Escolar Documentos
Profissional Documentos
Cultura Documentos
divide-and-conquer
impossible to determine from this information
5. Refer to the exhibit. What are two possible causes for the interface status?
(Choose two.)
The loopback address is not set.
The encapsulation type is mismatched.
A cable is not attached to the interface.
Keepalive messages are not being received.
The interface is administratively shut down.
6. Refer to the exhibit. Host H1 on the LAN is not able to access the FTP server
across the Internet. Which two configuration statements are causing this
problem? (Choose two.)
There is no route to the Internet.
The IP address on Fa0/0 is incorrect.
The IP address on S0/0/0 is incorrect.
The NAT command on the Fa0/0 interface is applied in the wrong direction.
The NAT command on the S0/0/0 interface is applied in the wrong direction.
7. Which two conditions identify issues that are confined to Layer 1? (Choose
two.)
cables that exceed maximum length
encapsulation errors
viruses and worms that create excessive broadcast traffic
poor termination of cables
receiving line protocol down messages on the router console
8. A network administrator is upgrading a Cisco 1841 router by adding a WIC-2T
module card. Which show command can the administrator use to verify that the
module is correctly recognized by the router?
show flash:
show version
show ip route
show startup-configuration
9. Hosts on two separate subnets cannot communicate. The network
administrator suspects a missing route in one of the routing tables. Which three
commands can be used to help troubleshoot Layer 3 connectivity issues?
(Choose three.)
ping
show arp
traceroute
show ip route
show controllers
show cdp neighbor
10. Refer to the exhibit. Which statement is true regarding the IP address
configuration?
Interfaces Fa0/0 and Fa0/1 can be in the same subnet.
Interface Fa0/0 and NetworkA can be in the same subnet.
Interface Fa0/0 and NetworkB can be in the same subnet.
Interface Fa0/1 and NetworkB can be in the same subnet.
11. A network administrator plugs a new PC into a switch port. The LED for that
port changes to solid green. What statement best describes the current status of
the port?
There is a duplex mismatch error.
There is a link fault error. This port is unable to forward frames.
The port is operational and ready to transmit packets.
This port has been disabled by management and is unable to forward frames.
The flash memory is busy.
12. Refer to the exhibit. Which three statements are true about the output of the
show ip interface brief command? (Choose three.)
FastEthernet0/0 is functioning correctly.
The shutdown command has been applied on Serial0/0.