Você está na página 1de 31

Gas Condensate PVT Analysis Workbook

Written by Robert Mott, August 2003


This worksheet analyses results from CVD and CCE tests on a gas condensate fluid
Data should only be entered on yellow cells
First enter CVD data (below the dew point) on the sheet 'CVD Data'
Then enter CCE relative volumes (above the dew point) on the sheet 'CCE Data'
Recovery factors for individual components and for stock tank oil and gas are shown on the sheet 'Recovery factors'
The sheet 'CVD analysis' contains material balance calculations which can be used as a consistency check of CVD data
These checks are described in 'Phase Behavior', SPE Monograph 20, by Whitson and Brule
The material balance checks calculate liquid phase densities and compositions.
Densities and K-values from the material balance calculation are displayed as charts.

Non-monotonic behaviour for the K-value or liquid density curves will cast some doubt on the validity of the CVD measurem

If the liquid composition is measured at the end of the CVD, two other material balance checks can be used.
A 'Forward Material Balance' calculates the final liquid composition from the original composition, liquid saturations, Z-facto
amounts of gas removed, and the gas compositions at each step.

A 'Backward Material Balance' calculates the original composition from the final liquid composition, final liquid saturation, fi
Z-factor, the amounts of gas removed, and the gas compositions at each step. This is a better check for lean condensates
The Material Balance checks are shown on the sheet 'Material Balance'.

JACK KNIFE 1
Nitrogen
Carbon
Methane
Ethane
Propane
Isobutane
n-Butane
2,2
Isopentane
n-Pentane
2,2
Cyclopentane
2,3

n-Hexane
Heptanes

Dioxide

Dimethylpropane

Dimethylbutane
Dimethylbutane
2 Methylpentane
3 Methylpentane
Plus

0
0
0.002
0.008
0.154
0.188
0.608
0.004
0.835
1.099
0.055
0
0.356
0.84
0.56
1.423
93.867

N2
CO2
H2S
C1
C2
C3
iC4
nC4
iC5
nC5
C6
C7+

0.000
0.000
0.000
0.002
0.008
0.154
0.188
0.608
0.839
1.099
3.234
93.867

CVD Data
The first pressure must be the dew point pressure
The number of pressure entries must be set to display the charts correctly
Number of pressure entries

Plus fraction

C7+

Pressure (psig)

5535

4500

3500

2500

1700

900

Wellstream produced (cum %)


Liquid volume (%)
Equilibrium gas Z-factor

0
0
1.0823

7.976
17
0.9202

21.98
22.842
0.8515

39.965
23.832
0.8369

56.259
22.309
0.8568

73.951
19.063
0.9069

Equilibrium gas composition


N2
CO2
H2S
C1
C2
C3
iC4
nC4
iC5
nC5
C6
C7+

0.393
1.776
0.000
68.250
7.024
6.625
1.418
2.319
0.857
0.842
0.968
9.529

0.405
1.829
0.000
71.913
7.178
6.501
1.352
2.178
0.800
0.787
0.857
6.200

0.433
1.863
0.000
74.339
7.244
6.501
1.312
2.113
0.766
0.757
0.771
3.900

0.442
1.899
0.000
75.538
7.464
6.501
1.300
2.113
0.724
0.716
0.701
2.600

0.437
1.936
0.000
76.049
7.621
6.501
1.324
2.113
0.690
0.681
0.647
2.000

0.428
1.945
0.000
74.723
7.691
7.112
1.462
2.360
0.815
0.762
0.701
2.000

C7+ molecular weight


C7+ specific gravity

169.53
0.8163

149.703
0.8013

136.501
0.7897

126.627
0.7803

120.849
0.7746

116.4
0.7699

Total composition

100.00

100.00

100.00

100.00

100.00

100.00

mol vol
Plus fraction prod
Cum moles

207.7

186.8
172.9
162.3
156.0
151.2
0.494512 0.546156 0.46761 0.32588 0.35384
0 0.494512 1.040668 1.508278 1.834158 2.187998
5.2%
10.9%
15.8%
19.2%
23.0%

Vol prod
Cum vol

Initial moles
Vol

92.38728
94.404
92.38728 186.7913
4.7%
9.4%
9.529
1978.992

75.8837 50.84208 53.49653


262.675 313.5171 367.0136
13.3%
15.8%
18.5%

2
93.845
14.967
1

0.335
1.612
0.000
60.118
7.178
8.091
1.991
3.243
1.213
1.151
1.268
13.800
131.537
0.785
100

167.6
2.745372
4.93337
51.8%
460.0229
827.0365
41.8%

Equilibrium
Liquid
(last stage)

