-11.54
-14.65
-19.78
-19.93
-15.49
-12.62
-10.40
-9.10
-8.32
-7.87
-8.11
-8.59
-9.46
-10.92
-13.96
-18.26
-17.12
-13.51
-10.32
-8.56
-7.45
-6.98
SWRA350
Elevation
180 deg
(dB)
-8.79
-9.81
-11.09
-13.81
-17.10
-19.39
-17.31
-13.52
-11.19
-9.54
-8.58
-8.22
-8.45
-8.98
-10.21
-12.43
-15.55
-19.34
-18.79
-14.63
-11.81
-9.65
-8.70
-8.39
-8.84
Page 12 of 28
Elevation
0 deg
(dB)
-12.09
-6.83
-0.61
2.80
4.71
5.85
6.30
6.09
5.35
3.78
1.32
-3.35
-12.19
-6.23
-0.37
3.06
4.99
6.08
6.45
6.31
5.59
4.13
1.77
-2.58
-8.12
Elevation
15 deg
(dB)
-10.53
-12.85
-3.00
1.54
4.09
5.71
6.46
6.58
6.14
4.85
2.71
-1.13
-7.93
-10.93
-2.77
1.49
3.79
5.23
5.91
6.01
5.54
4.36
2.45
-1.04
-7.11
Elevation
30 deg
(dB)
-8.87
-12.78
-3.17
1.55
4.20
5.83
6.59
6.58
5.87
4.19
1.65
-3.01
-10.54
-8.07
-1.96
1.72
3.76
4.98
5.53
5.41
4.75
3.47
1.45
-1.96
-5.65
Elevation
45 deg
(dB)
-12.61
-16.66
-6.08
-0.99
1.84
3.95
4.93
5.22
4.77
3.31
1.06
-3.17
-9.71
-10.90
-4.60
-0.74
1.41
2.77
3.37
3.24
2.42
1.11
-0.87
-4.05
-9.16
Elevation
60 deg
(dB)
-14.84
-15.30
-8.25
-3.63
-0.90
0.97
1.83
2.01
1.46
-0.16
-2.46
-6.33
-12.21
-12.04
-6.08
-2.58
-0.83
0.04
0.17
-0.27
-1.16
-2.82
-5.09
-8.45
-12.45
Elevation
75 deg
(dB)
-16.86
-15.04
-12.34
-10.69
-9.92
-9.00
-7.32
-6.03
-5.69
-6.46
-8.69
-12.79
-18.94
-17.23
-12.22
-8.49
-6.11
-4.59
-4.07
-5.06
-7.18
-10.24
-13.07
-16.13
-18.36
Elevation
90 deg
(dB)
-17.19
-17.48
-14.99
-12.18
-8.04
-4.67
-2.78
-2.47
-3.42
-6.21
-9.84
-15.29
-19.07
-14.40
-10.31
-6.84
-4.31
-3.35
-3.36
-4.40
-6.24
-8.83
-11.76
-15.31
-16.74
Elevation
105 deg
(dB)
-16.38
-16.58
-15.24
-12.87
-9.94
-5.83
-3.47
-2.20
-2.39
-3.94
-6.20
-9.30
-13.40
-18.46
-10.11
-4.95
-2.02
-0.37
0.16
-0.53
-2.16
-5.13
-8.36
-13.04
-16.33
Elevation
120 deg
(dB)
-16.68
-18.43
-12.45
-7.66
-4.66
-2.55
-1.74
-2.10
-3.59
-6.83
-10.76
-16.14
-18.12
-14.93
-11.81
-8.84
-7.16
-5.74
-5.57
-6.26
-7.39
-9.13
-10.93
-12.71
-15.31
Elevation
135 deg
(dB)
-18.66
-13.01
-9.14
-6.88
-5.07
-3.89
-3.57
-3.65
-4.61
-6.47
-9.74
-14.17
-15.54
-11.07
-8.34
-6.50
-5.56
-5.02
-4.65
-4.96
-5.37
-6.55
-8.44
-12.27
-18.17
Elevation
150 deg
(dB)
-15.62
-13.57
-11.66
-9.41
-7.91
-6.98
-6.97
-7.32
-7.91
-9.19
-10.65
-13.83
-17.77
-16.46
-11.36
-8.33
-6.62
-5.66
-5.23
-5.41
-5.98
-7.30
-9.59
-13.81
-16.05
Elevation
165 deg
(dB)
-18.47
-17.55
-14.57
-12.38
-11.27
-10.86
-11.13
-11.54
-12.19
-12.56
-13.22
-14.65
-16.64
-19.08
-18.63
-15.71
-12.72
-11.02
-9.32
-8.66
-8.55
-9.61
-11.17
-14.17
-18.18
SWRA350
Elevation
180 deg
(dB)
-14.33
-13.45
-12.50
-11.67
-10.97
-11.02
-11.19
-12.04
