v2011 Alignment Review Plane / Line / Point Alignment Theory Video (Click button to play). Example Alignment Plane (Datum A) Line (Datum B) Point (Datum C)
Datum A (Primary Datum): Plane Datum B (Secondary Datum): Line Datum C (Tertiary Datum): Point
Alignment Procedure: Level 1. Measure a Plane on Datum A with at least 3 points in a triangular pattern and then press Done on the jogbox.
2. Open the Alignment Utilities dialog box (Insert > Alignment > New).
3. Make the dialog selections as shown.
a. Pick the Level Feature. b. Select the vector direction. c. Push the Level button. Alignment Procedure: Rotate 4. Measure a Line on Datum B from left to right and then press Done on the jogbox..
5. Open the Alignment Utilities dialog box (Insert > Alignment > New).
6. Make the dialog selections as shown.
a. Pick the Rotate Feature. b. Select Rotate to: XPLUS (the line direction).
c. About: ZPLUS (the Level direction). d. Push the Rotate button. Alignment Procedure: Origins 7. Measure a Point on Datum C and press Done on the jogbox..
8. Open the Alignment Utilities dialog box (Insert > Alignment > New).
9. Make the dialog selections as shown.
a. Pick the Point b. Check X c. Push Origin d. Pick the Line e. Check Y f. Push Origin g. Pick the Plane h. Check Z i. Push Origin Alignment Verification 10. Open the Probe Readout Window remember the shortcut key.
11. Position the probe (ruby tip) at the approximate location of the origin. Observe the X, Y and Z values in the Probe Readout Window are approximately zero.
12. Move the probe along the X axis of the part and observe the X values in the Probe Readout Window count positive.
13. Move the probe up in Z and observe the Z values in the Probe Readout Window count positive.
14. The direction of the Y axis follows the right hand rule as shown.
Ctrl W + Rotate Direction Level Direction This third direction is forced mutually perpendicular to the two previous direction vectors based on the right hand rule. pc dmis pro cad cad++ v2011 End of Alignment Review
Geometrical Dimensioning and Tolerancing for Design, Manufacturing and Inspection: A Handbook for Geometrical Product Specification Using ISO and ASME Standards