Escolar Documentos
Profissional Documentos
Cultura Documentos
b) E
c) E
d) E
iii) Bending moment at supports in case of simply supported beam is always
a) Less than unity b) More than unity
c) Zero d) None of the above
iv) In a cantilever beam uniformly distributed load (UDL) the Shear force and
bending moment varies following a
a) Linear and parabolic law b) Parabolic and cubic law
c) Linear and cubic law d) None of the above
v) The motion of a particle is given by the equation S= 2t
3
+3t (S is in m and t is time
in sec). starting from t=0, to attain a velocity of 9 m/s the particle will have to
travel a distance of
(a) 5m (b) 10m (c) 15m (d) 20m
2. i)
ii)
Explain stress-strain curve for ductile material with neat sketch.
The following data relate to a bar subjected to a tensile test:
Diameter of a bar, d= 30mm (0.03m)
Tensile load, P= 54KN
Gauge length, l= 300mm (0.3m)
Extension of the bar, l= 0.112mm
Change in diameter, d= 0.00366mm
Calculate (i) Poissons ratio (ii) The values of three moduli (E, C and K).
[2]
[3]
3.
Construct the shear force and bending moment diagram for given beam:
[5]
4.
(i)
(ii)
What are sagging and hogging moments?
A sphere is fired horizontally into a viscous liquid with an initial velocity of 27
m/s. If it experience a deceleration a= - 6tm/s
2
, where t is in seconds, determine
the distance travelled before it stops.
[2]
[3]