0.000
0.000
0.000
0.002
0.008
0.154
0.188
0.608
0.839
1.099
3.234
93.867

N2
CO2
H2S
C1
C2
C3
iC4
nC4
iC5
nC5
C6
C7+

189.3 C7+ molecular weight


0.8276 C7+ specific gravity
100.00

182.4085 Residual liq MW

MW
Mwref
28.013
44.01
34.076
16.04
30.07
44.09
58.12
58.12
72.15
72.15
86.17

Density
(lb/ft3)

35.01
36.45
39.13
39.3
41.19

No of pressures in CVD
N_pres

Plus fraction
7

1
2
3
4
5
6
7
8
9
10

N_plus
PlusFrac

2
7
C7+

C6+
C7+
C8+
C9+
C10+
C11+
C12+

General Information
NS-1 fluid
Reservoir temperature (deg F)
Initial pressure (psig)

263
10440

Definition of oil for surface oil and


gas recoveries

C5+

CCE Data
only enter data at or above dew point pressure
enter pressures in descending order
Pressure
Relative
psig
volume
10440
0.83715
5535
1

C4+
C5+
C6+
C7+
Oil frac

Calculated oil gas ratio - assumes surface oil = C5+


Tstd
Pstd

520 deg R
14.7 psia

Forward material balance


Calculates residual liquid composition

Backward material balance


Calculates initial gas composition
Calculated density of residual liquid
Density to use in calculation

N2
CO2
H2S
C1
C2
C3
iC4
nC4
iC5
nC5
C6
C7+

Measured Calculated
0.00
0.10
0.00
0.73
0.00
0.00
0.00
13.27
0.01
0.75
0.15
1.31
0.19
0.28
0.61
0.91
0.84
0.93
1.10
1.13
3.23
3.07
93.87
77.51
100.00

100.00

N2
CO2
H2S
C1
C2
C3
iC4
nC4
iC5
nC5
C6
C7+

Measured
0.39
1.78
0.00
68.25
7.02
6.63
1.42
2.32
0.86
0.84
0.97
9.53
100.00

material balance
initial gas composition
44.6 lb/ft3
51.28 lb/ft3
Calculated
0.39
1.73
0.00
67.46
6.98
6.56
1.41
2.30
0.85
0.84
0.98
10.51
100.00

0.8214

Recovery factors from depletion, no water influx


100.0%
90.0%

C1

C2

C3

C4's

C5's

C6

50.0%

C7+

Gas

40.0%

Oil

Recovery factors

80.0%
70.0%
60.0%

30.0%
20.0%
10.0%
0.0%
12000

10000

8000

6000

4000

abandonment pressure (psig)

2000

Calculated oil gas ratio - assumes surface oil = C5+


300.00

OGR (bbl/MMscf)

250.00

200.00

150.00

100.00

50.00

0.00
0

1000

2000

3000

pressure (psia)

4000

5000

6000

K-values calculated from material balance analysis of CVD data


10.0000
CO2
C1
C2
C3
iC4
nC4
iC5
nC5
C6
Row
126
Row
127
Row
128
Row
129

1.0000

0.1000

0.0100
0

1000

2000

3000

pressure (psia)

4000

5000

6000

Oil and Gas Densities calculated from material balance analysis of CVD data
900.00
800.00

density (Kg/m3)

700.00
600.00

liquid density
(kg/m3)

500.00
400.00

gas density
(kg/m3)

300.00
200.00
100.00
0.00
0

1000

2000

3000

pressure (psia)

4000

5000

6000

Calculated modified black oil properties


Pressure (psia)
Pressure (psia)
Moles of Gas
up to C3
C4
C5
C6
Gas volume at surface
(ft3/mol of equil gas)

Moles of oil
iC4
nC4
iC5
nC5
C6
C7
C8
C9
C10
C11
C7+
Volume of Oil
iC4
nC4
iC5
nC5
C6
C7
C8
C9
C10
C11
C7+
Oil volume at surface (ft3/mol
of equil gas)
Oil-gas ratio (bbl/MMscf)
GOR (scf/STB)
Gas FVF (res bbl/Mscf)