-12.51
-12.79
-13.33
-14.58
-15.59
-15.70
-14.41
-13.82
-12.83
-11.72
-12.14
-11.95
-12.82
-13.52
-14.27
-14.30
-13.93
Page 13 of 28
SWRA350
Page 14 of 28
SWRA350
Page 15 of 28
SWRA350
Page 16 of 28
RP_2440.000_tot
Azimuth
(deg)
0.00
15.00
30.00
45.00
60.00
75.00
90.00
105.00
120.00
135.00
150.00
165.00
180.00
195.00
210.00
225.00
240.00
255.00
270.00
285.00
300.00
315.00
330.00
345.00
360.00
Elevation
0 deg
(dB)
6.39
6.68
6.98
7.06
7.11
6.95
6.71
6.48
6.33
6.30
6.34
6.48
6.67
6.90
7.06
7.16
7.07
6.99
6.71
6.50
6.38
6.26
6.26
6.32
6.51
Elevation
15 deg
(dB)
5.83
5.77
5.81
5.94
6.04
6.29
6.56
6.89
7.12
7.18
7.08
6.89
6.61
6.35
6.18
5.99
5.98
5.98
6.00
6.14
6.26
6.28
6.22
6.07
5.91
Elevation
30 deg
(dB)
3.83
4.05
4.54
4.98
5.34
5.60
5.71
5.78
5.78
5.71
5.57
5.41
5.31
5.32
5.42
5.49
5.50
5.48
5.32
5.11
4.78
4.47
4.09
3.81
3.82
Elevation
45 deg
(dB)
-0.71
-0.76
-0.14
1.02
2.04
3.03
3.81
4.31
4.44
4.10
3.48
2.74
2.09
1.86
1.93
2.21
2.54
2.76
2.78
2.72
2.49
1.95
1.09
0.07
-0.46
Elevation
60 deg
(dB)
-8.58
-8.61
-6.86
-5.03
-3.41
-2.34
-1.36
-0.98
-1.02
-1.59
-2.65
-3.66
-4.27
-3.98
-3.40
-2.21
-1.28
-0.87
-1.04
-1.63
-2.78
-4.32
-5.78
-7.26
-8.25
Elevation
75 deg
(dB)
-11.45
-11.69
-13.39
-15.01
-14.38
-11.73
-9.82
-8.57
-8.10
-8.81
-9.74
-10.65
-11.25
-11.42
-11.09
-10.55
-10.24
-10.50
-11.39
-13.19
-14.51
-14.58
-13.47
-12.73
-12.10
Elevation
90 deg
(dB)
-11.01
-11.03
-12.53
-13.12
-10.81
-7.52
-5.22
-4.64
-5.25
-6.84
-8.57
-9.81
-10.37
-10.07
-8.65
-6.32
-4.17
-2.88
-2.71
-3.47
-5.17
-7.46
-9.22
-10.43
-10.55
Elevation
105 deg
(dB)
-12.61
-11.96
-11.31
-10.85
-7.11
-3.83
-2.17
-1.78
-2.58
-4.77
-7.60
-10.75
-12.96
-12.11
-9.26
-7.16
-5.04
-3.85
-3.14
-3.92
-5.74
-8.39
-11.78
-14.10
-14.03
Elevation
120 deg
(dB)
-5.82
-6.02
-5.70
-4.43
-3.01
-2.02
-1.93
-2.30
-3.60
-5.78
-8.57
-10.35
-9.88
-7.89
-5.86
-4.17
-2.89
-2.07
-2.07
-2.36
-3.13
-3.90
-4.78
-5.45
-5.64
Elevation
135 deg
(dB)
-8.97
-10.21
-10.35
-9.04
-7.85
-7.35
-7.15
-7.36
-7.60
-8.44
-9.68
-10.78
-9.61
-7.50
-5.74
-4.64
-4.47
-4.27
-4.40
-4.36
-4.40
-4.72
-5.36
-6.72
-8.02
Elevation
150 deg
(dB)
-8.71
-8.44
-8.59
-8.85
-9.28
-9.84
-11.19
-12.32
-13.62
-13.49
-13.79
-13.79
-14.22
-16.28
-15.00
-11.93
-10.29
-9.81
-9.75
-10.58
-10.86
-11.95
-12.42
-10.69
-9.12
Elevation
165 deg
(dB)
-6.14
-6.52
-7.78
-9.84
-12.50
-15.50
-15.89
-13.75
-11.87
-10.17
-9.40
-8.84
-8.68
-9.07
-9.76
-11.46
-13.16
-13.80
-13.45
-11.90
-10.61
-8.59
-7.31
-6.41
-6.22
SWRA350
Elevation
180 deg
(dB)
-6.03
-6.03
-6.39
-6.97
-7.64
-8.84
-10.16
-10.29
-10.46
-9.30
-8.05
-7.18
