Escolar Documentos
Profissional Documentos
Cultura Documentos
ABCD
3. The antenna can be equipped with the downtilt kit or without the
downtilt kit. Select an installation mode based on the site conditions.
4. Appearance of the actual antenna may differ from the pictures.
Copyright Huawei Technologies Co., Ltd. 2014. All rights reserved.
2014
Adjust downtilt
Twist on protective cover
Twist off protective cover
Follow the position shown in the
picture to read scales.
Rotate ruler
1. The RCU is optional. For details about how to install the RCU, see the relevant RCU Installation Guide.
RCURCU
2
The mechanical downtilt of
the antenna is fixed to 0.
0
3
Install the antenna
2
Install the Clamps
Assemble the Clamps
Installation without Downtilt Kit
1
Installation with Downtilt Kit
1
Assemble the bracket
1. Split clamps and downtilt kit /
Split either of the 2
PCS of subassemblies
in the packing case.
2PCS
1PCS
3
3. Assemble lower bracket /
2. Assemble upper bracket /
Bump
Place the side of the downtilt kit with a bump outside.
Insert the bolt from the side with the bump.
Bump
Insert the bolt from the side with the bump.
Bump
4
For particular installation, please contact Huawei Technologies Co., Ltd. www.huawei.com
www.huawei.com
2014-03
Method 1: Using Scale
1:
Finally, tighten all the nuts.
Recommended torque:
M8 = 18 Nm
:
M8 = 18Nm
4
Adjust the mechanical downtilt
Before adjustment, adjust the inclinometer
to the desired downtilt angle.
After adjustment, locate the bead in the
inclinometer in the middle.
Method 2: Using inclinometer
2:
Ensure the bracket is
fully collapsed at 0.
0
3
Install the antenna
2
Install the bracket
"L" on the scale indicates the distance between antenna
bases. Observe the readings according to this distance. For
example, if the distance is 0.7 m, observe the readings
corresponding to "L=0.7 m" (scale range: 0 to 20 ).
L
0.7m
L=0.7m0 ~ 20
L