Escolar Documentos
Profissional Documentos
Cultura Documentos
Route Planning
Starting from the Great Northern Highway near Fitzroy Crossing, we planned to emerge from the
desert on the NW Coastal Highway near Sandfire Roadhouse, the full distance of the desert crossing
being around 800-900km which should take around 2 weeks. Alternative exit route strategies were
considered via the Edgar Ranges north west to the Roebuck Plains if the western route became
impassable.
A things transpires, due to emerging fuel concerns, we had to abandon the side trip to Joanna Springs,
which would have added around 250km to the route, and put that on the list for a future trip.
The blue and red tracks on the map above indicates our actual desert track, with the red centre section
(about 400km) being the most challenging section. For most of that section there were almost no
visible tracks to follow, only feint Google Earth photos of tracks (which were a few years old) that I had
saved and geo-referenced for our mapping software before leaving home, and occasional exploration
cut lines from the 1970s and 80s, most of which are very overgrown at ground level.
We had some old mining maps of the 1980s and GPS track plots from a couple of previous expeditions,
but vegetation conditions can change significantly over just a few years, and even our most detailed
topographical maps (EOTopo 200K maps from Exploroz) showed no tracks at all for around 70km
where our route crossed the Calvert Expeditions route of 1896 (the feint yellow south-north line on the
map above). That 70km section would take us 2 1/2 days to cross.
27 July
We had all arranged to meet at mid-day at a point 70km south east of Fitzroy Crossing on 29 July to
start the crossing, but starting from 3 widely dispersed parts of the country, getting to the starting
point was our first challenge. We came up from Adelaide, Dave and Pauline came up from Perth, and
Deano and Kaye came across from touring in Queensland.
Coming up from Adelaide in less than a week, we completed the 1100km Tanami Track to Halls creek
and met up with Deano and Kaye in the caravan park at Halls Creek. We compared notes on our Okas
at some length and I did some maintenance work on the handbrake since the cable had slipped off its
pulley and was jamming and got badly frayed.
I tidied up the sharp hard frayed ends, wrapped them in tape, and to ensure the same thing didnt
happen again, I fitted a bespoke stop to the handle so that only fresh unfrayed cable went around the
29 July
We met up with Dave and Pauline at the Cherrabun T/O, after a 140km drive from our previous Laura
River campsite with Deano and Kaye, who we teamed up with in Halls Creek. They arrived one minute
early and we arrived one minute late, not bad after 2500km from Adelaide.
The first meeting of our 3 Okas:
[Note for the future regarding fuel: In hindsight, we should have gone the next 70km to refuel again
in Fitzroy Crossing. The 200km from Halls Creek had used valuable fuel which we were to need
during the latter stages of the desert crossing, but we didnt realise at the time quite how tough the
crossing would be on fuel.
We had worked on a worst case average fuel consumption of around 4km/l, as we had experienced
on the CSR, but actually it was twice as heavy for much of the crossing, averaging 2.5km/l for the
most challenging sections. A lesson for the future.]
We drove quickly though picturesque Cherrabun station on rough station tracks, keen to get camped
on an old abandoned WMC airstrip on the desert crossing proper.
We located the old WMC airstrip about 100km in from the highway and set up for our first camp.
We all had superb BBQ-ed Baramundi for dinner, courtesy of Dave and Pauline who had brought them
from Jubillee Station where theyd been staying (and obviously fishing).
A high flyer passed over our airstrip campsite, which seemed appropriate.
30 July
We passed the junction of the old 1980s WMC mining track with its still legible (and sadly accurate)
sign:
At the track junction we stopped for a group photo, in this area the track is still in very good condition:
We drove though an abandoned Aboriginal out station and refilled with water at their still working
water system, since we werent sure where our next water source would be.
A few km further on we met the junction of the McLarty Track and turned west.
The track deteriorated in visibility and quality as we headed further west but the purple flowers and
Holly Grevillea looks very pretty, when they werent blocking our way.
We camped 90km further on from last night, just off the track at an old mining campsite used by Dave
a few years ago.
We located their still working bore and drew water using Daves very effective flap pump. We didnt
know it then but this would be the last useable water we located until Sandfire Roadhouse a week and a
half later.
To demonstrate the amount of recent vegetation growth in the GSD, this is a merged photo of the same
area now, and in 2010:
31 July
From here the track started to deteriorate further and became overgrown requiring frequent deviations
around thickets of small trees and bushes where we couldnt push through them. We only achieved
47km today.
1 Aug
Another slow day along the McLarty Track, we only achieved 44km today.
There is no dotted line on the map to follow for 70km across this section of desert, 2 1/2 days drive:
We were on even more our own for this section, but we knew where we were and we knew what we
were heading for.
Fortunately there were still some signs of a track on the ground and occasional signs of human
presence to provide reassurance we were on the right line.
We passed the approximate location where the 1896 Calvert Expedition crossed our track. [Calvert
financed the expedition but it was led by Larry Wells, you can read the book of their explorations
online here]. They were heading north and having to cross thousands of sand dunes in the process,
whereas our track was predominantly east/west to minimise dune crossings but we still crossed more
than 100.
Our 700km desert track, in red, superimposed on Calverts 1896 map of unexplored areas of north
western Australia.
Two of Calvert/Wellss men (Charles Wells, cousin of Larry, and George Jones) died in the desert of
heat and thirst in November 1896, a days march from Joanna Springs, but it took 6 months of
exhausting searches to find them. Their mummified bodies were eventually recovered and buried in
Adelaide.
Although we didnt reach Joanna Springs due to fuel concerns, there is a memorial plaque to the 2 lost
men, installed there by the Land Rover Calvert Centenary Expedition, (photo courtesy of Mick O on
Exploroz):
Back on our track the thickets were becoming thicker but at least we didnt have to find water for our
camels:
2 Aug
This was the day we had to seriously start making our own tracks.
The dotted red line on the maps disappeared completely yesterday and today the tracks on the ground
did likewise. We were left with Google Earth photos and the track plot of a previous adventurer to
guide us. As a result we could only achieve 22km today.
Things started out OK
We did find a large spider hanging from silver threads of steel. He (or she) obviously knew how to
survive out here:
Heres a video of pushing our way across the desert spinifex. It started fairly easy but was to become
more difficult, much more difficult in the later stages of our trek.
3 Aug
After about 20km this morning we regained the red line on the map and reached the McLarty No 1 drill
site, but we couldnt locate their bore, so we had lunch here instead.
The McLarty No 1 drill site was made in 1968, with the details firmly etched into a piece of thick steel
plate.
We located the junction of the Edgar Ranges Track from the north which showed some evidence of
recent wheel tracks (a day or 2 old) although we never saw anyone, and turned south down the
McLarty Hills track which was an old mining cut line but now mostly very indistinct and overgrown.
We managed a bit further today, 32km, but it was hard slog and we were getting tired so we made
camp a few km short of the McLarty Hills, they could wait until tomorrow.
Camels came to visit our campsite, but they were more curious than threatening but we were very
cautious, large male camels can be very protective of their harem if threatened:
As I explored the facilities around the campsite I noted that its so dry out here your wee dries up
before it hits the ground (almost, men only).
Tomorrow we should reach the McLarty Hills, our first major objective. See Exploring the McLarty
Hills.