Escolar Documentos
Profissional Documentos
Cultura Documentos
c
voltage equal to multiplier of the peak input voltages Vp i.e., 2Vp, 3Vp, 4Vp.
During the positive half-cycle of the input signal, the diode DI conducts and
diode D2 is cut off, charging the capacitor CI up to the peak rectified voltage i.e., Vm.
During the negative half-cycle, diode, D1 is cut off and diode D2 conducts charging
capacitor C2. It may be noted that during negative half cycle, the voltage across
capacitor C1 is in series with the input voltage. Therefore the total voltage presented
to capacitor C2 is equal to 2Vm during the negative half cycle.
On the next positive half cycle, the diode D2 is non-conducting and the capacitor will
discharge through the load. If no load is connected across capacitor C2, both
capacitors stay charged at their full values (i.e., C1 to Vm and C2 to 2Vm). It may be
noted that both the diodes D1 and D2have a peak inverse voltage (PIV) of 2Vm each.
Above Figure shows another voltage doubler circuit known as full-wave voltage
doubler. In this circuit during, the positive half cycle of a.c. input voltage,
diode D1 conducts charging capacitor CI to a peak voltage Vm with polarity. The
diode D2 is cut off at this time.
During the negative half cycle the diode D2 conducts (while D1 is at cut-off) charging
capacitorC2 to Vm. If there is load connected across the output, then the output
voltage is equal to2Vm. However, if the load is connected, then the voltage would be
less than 2Vm.
VOLTAGE TRIPLER
During the first positive half cycle, the capacitor C1 charges through diode D1 to a
peak voltageVm. During negative half cycle, capacitor C2 charges through diode D2 to
twice the peak voltage 2Vm developed by the sum of the voltages across
capacitor C1 and the input signal.
VOLTAGE QUADRUPLER
The addition of still another diode-capacitor section to the voltage Tripler produces
an output four times the peak voltage. The circuit diagram is shown in below Figure.
Application
Voltage multipliers are used in high voltage, low current applications such as for
accelerating purpose in a cathode ray tube. Generally these are used where both the
supply voltage and load are maintained constant.