-6.78
-6.68
-7.13
-8.00
-9.18
-10.62
-11.87
-12.64
-11.04
-9.23
-7.48
-6.78
-6.16
Page 17 of 28
Elevation
0 deg
(dB)
6.34
6.29
5.64
4.29
1.88
-2.22
-12.39
-7.76
-0.77
2.85
4.93
6.12
6.65
6.58
5.89
4.59
2.24
-1.63
-10.06
-10.04
-1.47
2.35
4.57
5.83
6.42
Elevation
15 deg
(dB)
5.79
5.59
4.81
3.27
0.35
-4.97
-16.58
-4.18
0.98
3.78
5.39
6.31
6.52
6.18
5.29
3.57
0.87
-4.03
-15.06
-6.56
-0.62
2.60
4.34
5.35
5.79
Elevation
30 deg
(dB)
3.77
3.72
3.23
2.04
-0.32
-4.48
-15.52
-7.38
-1.00
2.24
4.04
4.99
5.26
5.02
4.27
2.86
0.48
-3.55
-12.49
-10.23
-3.32
0.15
2.08
3.14
3.67
Elevation
45 deg
(dB)
-0.79
-1.04
-1.81
-3.13
-5.61
-10.84
-17.48
-7.54
-2.81
-0.28
1.16
1.90
1.96
1.62
0.77
-0.69
-3.11
-7.77
-18.00
-11.19
-5.79
-3.15
-1.86
-1.18
-0.68
Elevation
60 deg
(dB)
-9.23
-9.87
-11.07
-12.31
-14.00
-16.92
-16.79
-12.13
-8.80
-6.86
-5.88
-5.11
-4.82
-4.72
-5.48
-6.66
-8.09
-10.89
-15.40
-21.05
-16.16
-12.37
-10.36
-9.30
-9.17
Elevation
75 deg
(dB)
-13.82
-14.64
-17.55
-18.47
-16.04
-15.34
-16.39
-14.91
-13.01
-12.06
-12.33
-12.98
-13.08
-12.87
-13.05
-13.28
-14.46
-16.68
-18.76
-19.36
-17.70
-16.74
-15.31
-14.35
-14.13
Elevation
90 deg
(dB)
-11.87
-12.05
-13.55
-14.63
-14.55
-14.98
-16.55
-16.70
-13.81
-12.19
-11.00
-11.06
-11.36
-10.90
-10.31
-10.28
-10.28
-11.33
-11.97
-11.75
-11.23
-10.93
-10.97
-11.50
-11.43
Elevation
105 deg
(dB)
-14.00
-12.83
-12.47
-13.44
-12.19
-11.64
-11.82
-13.85
-16.55
-17.96
-17.86
-17.70
-17.18
-15.81
-14.51
-14.88
-16.05
-17.93
-17.90
-16.02
-15.46
-16.46
-17.88
-17.79
-16.23
Elevation
120 deg
(dB)
-6.12
-6.79
-8.37
-9.35
-10.02
-11.15
-13.63
-18.32
-18.82
-14.90
-13.06
-11.90
-10.45
-10.14
-11.09
-13.51
-17.20
-19.01
-15.87
-12.75
-10.04
-8.23
-7.14
-6.50
-6.03
Elevation
135 deg
(dB)
-9.62
-11.71
-13.89
-14.60
-14.70
-15.63
-17.55
-19.45
-18.61
-16.40
-14.60
-12.86
-10.27
-8.45
-7.75
-8.00
-10.01
-12.75
-14.77
-13.57
-10.96
-9.07
-8.13
-8.19
-8.86
Elevation
150 deg
(dB)
-10.17
-9.49
-9.37
-9.71
-10.71
-11.95
-14.87
-17.89
-20.80
-19.19
-17.41
-16.74
-17.05
-19.47
-18.41
-15.83
-14.98
-16.20
-18.50
-20.58
-20.30
-19.86
-17.84
-13.60
-10.70
Elevation
165 deg
(dB)
-6.55
-6.91
-8.19
-10.40
-13.63
-18.78
-20.19
-15.38
-12.70
-10.73
-9.92
-9.28
-9.11
-9.57
-10.63
-13.41
-16.77
-19.51
-16.22
-13.24
-11.22
-8.96
-7.71
-6.80
-6.62
SWRA350
Elevation
180 deg
(dB)
-6.51
-6.61
-6.99
-8.06
-9.66
-12.26
-16.51
-17.56
-14.63
-11.21
-8.88
-7.62
-7.05
-6.97
-7.52
-8.54
-10.04
-12.54
-15.09
-17.23
-13.85
-10.70
-8.40
-7.50
-6.70
Page 18 of 28
Elevation
0 deg
(dB)
-12.92
-4.01
1.22
3.80
5.56
6.38
