Escolar Documentos
Profissional Documentos
Cultura Documentos
Network Camera
Model No.
Please read this document before using the product, and save this document for future
reference. Panasonic Network Camera Website: http://panasonic.net/pcc/ipcam/
BB-HCM580A
BB-HCM581A
Abbreviations
This manual is written for both the BB-HCM580A (AC Adaptor Type) and
the BB-HCM581A (PoE Ready). Available features and operations vary
slightly depending on the model. You can confirm the model no. of your
camera by checking the model no. printed on the front of the camera.
Make sure you have read the Important Information document and
followed the instructions in the Installation Guide for connecting your
camera.
Trademarks
Adobe and Reader are either registered trademarks or trademarks of Adobe Systems
Incorporated in the United States and/or other countries.
Microsoft, Windows, Windows Vista, Windows Server, ActiveX, and Internet Explorer are
either registered trademarks or trademarks of Microsoft Corporation in the United States
and/or other countries.
Screen shots reprinted with permission from Microsoft Corporation.
All other trademarks identified herein are the property of their respective owners.
This software is based in part on the work of the Independent JPEG Group.
If you are using firewall or antivirus software on your PC, the Setup Program may not
be able to find any cameras on your network. If you cannot disable your firewall or
antivirus software, you can configure the camera by entering its MAC address (see
Camera Diagram on page 2 of the Installation Guide to find your cameras MAC
address label).
If the following ActiveX Controls dialog is displayed, click [Install ActiveX Control...].
If you have more than one camera, you can distinguish cameras by model number,
printed on the front of the camera, or by MAC address (see Camera Diagram on
page 2 of the Installation Guide to find your cameras MAC address label).
If more than 20 minutes have passed since the selected camera was turned on, you
cannot configure the camera. Turn off the camera, then turn it on again. This restriction
does not apply to cameras which have not been configured yet or have been reset to
their factory default settings.
8. Click the [Setup] tab, click [Date and Time] on the left
side of the screen, then set the cameras date and
time. Click [Save] when finished.
For more information, refer to 5.3 Setting the Date
and Time in the Operating Instructions on the CDROM.
If you enabled [Auto Port Forwarding (IPv4)], the cameras port number may have
changed. Do not forget the addresses displayed here.
To confirm that the camera can be accessed from the Internet using a PC, use a PC
not connected to your network and access the camera using the address displayed
here.
The IP address or URL used to access the camera over the Internet will also be
displayed on the [Status] page of the [Maintenance] tab.
Note:
Network Camera Recorder with Viewer Software Single Camera
Version is compatible with Microsoft Windows Vista, Windows
XP and Windows Server 2003.
Camera registration is limited to one camera.
Support is not provided for the single camera version of this
software.