Escolar Documentos
Profissional Documentos
Cultura Documentos
MANUAL
Preface
Thank you for purchasing the tracker. This manual shows how to operate the device
smoothly and correctly. Make sure to read this manual carefully before using this
product. Please note that specification and information are subject to changes without
prior notice in this manual. Any change will be integrated in the latest release. The
manufacturer assumes no responsibility for any errors or omissions in this document.
1Summary
Working Based on existing GSM/GPRS network and GPS satellites, this product can
locate and monitor any remote targets by SMS or internet.
2Introduction
3 LED Indication
3.1 Red LEDpower/working status indicator
Status
Meaning
Continuously in bright
Continuously in dark
Fully charged
No battery/troubleshot
Meaning
GPS signal has been acquired successfully
GPS signal was searching
GPS stops working/ the gps was sleeping
Status
Quick flashing
Slow flashing
Continuously in dark
Meaning
GSM initialization
GPRS online
No GSM signal or the gps was sleeping
number
1
2
3
4
5
6
7
definition
V+
VACC
Oil
TX
RX
GND
color
red
black
orange
yellow
blue
green
purple
Wiring instructions
Positive pole
Negative pole
ACC ignition
Relay controlled wire
Send data / for backup
Receive data / for backup
Ground wire
5Installation
5.1 Wiring :
5.2 Placement
The terminal should be placed under cover. It is recommended to ask professional
companyes to install the terminal for you
NOTE: The GPS signal will be attenuated if the device is installed under the driver
seat
6 Power ON/OFF
6.1 Power ON
The terminal will be automatically ON, when you insert the SIM card into the SIM
card slot. The battery will connect the internal wires together in the terminal and the
external power supply. will start providing power to the device and also charging the
battery.
After the power is ON, it will start searching the GSM and GPS signal. During this
period, the Red LED ( power ) is long right , the Green LED (GSM) is flashing ,the
5
Blue LED (GPS) is long right too. When the Blue LED( GPS) is flashing, after the
Green LED (GSM) flashing every time 8seconds ,means the GPS was working.
6.2 Power OFF
Pull out the SIM card, the terminal will be off.
7parameter
Name
Dimensions
Communication
network
GSM frequency
GPS chip
GSM chip
GPS sensitivity
GPS positioning
accuracy
battery
Working time
Voltage
Current
Standby current
Dust levels
Water level
Storage
Temperature
Operating
temperature
Humidity
Parameter
97mm * 57mm * 19mm
GSM/GPRS
GSM 850/900/1800/1900 MHz
G-TOP
MTK
-159dBm
5-30m
450mAH
5hour
DC 12~90V
<80mA
<10mA
IP6x
IPx5
-40C to +85C
-20C to +65C
5%--95% non-condensing
8.Operating Instructions
default password is 0000.
lat:11456.209400, latitude;
lng: 2233.470100; longitude;
distance: 500; fence radius;
time: 5 sampling interval;
status: 2 , terminal has obtained valid satellite data, fence works normally;
status: 1; fence open, but there are no valid satellite data have been received;
status: 0, no electronic fence is set.
9.Control circuit:
9.1 Fuel cut
Send command: 222+password
For example: 2220000, the device will cut off the fuel, and then your cell phone will
get a message RF2 OK from the device.