Escolar Documentos
Profissional Documentos
Cultura Documentos
5. the minimum cross sectional area at the seat of the control valve or the supply pipe or tubing
which feeds the device outlet. If two or more lines supply one outlet, the effective opening
shall be the sum of the cross-sectional areas of the individual supply lines or the area or the
single outlet, whichever is smaller.
A.
effective opening
B.
effective depth
C.
effective area
D.
effective invert
6. Suspended cast iron soil pipe shall be supported at not more than ____m intervals, except that
pipe exceeding 1.5m length may be supported at not more than _____m intervals. Supports
shall be adequate to maintain alignment & to prevent sagging & shall be placed within 0.45m
of the hub or joint.
A.
1.5/ 3
B.
1.5/ 4
C.
3/ 1.5
D.
4/ 1.5
7. No water closet or bidet shall be set closer than ______m from its center to any side of the
A.
B.
C.
D.
wall or obstruction or closer than ______m center to center to any similar fixture.
.375 / 0.75
.375 / 0. 70
.40 / 0.70
.50 / 0.60
8. Lead Pipe
- shall be supported at by____________for entire length with hangers
properly spaced.
A.
Stiff aluminum or wooden backing
B.
stiff metal or wooden backing
C.
stiff plastic or metal sheet
9. Fixtures having concealed slip joint connections shall be provided with an access panel or
utility at least ______m in its least dimension for inspection & repair.
A.
0.30
B.
0.20
C.
0.10
D.
0.40
10.
A.
B.
C.
D.
11. drains shall have a waterway equivalent area of the tailpiece meaning, the sum of all the
areas of the perforation of the strainer is equivalent to the outlet area.
A.
Strainers serving bathub
B.
Strainers serving shower
C.
Strainers serving lavatory
D.
none of the above
12. Copper Tubing - shall be supported at approximately ________m intervals for piping 38mm
diameter & smaller & _______m intervals for piping 51mm & larger in dia.
A.
1.8/ 3.0
B.
1.9/ 3.5
C.
1.5 / 2.5
D.
none of the above
13. Continuous waste fixture tailpiece connections were exposed or accessible may be of
seamless drawn brass not less than Ga. 20 B&S or ______mm thk.
A.
0.90
B.
0.80
C.
0.70
D.
0.60
14. All porcelain enamel surfaces on plumbing fixtures shall be __________
A.
mold resistant
B.
acid resistant
C.
corrosion resistant
D.
15. All pipe determinations shall be based on eighty percent (___) the reduced pressure.
A.
70%
B.
60%
C.
80%
D.
90%