6.65
6.31
5.39
3.69
0.76
-4.62
-16.96
-4.64
0.79
3.66
5.34
6.34
6.62
6.40
5.60
4.00
1.33
-3.47
-10.28
Elevation
15 deg
(dB)
-14.26
-8.03
-1.06
2.56
4.67
5.95
6.53
6.53
5.91
4.53
2.14
-2.12
-10.38
-7.85
-1.13
2.30
4.38
5.52
5.97
5.90
5.26
3.86
1.67
-2.09
-9.90
Elevation
30 deg
(dB)
-14.64
-7.24
-1.30
1.91
3.96
5.15
5.68
5.56
4.76
3.12
0.30
-4.99
-14.47
-6.44
-0.90
2.07
3.86
4.90
5.25
4.98
4.05
2.47
-0.23
-4.61
-11.02
Elevation
45 deg
(dB)
-18.15
-12.93
-5.09
-1.10
1.23
2.85
3.77
4.02
3.53
2.13
-0.35
-4.77
-13.19
-10.87
-4.39
-0.91
1.17
2.36
2.74
2.54
1.80
0.34
-1.98
-5.96
-13.53
Elevation
60 deg
(dB)
-17.19
-14.62
-8.94
-5.93
-3.81
-2.50
-1.49
-1.32
-1.82
-3.13
-5.46
-9.15
-13.50
-12.03
-7.59
-4.14
-2.29
-1.33
-1.21
-1.68
-2.98
-5.06
-7.64
-11.53
-15.40
Elevation
75 deg
(dB)
-15.21
-14.77
-15.49
-17.61
-19.36
-14.22
-10.91
-9.71
-9.79
-11.59
-13.21
-14.48
-15.89
-16.89
-15.49
-13.87
-12.31
-11.70
-12.27
-14.39
-17.34
-18.66
-18.09
-17.81
-16.39
Elevation
90 deg
(dB)
-18.44
-17.80
-19.33
-18.45
-13.21
-8.37
-5.56
-4.92
-5.90
-8.34
-12.25
-15.84
-17.29
-17.65
-13.63
-8.55
-5.38
-3.55
-3.26
-4.16
-6.40
-10.07
-13.99
-17.07
-17.91
Elevation
105 deg
(dB)
-18.25
-19.36
-17.60
-14.32
-8.72
-4.62
-2.67
-2.05
-2.76
-4.99
-8.03
-11.73
-15.02
-14.51
-10.80
-7.97
-5.40
-4.03
-3.29
-4.20
-6.23
-9.13
-13.01
-16.53
-18.03
Elevation
120 deg
(dB)
-17.57
-13.90
-9.08
-6.12
-3.97
-2.59
-2.23
-2.41
-3.73
-6.35
-10.48
-15.55
-18.97
-11.83
-7.41
-4.70
-3.06
-2.15
-2.25
-2.78
-4.11
-5.90
-8.56
-12.13
-16.30
Elevation
135 deg
(dB)
-17.58
-15.56
-12.88
-10.45
-8.85
-8.04
-7.56
-7.64
-7.96
-9.20
-11.37
-14.99
-18.14
-14.58
-10.07
-7.33
-5.89
-4.94
-4.81
-4.91
-5.48
-6.71
-8.63
-12.15
-15.58
Elevation
150 deg
(dB)
-14.16
-15.12
-16.44
-16.30
-14.79
-13.99
-13.62
-13.73
-14.55
-14.86
-16.27
-16.85
-17.42
-19.12
-17.65
-14.21
-12.09
-10.95
-10.37
-11.04
-11.38
-12.71
-13.89
-13.80
-14.28
Elevation
165 deg
(dB)
-16.55
-17.18
-18.26
-19.07
-18.93
-18.25
-17.92
-18.79
-19.47
-19.33
-18.86
-18.99
-18.91
-18.72
-17.18
-15.88
-15.65
-15.16
-16.72
-17.64
-19.47
-19.47
-17.80
-17.12
-16.75
SWRA350
Elevation
180 deg
(dB)
-15.83
-15.06
-15.34
-13.54
-11.93
-11.47
-11.31
-11.19
-12.56
-13.80
-15.69
-17.35
-19.00
-18.65
-17.77
-17.32
-16.61
-15.10
-14.67
-14.50
-14.27
-14.64
-14.67
-14.97
-15.46
Page 19 of 28
SWRA350
Page 20 of 28
SWRA350
Page 21 of 28
SWRA350
Page 22 of 28
RP_2480.000_tot
Azimuth
(deg)
0.00
15.00
30.00
45.00
60.00
75.00
90.00
105.00
120.00
135.00
150.00
165.00
180.00
195.00
210.00
225.00
240.00
255.00
270.00
285.00
300.00