5535
5549.7

4500
4514.7

3500
3514.7

2500
2514.7

1700
1714.7

84.068
3.737
0
0

87.826
3.53
0
0

90.38
3.425
0
0

91.844
3.413
0
0

92.544
3.437
0
0

333.339

346.820

356.117

361.629

364.378

0
0
0.857
0.842
0.968
0
0
0
0
0
9.529

0
0
0.8
0.787
0.857
0
0
0
0
0
6.2

0
0
0.766
0.757
0.771
0
0
0
0
0
3.9

0
0
0.724
0.716
0.701
0
0
0
0
0
2.6

0
0
0.69
0.681
0.647
0
0
0
0
0
2

0.0000
0.0000
0.0158
0.0155
0.0203
0.0000
0.0000
0.0000
0.0000
0.0000
0.3171

0.0000
0.0000
0.0148
0.0144
0.0179
0.0000
0.0000
0.0000
0.0000
0.0000
0.1856

0.0000
0.0000
0.0141
0.0139
0.0161
0.0000
0.0000
0.0000
0.0000
0.0000
0.1080

0.0000
0.0000
0.0133
0.0131
0.0147
0.0000
0.0000
0.0000
0.0000
0.0000
0.0676

0.0000
0.0000
0.0127
0.0125
0.0135
0.0000
0.0000
0.0000
0.0000
0.0000
0.0500

0.3687

0.2328

0.1522

0.1088

0.0888

196.98
5077
0.8082

119.53
8366
0.8118

76.11
13138
0.9397

53.57
18666
1.2712

43.39
23048
1.8943

900
914.7

2
16.7

91.899
3.822
0
0

77.334
5.234
0
0

363.391

313.457

0
0
0.815
0.762
0.701
0
0
0
0
0
2

0
0
1.213
1.151
1.268
0
0
0
0
0
13.8

0.0000
0.0000
0.0150
0.0140
0.0147
0.0000
0.0000
0.0000
0.0000
0.0000
0.0485

0.0000
0.0000
0.0224
0.0211
0.0265
0.0000
0.0000
0.0000
0.0000
0.0000
0.3706

0.0921

0.4406

Carbon_no
4
5
6

4
4
5
5
6
7
8
9
10
11
7
MW

45.16
250.35
22143
3994
3.7688 263.8803

58.12
58.12
72.15
72.15
86.17
100.2
114.2
128.3
142.3
156.3

Density
(lb/ft3)
35.01
36.45
39.13
39.30
41.19
42.58
44.19
45.35
45.68
46.00

Calculated recovery factors


Calculated recovery factors for each component
Abandonment pressure (psia)

10440

5535

4500

3500

2500

1700

Component
C1
C2
C3
C4's
C5's
C6
C7+

0.0%
0.0%
0.0%
0.0%
0.0%
0.0%
0.0%

#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!

#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!

#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!

#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!

#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!

Gas
Oil

0.0% #VALUE! #VALUE! #VALUE! #VALUE! #VALUE!


0.0% #VALUE! #VALUE! #VALUE! #VALUE! #VALUE!

Moles produced at each step


N2
CO2
H2S
C1
C2
C3
iC4
nC4
iC5
nC5
C6
C7+

0
0
0
0
0
0
0
0
0
0
0
0

0.032
0.146
0.000
5.736
0.573
0.519
0.108
0.174
0.064
0.063
0.068
0.495

0.061
0.261
0.000
10.410
1.014
0.910
0.184
0.296
0.107
0.106
0.108
0.546

0.079
0.342
0.000
13.586
1.342
1.169
0.234
0.380
0.130
0.129
0.126
0.468

0.071
0.315
0.000
12.391
1.242
1.059
0.216
0.344
0.112
0.111
0.105
0.326

Moles of gas produced


up to C3
C4
C5
C6
Total
Cumulative total

0.000
0.000
0.000
0.000
0.000
0.000

7.005
0.282
0.000
0.000
7.287
7.287

12.657
0.480
0.000
0.000
13.136
20.423

16.518
0.614
0.000
0.000
17.132
37.555

15.079
0.560
0.000
0.000
15.639
53.194

Moles of oil produced


iC4
nC4
iC5
nC5
C6
C7+

0.000
0.000
0.000
0.000
0.000
0.000

0.000
0.000
0.064
0.063
0.068
0.495

0.000
0.000
0.107
0.106
0.108
0.546

0.000
0.000
0.130
0.129
0.126
0.468

0.000
0.000
0.112
0.111
0.105
0.326

Volume of oil produced (ft3/mol of equil gas)

iC4
nC4
iC5
nC5
C6
C7+
Total
Cumulative total

0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000

0.000
0.000
0.001
0.001
0.001
0.015
0.019
0.019

0.000
0.000
0.002
0.002
0.002
0.015
0.021
0.040

0.000
0.000
0.002
0.002
0.003
0.012
0.020
0.059

0.000
0.000
0.002
0.002
0.002
0.008
0.014
0.074

900

#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!

#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!

#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!

