Escolar Documentos
Profissional Documentos
Cultura Documentos
and shall not be copied or used any manner, except with Embraers written consent.
and shall not be copied or used any manner, except with Embraers written consent.
PURPOSE
EMBRAER 170 / 190
and shall not be copied or used any manner, except with Embraers written consent.
I/O MODULE
POWER
SUPPLY
NETWORK
INTERFACE
CONTROLLER
PROCESSOR
BACKPLANE B (BOTTOM)
MAU CHANNEL ( EXAMPLE )
and shall not be copied or used any manner, except with Embraers written consent.
and shall not be copied or used any manner, except with Embraers written consent.
and shall not be copied or used any manner, except with Embraers written consent.
FIM TASK
and shall not be copied or used any manner, except with Embraers written consent.
On
the
CMC
OVERHEAT
DETECTION
PARAMETERS screen, look at BLEED 1, BLEED 2
or APU OVERHEAT LOCATION VALUES to
identify the bleed leakage point.
Record the values and check the Table for access
panel and XYZ coordinates of the leakage spot. (see
example below)
and shall not be copied or used any manner, except with Embraers written consent.
and shall not be copied or used any manner, except with Embraers written consent.
and shall not be copied or used any manner, except with Embraers written consent.
CMC
and shall not be copied or used any manner, except with Embraers written consent.
CMC
1 - The WWSC senses that the fill/drain valve is not in the position
(open/closed) set in the fill/drain switch after 5s (38100227WWS)
1.1 Failure of the FILL/DRAIN VALVE
1.2 Defective HARNESS
1.3 Failure of the WWSC
2 The WWSC senses that the FWD drain valve is not in the
position (open/closed) set in the fill/drain switch after 5s
(38100226WWS)
2.1 Failure of the FORWARD DRAIN VALVE
2.1 Defective HARNESS
2.3 Failure of the WWSC
and shall not be copied or used any manner, except with Embraers written consent.
and shall not be copied or used any manner, except with Embraers written consent.
hot air
Pressure-actuated
torque motor symbol
ACM shaft
To ECS system
and shall not be copied or used any manner, except with Embraers written consent.
and shall not be copied or used any manner, except with Embraers written consent.
and shall not be copied or used any manner, except with Embraers written consent.
and shall not be copied or used any manner, except with Embraers written consent.
and shall not be copied or used any manner, except with Embraers written consent.
and shall not be copied or used any manner, except with Embraers written consent.
If
or
EICAS messages are displayed on the EICAS
perform the follow procedure:
1) Go to CMC MAIN MENU pages on MFD 2 and
click on the MAINTENANCE MESSAGES:
GO TO
MAINTENANCE
MESSAGES
and shall not be copied or used any manner, except with Embraers written consent.
GO TO ACTIVE
or
HISTORICAL BY
DATE
HISTORICAL BY DATE
and shall not be copied or used any manner, except with Embraers written consent.
EICAS message
and shall not be copied or used any manner, except with Embraers written consent.
4) The CMC will display the FDE (Flight Deck Effect) DETAIL
page and MAINTENANCE FAULT CODE for correlated CAS
MSG.
FDE NAME: The title of the FDE,
the same title as CAS message
and shall not be copied or used any manner, except with Embraers written consent.
and shall not be copied or used any manner, except with Embraers written consent.
MAINTENANCE
MSG Fault Code
with 11
characters
In some cases the FIM Task will guide you to the ENG
MAINTENANCE MANUAL.
and shall not be copied or used any manner, except with Embraers written consent.
and shall not be copied or used any manner, except with Embraers written consent.
and shall not be copied or used any manner, except with Embraers written consent.
EICAS message
and shall not be copied or used any manner, except with Embraers written consent.
and shall not be copied or used any manner, except with Embraers written consent.
and shall not be copied or used any manner, except with Embraers written consent.
CAS
message
field
and shall not be copied or used any manner, except with Embraers written consent.
E = Engine
1 or 2 = eng 1 or 2
A or B = FADEC Channel
Fault code
to be used
on the FIM
and shall not be copied or used any manner, except with Embraers written consent.
and shall not be copied or used any manner, except with Embraers written consent.
Ailerons
PCUs
location
and shall not be copied or used any manner, except with Embraers written consent.
and shall not be copied or used any manner, except with Embraers written consent.
-300
-250
- 50
Less than 400 psi:
WITHIN the limits
Formula ( A B )
P = -300 - (-250)
= -300 + 250
P = -50 psi
and shall not be copied or used any manner, except with Embraers written consent.
EX:
+150
EX:
- 800
950
More than 400 psi:
OUT of the limits
Formula ( C D )
P = +150 - (-800)
= +150 + 800
= 950 psi
and shall not be copied or used any manner, except with Embraers written consent.
and shall not be copied or used any manner, except with Embraers written consent.