315.00
330.00
345.00
360.00
Elevation
0 deg
(dB)
6.55
6.81
7.02
7.10
7.11
7.05
6.89
6.80
6.69
6.63
6.52
6.43
6.41
6.57
6.82
7.01
7.13
7.08
6.88
6.68
6.48
6.34
6.32
6.45
6.64
Elevation
15 deg
(dB)
5.40
5.37
5.44
5.63
5.81
6.06
6.32
6.64
6.81
6.82
6.59
6.21
5.82
5.62
5.64
5.81
6.12
6.31
6.50
6.52
6.50
6.33
6.05
5.69
5.57
Elevation
30 deg
(dB)
2.56
2.82
3.28
3.77
4.16
4.44
4.72
4.84
4.86
4.74
4.44
4.15
3.92
3.94
4.29
4.68
4.96
5.08
4.99
4.70
4.28
3.70
3.00
2.61
2.60
Elevation
45 deg
(dB)
-3.22
-2.94
-1.99
-0.95
-0.20
0.52
1.28
1.89
2.35
2.10
1.50
0.65
-0.29
-0.82
-0.40
0.47
1.41
2.12
2.42
2.17
1.53
0.58
-0.86
-2.24
-2.20
Elevation
60 deg
(dB)
-10.28
-10.12
-8.67
-8.05
-7.76
-7.55
-7.18
-6.34
-5.38
-5.17
-5.31
-6.05
-7.04
-7.52
-7.20
-6.18
-5.02
-4.21
-3.86
-4.23
-5.44
-6.91
-7.99
-9.29
-9.86
Elevation
75 deg
(dB)
-12.56
-13.37
-15.78
-16.81
-15.40
-12.60
-9.84
-8.50
-8.11
-8.81
-9.12
-9.04
-8.75
-8.93
-9.42
-9.80
-9.52
-9.20
-8.77
-8.72
-9.76
-11.68
-12.83
-12.44
-12.25
Elevation
90 deg
(dB)
-15.74
-16.30
-13.80
-11.02
-7.27
-4.44
-2.64
-2.34
-3.31
-5.64
-8.97
-12.73
-13.03
-10.29
-7.21
-5.12
-3.12
-2.15
-2.14
-3.37
-5.70
-8.65
-11.44
-13.49
-14.87
Elevation
105 deg
(dB)
-9.31
-9.22
-9.72
-8.67
-5.33
-2.95
-1.25
-0.74
-1.33
-3.03
-5.51
-8.52
-12.69
-12.93
-7.83
-4.47
-2.40
-1.36
-1.06
-1.65
-2.90
-4.49
-6.51
-8.08
-9.90
Elevation
120 deg
(dB)
-9.79
-10.34
-10.67
-9.54
-8.20
-7.10
-6.37
-6.40
-7.72
-9.73
-11.94
-12.77
-11.37
-9.30
-6.92
-5.27
-3.65
-2.71
-2.67
-3.18
-4.16
-5.54
-7.21
-8.53
-9.30
Elevation
135 deg
(dB)
-8.33
-8.70
-9.08
-9.01
-8.95
-8.80
-9.00
-9.55
-10.44
-12.80
-13.89
-13.27
-13.41
-14.34
-15.00
-14.21
-14.06
-13.53
-13.71
-14.20
-14.06
-13.46
-11.08
-9.44
-9.03
Elevation
150 deg
(dB)
-5.96
-6.21
-6.92
-7.95
-9.08
-10.05
-10.89
-11.64
-11.12
-11.09
-10.49
-10.23
-8.50
-7.45
-6.83
-6.69
-6.72
-7.43
-8.11
-9.15
-9.38
-8.25
-6.87
-6.14
-5.96
Elevation
165 deg
(dB)
-6.56
-6.94
-7.80
-8.79
-9.81
-10.21
-10.18
-9.92
-9.71
-9.27
-8.77
-8.47
-8.61
-8.30
-7.85
-7.71
-7.92
-8.05
-8.22
-7.70
-7.39
-6.65
-6.19
-6.18
-5.89
SWRA350
Elevation
180 deg
(dB)
-8.38
-8.36
-8.73
-8.62
-8.12
-7.68
-7.33
-7.00
-7.11
-6.96
-7.00
-7.16
-7.45
-7.84
-8.18
-8.36
-8.76
-8.71
-8.66
-8.22
-7.90
-7.62
-7.70
-7.90
-8.08
Page 23 of 28
Elevation
0 deg
(dB)
6.53
6.43
5.69
4.28
1.76
-2.39
-13.03
-8.28
-0.74
2.70
4.80
5.88
6.39
6.31
5.62
4.29
1.85
-2.18
-11.65
-9.39
-1.13
2.49
4.80
6.04
6.60
Elevation
15 deg
(dB)
5.38
5.12
4.15
2.64
-0.42
-5.67
-18.94
-5.14
0.16
2.96
4.65
5.48
5.73
5.44
4.49
2.89
0.00
-4.89
-18.76
