Escolar Documentos
Profissional Documentos
Cultura Documentos
-<CF SC:&&+ C,<+E& &2it menu or change screen when not in menus
)OW+ %&+*
Eo down through list or decrease value
&nter %ain %enu
*P %&+*
Eo u through list or increase value
&nter %ain %enu
Wai$in...
Wai$in...
+4%(& +>?4&?&4+&
T"da6% +&.(>&@W9
T"$a#% (>(+@W9
Waiting for sufficient e2orted
ower to start heating water$
%eating #ate&
Hea$in Wa$e)
O/$./$% &=&(W
Hea$in Wa$e)
+4%(& +>?4&?&4+&
T"da6% +&.(>&@W9
T"$a#% (>(+@W9
,eating water with ower from
PV system3 no Erid ower is
/eing used$
The current outut ower alied
to load is shown$
%eating #ate&
(Dual Heater Mode)
Hea$in Wa$e)1&2
O/$./$% &=&(W
Hea$in Wa$e)1&2
+4%(& +>?4&?&4+&
T"da6% +&.(>&@W9
T"$a#% (>(+@W9
,eating water with ower from
PV system3 no Erid ower is
/eing used$ Current heater is
show in /rac1ets$
#ate& %ot
Wa$e) H"$
Wa$e) H"$
+4%(& +>?4&?&4+&
T"da6% +&.(>&@W9
T"$a#% (>(+@W9
The water is fully heated3 the
immersion thermostat is oen$
%ot #ate& 'oost
UNIT TEMPERATURE
TOO HOT
The internal temerature of the
immerS*+ is too high$
Chec1 vents are clear$
MAINS VOLTAGE
TOO HIGH
MAINS VOLTAGE
TOO LOW
<C suly voltage is outside of
the oerating arameters$
ERROR
CLAMP REVERSED
The clam has /een reversed3
the settings will need to /e reset
to reconfigure the unit$
;See section 4$" Reset Settings=
ERROR
OUTPUT OVERLOAD
The outut of the unit is
overloaded3 the heater is larger
than "1W$
1.
#$ Trou/leshooting
*se the ta/le /elow to hel remedy the ro/lem$
<ny actions re?uiring oening the immerS*+ and9or testing voltages should only /e carried out a
cometent erson$ Contact your installer if in dou/t$
Symptom &ossi7le ause #ction
*nit dead3 no dislay %C- Tried Chec1 %C- is O+
8I+ and 8) terminals swaed Chec1 suly voltage on 8I+ terminal
Internal >use -lown Test fuse inside immerS*+
Showing ater Hot even though
the water is cold
+o load resent on 8) terminal Immersion heater isolator should /e O+
Chec1 immersion heater thermostat is not oen
Immersion heater element could /e oen4circuit
<lways showing aiting... PV system not generating
sufficient ower
Wait for PV system ower increase or reduce demand
/y switching off aliances
Pro/lem with signal from clam Chec1 clam is fitted to correct ca/le
Chec1 clam wire connections to terminals
,eating water at full outut even
when PV is not e2orting
Clam reversed The clam has /een reversed3
the settings will need to /e reset to reconfigure the unit$
;See section 4$" Reset Settings=
Slave device status not showing on
master dislay
Communication lin1 wires not
roerly connected
Chec1 continuity of communication wires to terminals <
H -
<ddress conflict Chec1 )IP switch ositions
Slave status screen not showing
on master
%O)-*S not ena/led on master Chec1 %O)-*S is ena/led in Comms menu
<ddress settings incorrect Chec1 )IP switch ositions
20
'$ Warranty
Su/6ect to the rovisions descri/ed /elow3 this roduct is rotected for three ;"= year against defects in
material and wor1manshi$
Should this roduct fail to erform as descri/ed within the warranted eriod3 it will /e reaired or relaced
with the same or functionally e?uivalent roduct /y 4eco3 at its discretion3 free of charge rovided you@ ;1=
:eturn the failed roduct to 4eco with shiing charge reaid3 and ;2= rovide 4eco with roof of the
original date of urchase$ :eturned or relacement roducts will /e returned to you with shiing charges
reaid$
:elacement roducts may /e refur/ished or contain refur/ished materials$ If 4eco3 /y its sole
determination3 is una/le to reair or relace the defective roduct3 it will refund the dereciated urchase
rice of the roduct$
The warranty does not aly if3 in the 6udgement of 4eco3 the roduct fails due to damage from shiment3
handling3 storage3 accident3 a/use3 misuse3 or if it has /een used or maintained in a manner not
conforming to roduct manual instructions3 has /een modified in any way3 or has had any serial num/er
removed or defaced$ :eair /y anyone other than 4eco or an aroved agent will void this warranty$ The
ma2imum lia/ility of 4eco under this warranty is limited to the urchase rice of the roduct covered /y
the warranty$
Prior to returning any defective roduct3 the end customer or the reseller from whom the end customer
originally urchased the roduct must o/tain a :eturn %aterials <uthorisation ;:%<= num/er from 4eco$
<ll defective roducts should /e returned to 4eco with shiing charges reaid$ 4eco will not accet
collect shiments$
&2cet as secifically rovided in this agreement or as re?uired /y law3 the warranties and remedies
stated a/ove are e2clusive and in lieu of all others3 oral or written3 e2ress or imlied$ <ny and all other
warranties3 including imlied warranties or merchanta/ility3 fitness for a articular urose and non4
infringement of third arty rights are e2ressly e2cluded$ 4eco shall not under any circumstances /e lia/le
to any erson for any secial3 incident3 indirect or conse?uential damages3 including without limitation3
damages resulting from use or malfunction of the roducts3 loss of rofits or revenues or costs of
relacement goods3 even if 4eco is informed in advanced of the ossi/ility of such damages$
21
($ Conformance
E Declaration of onformity
In accordance with &+ ISO 1'0!041@2004
e 4eco 8td
of " Church View -usiness Centre
-in/roo13 8incolnshire3 8+( #-C3 &ngland
In accordance with the following Directi!es"
200#9.!9&C The 8ow Voltage )irective
2004910(9&C The &lectromagnetic Comati/ility )irective
Here#y declare that"
E;uipment ,eater controller for microgeneration systems
Model immerS*+
Is in conformity with the applica#le re$uirements of the following documents
'ef9 No9 Title Edition8Date
-S &+ #10004#41 &lectromagnetic comati/ility ;&%C=$ Eeneric
standards$ Immunity for residential3 commercial
and light4industrial environments
200'
-S &+ #10004#4" &lectromagnetic comati/ility ;&%C=$ Eeneric
standards$ &mission standard for residential3
commercial and light4industrial environments
200'
I here/y declare that the e?uiment named a/ove has /een designed to comly with the relevant
sections of the a/ove referenced secifications$ The unit comlies with all alica/le &ssential
:e?uirements of the )irectives$
Signed@
+ame@ 8ee Sutton
Position@ Technical )irector
On@ 12 Iuly 2012
22
.$ Commissioning Sheet
%odel
Serial +um/er
Installation Comany
Installer +ame
)ate of Installation
Signed /y Installer
2"
4eco 8td3 " Church View -usiness Centre3 -in/roo13 8incolnshire3 8+( #-C3 &ngland
D44 ;0=14'2 ".(("(