-6.40
-0.63
2.33
4.17
5.01
5.50
Elevation
30 deg
(dB)
2.53
2.42
1.78
0.65
-1.67
-5.63
-15.91
-9.54
-2.82
0.43
2.38
3.40
3.83
3.67
3.00
1.74
-0.61
-4.52
-13.33
-12.04
-4.39
-1.04
0.92
1.98
2.50
Elevation
45 deg
(dB)
-3.41
-3.47
-3.85
-4.53
-6.43
-10.13
-19.08
-11.05
-5.22
-2.79
-1.48
-0.92
-0.73
-1.02
-1.84
-3.16
-5.49
-9.28
-18.23
-14.48
-8.77
-5.94
-4.45
-3.77
-2.48
Elevation
60 deg
(dB)
-11.06
-11.08
-10.93
-11.00
-12.21
-14.39
-19.14
-15.98
-11.01
-8.86
-7.84
-7.53
-8.01
-8.52
-9.17
-10.17
-12.14
-14.67
-17.71
-21.11
-20.22
-16.15
-13.30
-11.98
-11.16
Elevation
75 deg
(dB)
-16.81
-18.35
-20.07
-21.34
-18.95
-18.32
-16.11
-13.23
-10.98
-10.08
-10.14
-10.05
-10.10
-10.09
-10.96
-12.04
-13.13
-14.65
-16.98
-16.81
-16.47
-16.02
-15.93
-15.84
-16.66
Elevation
90 deg
(dB)
-20.36
-20.61
-20.29
-19.74
-17.62
-16.31
-15.51
-14.69
-13.55
-12.89
-12.96
-14.73
-15.22
-15.00
-13.38
-13.11
-13.67
-15.49
-16.35
-15.02
-14.28
-14.70
-16.51
-18.45
-20.48
Elevation
105 deg
(dB)
-10.90
-9.91
-11.02
-12.38
-12.15
-12.24
-13.05
-14.20
-17.20
-18.13
-17.67
-17.53
-16.51
-17.57
-19.15
-18.60
-17.19
-16.52
-16.32
-16.43
-16.14
-15.30
-13.98
-12.71
-12.37
Elevation
120 deg
(dB)
-10.72
-11.50
-13.71
-14.18
-13.95
-13.86
-15.22
-16.80
-17.77
-17.09
-16.02
-14.61
-12.20
-10.32
-9.48
-10.20
-11.90
-14.34
-17.99
-15.83
-12.94
-11.55
-10.87
-10.43
-10.43
Elevation
135 deg
(dB)
-8.78
-9.27
-10.04
-10.65
-11.28
-12.79
-15.29
-17.71
-17.33
-16.59
-15.83
-14.77
-15.65
-18.67
-21.10
-17.92
-16.42
-15.96
-16.06
-17.03
-16.42
-15.28
-12.39
-10.24
-9.55
Elevation
150 deg
(dB)
-6.52
-6.85
-7.96
-9.34
-11.37
-13.62
-16.26
-17.62
-15.24
-14.10
-11.85
-10.85
-9.14
-8.83
-9.35
-11.13
-13.67
-16.53
-18.60
-17.18
-13.46
-10.42
-7.92
-6.76
-6.43
Elevation
165 deg
(dB)
-6.82
-7.29
-8.58
-10.69
-13.88
-19.17
-19.82
-15.06
-12.42
-10.73
-9.81
-9.19
-9.10
-8.80
-8.81
-9.65
-11.42
-14.20
-18.03
-17.46
-12.87
-9.64
-7.81
-6.93
-6.21
SWRA350
Elevation
180 deg
(dB)
-9.20
-9.09
-9.86
-10.97
-12.72
-15.61
-18.47
-18.84
-15.16
-11.76
-10.03
-8.64
-8.16
-8.22
-8.99
-10.20
-12.61
-15.64
-19.85
-18.08
-14.54
-12.00
-10.42
-9.51
-9.17
Page 24 of 28
Elevation
0 deg
(dB)
-17.73
-3.94
1.23
3.89
5.61
6.52
6.85
6.67
5.83
4.37
1.67
-2.83
-15.73
-5.93
0.67
3.69
5.61
6.53
6.82
6.57
5.65
4.03
1.03
-4.06
-13.84
Elevation
15 deg
(dB)
-17.86
-7.09
-0.48
2.60
4.63
5.75
6.30
6.34
5.75
4.52
2.15
-1.89
-11.27
-8.19
-0.67
2.70
4.90
5.96
6.49
6.30
5.57
4.12
1.50
-2.69
-13.01
Elevation
30 deg
(dB)
-18.74
-7.72
-2.07
0.86
2.84
3.99
4.68
4.68
4.04
2.73
0.22
-3.89
-13.35
-8.26
-1.61
1.59
3.55
4.57
4.93
4.61
3.65
1.92
-1.20
-6.07
-13.56
Elevation
45 deg
(dB)
-16.76
-12.39
-6.57
-3.45
-1.38
0.13
1.24
1.67
1.51
0.39
-1.55
-4.55
-10.46
-14.28
-5.87
-1.99
0.42
1.79
2.39
2.08
1.11
-0.52
-3.35
-7.53
-14.36
Elevation
60 deg
(dB)
-18.13
-17.13
-12.58
-11.12
-9.68
-8.56
-7.46
-6.84
-6.77
-7.59
-8.86
-11.44
-14.01
-14.37
-11.59
-8.40
-5.95
-4.62
-4.04
-4.32
-5.58
-7.46
-9.51
-12.66
-15.71
Elevation
75 deg
(dB)
-14.60
-15.03
-17.81
-18.70
-17.92
-13.96
-11.01
-10.28
-11.27
-14.77
-15.94
-15.87
-14.48
-15.21
-14.67
-13.75
-11.99
-10.65
-9.48
-9.45
-10.81
-13.67
-15.76
-15.09
-14.20
Elevation
90 deg
(dB)
-17.58
-18.31
-14.90
-11.65
-7.69
-4.74
-2.87
-2.60
-3.74
-6.54
-11.18
-17.05
-17.03
-12.07
-8.41
-5.87
-3.52
-2.36
-2.31
-3.68
-6.35
-9.88
-13.05
-15.16
-16.26
Elevation
105 deg
(dB)
-14.46
-17.52
-15.59
-11.08
-6.34
-3.49
-1.54
-0.94
-1.45
-3.17
-5.78
-9.10
-15.01
-14.77
-8.16
-4.64
-2.54
-1.50
-1.19
-1.80
-3.11
-4.87
-7.36
-9.91
-13.54
Elevation
120 deg
(dB)
-16.91
-16.63
-13.66
-11.37
-9.55
-8.12
-6.98
-6.82
-8.17
-10.61
-14.09
-17.41
-18.98
-16.10
-10.43
-6.95
-4.35
-3.02
-2.80
-3.43
-4.77
-6.80
-9.66
-13.03
-15.69
Elevation
135 deg
(dB)
-18.39
-17.78
-16.07
-14.04
-12.76
-11.00
-10.16
-10.27
-11.44
-15.15
-18.32
-18.62
-17.36
-16.34
-16.22
-16.61
-17.83
-17.21
-17.50
-17.39
-17.83
-18.12
-16.90
-17.22
-18.51
Elevation
150 deg
(dB)
-15.17
-14.85
-13.65
-13.55
-12.96
-12.56
-12.38
-12.91
-13.24
-14.11
-16.20
-18.98
-17.12
-13.11
-10.39
-8.62
-7.69
-8.00
-8.52
-9.90
-11.54
-12.31
-13.57
-14.96
-15.81
Elevation
165 deg
(dB)
-18.87
-18.14
-15.65
-13.30
-11.97
-10.80
-10.68
-11.51
-13.04
-14.71
-15.47
-16.61
-18.31
-18.01
-14.92
-12.15
-10.49
-9.26
-8.70
-8.19
-8.83
-9.68
-11.25
-14.16
-17.38
SWRA350
Elevation
180 deg
(dB)
-16.06
-16.47
-15.13
-12.41
-9.97
-8.44
-7.68
-7.29
-7.84
-8.70
-9.99
-12.56
-15.67
-18.61
-15.88
-12.97
-11.06
-9.69
-9.01
-8.70
-8.97
-9.59
-11.01
-12.97
-14.62
Page 25 of 28
SWRA350
Page 26 of 28
SWRA350
Page 27 of 28
SWRA350
Page 28 of 28
IMPORTANT NOTICE
Texas Instruments Incorporated and its subsidiaries (TI) reserve the right to make corrections, modifications, enhancements, improvements,
and other changes to its products and services at any time and to discontinue any product or service without notice. Customers should
obtain the latest relevant information before placing orders and should verify that such information is current and complete. All products are
sold subject to TIs terms and conditions of sale supplied at the time of order acknowledgment.
TI warrants performance of its hardware products to the specifications applicable at the time of sale in accordance with TIs standard
warranty. Testing and other quality control techniques are used to the extent TI deems necessary to support this warranty. Except where
mandated by government requirements, testing of all parameters of each product is not necessarily performed.
TI assumes no liability for applications assistance or customer product design. Customers are responsible for their products and
applications using TI components. To minimize the risks associated with customer products and applications, customers should provide
adequate design and operating safeguards.
TI does not warrant or represent that any license, either express or implied, is granted under any TI patent right, copyright, mask work right,
or other TI intellectual property right relating to any combination, machine, or process in which TI products or services are used. Information
published by TI regarding third-party products or services does not constitute a license from TI to use such products or services or a
warranty or endorsement thereof. Use of such information may require a license from a third party under the patents or other intellectual
property of the third party, or a license from TI under the patents or other intellectual property of TI.
Reproduction of TI information in TI data books or data sheets is permissible only if reproduction is without alteration and is accompanied
by all associated warranties, conditions, limitations, and notices. Reproduction of this information with alteration is an unfair and deceptive
business practice. TI is not responsible or liable for such altered documentation. Information of third parties may be subject to additional
restrictions.
Resale of TI products or services with statements different from or beyond the parameters stated by TI for that product or service voids all
express and any implied warranties for the associated TI product or service and is an unfair and deceptive business practice. TI is not
responsible or liable for any such statements.
TI products are not authorized for use in safety-critical applications (such as life support) where a failure of the TI product would reasonably
be expected to cause severe personal injury or death, unless officers of the parties have executed an agreement specifically governing
such use. Buyers represent that they have all necessary expertise in the safety and regulatory ramifications of their applications, and
acknowledge and agree that they are solely responsible for all legal, regulatory and safety-related requirements concerning their products
and any use of TI products in such safety-critical applications, notwithstanding any applications-related information or support that may be
provided by TI. Further, Buyers must fully indemnify TI and its representatives against any damages arising out of the use of TI products in
such safety-critical applications.
TI products are neither designed nor intended for use in military/aerospace applications or environments unless the TI products are
specifically designated by TI as military-grade or "enhanced plastic." Only products designated by TI as military-grade meet military
specifications. Buyers acknowledge and agree that any such use of TI products which TI has not designated as military-grade is solely at
the Buyer's risk, and that they are solely responsible for compliance with all legal and regulatory requirements in connection with such use.
TI products are neither designed nor intended for use in automotive applications or environments unless the specific TI products are
designated by TI as compliant with ISO/TS 16949 requirements. Buyers acknowledge and agree that, if they use any non-designated
products in automotive applications, TI will not be responsible for any failure to meet such requirements.
Following are URLs where you can obtain information on other Texas Instruments products and application solutions:
Products
Applications
Amplifiers
amplifier.ti.com
Audio
www.ti.com/audio
Data Converters
dataconverter.ti.com
Automotive
www.ti.com/automotive
DLP Products
www.dlp.com
Communications and
Telecom
www.ti.com/communications
DSP
dsp.ti.com
Computers and
Peripherals
www.ti.com/computers
www.ti.com/clocks
Consumer Electronics
www.ti.com/consumer-apps
Interface
interface.ti.com
Energy
www.ti.com/energy
Logic
logic.ti.com
Industrial
www.ti.com/industrial
Power Mgmt
power.ti.com
Medical
www.ti.com/medical
Microcontrollers
microcontroller.ti.com
Security
www.ti.com/security
RFID
www.ti-rfid.com
www.ti.com/space-avionics-defense
www.ti.com/video
Wireless
www.ti.com/wireless-apps
Mailing Address: Texas Instruments, Post Office Box 655303, Dallas, Texas 75265
Copyright 2010, Texas Instruments Incorporated