#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!

#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!
#VALUE!

V_Pinit
V_Pdew
N_init

#VALUE! #VALUE! #VALUE! #VALUE! #VALUE!


#VALUE! #VALUE! #VALUE! #VALUE! #VALUE!

0.076
0.344
0.000
13.220
1.361
1.258
0.259
0.418
0.144
0.135
0.124
0.354

0.067
0.321
0.000
11.960
1.428
1.610
0.396
0.645
0.241
0.229
0.252
2.745

0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000

0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000

0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000

16.259
0.676
0.000
0.000
16.935
70.129

15.385
1.041
0.000
0.000
16.426
86.555

0.000
0.000
0.000
0.000
0.000
86.555

0.000
0.000
0.000
0.000
0.000
86.555

0.000
0.000
0.000
0.000
0.000
86.555

Carbon_no

0.000
0.000
0.144
0.135
0.124
0.354

0.000
0.000
0.241
0.229
0.252
2.745

0.000
0.000
0.000
0.000
0.000
0.000

0.000
0.000
0.000
0.000
0.000
0.000

0.000
0.000
0.000
0.000
0.000
0.000

4
5
6

4
4
5
5
6
7

Initial gas
84.068
3.737
0.000
0.000
87.805

Initial oil
0.000
0.000
0.857
0.842
0.968
9.529

0.000
0.000
0.003
0.002
0.003
0.009
0.016
0.090

0.000
0.000
0.004
0.004
0.005
0.074
0.088
0.178

0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.178

0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.178

0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.178

0.000
0.000
0.016
0.015
0.020
0.317
0.369

#VALUE!
#VALUE!
#VALUE!

Initial gas

MW

Density

(lb/ft3)

58.12
58.12
72.15
72.15
86.17
Initial oil

35.01
36.45
39.13
39.3
41.19

temperature (deg R)

Tres

722.67 deg R

pressure (psia)

5549.7

4514.7

3514.7

wellstream produced (cum fraction)


liquid volume (fraction)
eq gas Z-factor

Np
SL
Z

0
0
1.0823

0.07976
0.17
0.9202

0.2198
0.22842
0.8515

Produced gas phase composition


N2
0.393
CO2
1.776
H2S
0
C1
68.25
C2
7.024
C3
6.625
iC4
1.418
nC4
2.319
iC5
0.857
nC5
0.842
C6
0.968
C7
0
C8
0
C9
0
C10
0
C11
0
C7+
9.529

0.405
1.829
0
71.913
7.178
6.501
1.352
2.178
0.8
0.787
0.857
0
0
0
0
0
6.2

0.433
1.863
0
74.339
7.244
6.501
1.312
2.113
0.766
0.757
0.771
0
0
0
0
0
3.9

gas phase composition

MW_plus

169.53

149.703

136.501

MW_gas

37.259

30.695

26.987

vol of 1 lb mole (ft3)


Gas density (lb/ft3)
Gas density (Kg/m3)

V
gas density (lb/ft3)
gas density (kg/m3)

1.5125
24.634
394.58

1.5808
19.417
311.03

1.8790
14.363
230.06

Lb Moles gas produced


Vol of gas in cell
Lb moles of gas in cell
Lb moles of liquid

Ngas_p
Vgas
Ngas
Nliq

0
1.5125
1.0000
0.0000

0.07976
1.2554
0.7942
0.1261

0.14004
1.1670
0.6211
0.1591

Mass removed
Mass of gas in cell
Mass of liquid
MW of liquid

Mgas_p
Mgas
Mliq

0.000
37.26
0.00

2.448
24.38
10.43
82.75

3.779
16.76
14.27
89.69

Liquid density (lb/ft3)


Liquid density (Kg/m3)

liquid density (lb/ft3)


liquid density (kg/m3)

40.58
650.00

41.30
661.57

moles of each component


remaining in cell

N2
CO2

0.361
1.630

0.300
1.369

0.393
1.776

(after extra gas has been removed)

moles of liquid in cell

MW of C7+ fraction in liquid

H2S
C1
C2
C3
iC4
nC4
iC5
nC5
C6
C7
C8
C9
C10
C11
C7+

0
68.25
7.024
6.625
1.418
2.319
0.857
0.842
0.968
0
0
0
0
0
9.529

0.000
62.514
6.451
6.106
1.310
2.145
0.793
0.779
0.900
0.000
0.000
0.000
0.000
0.000
9.034

0.000
52.104
5.437
5.196
1.126
1.849
0.686
0.673
0.792
0.000
0.000
0.000
0.000
0.000
8.488

Total

100.001

92.025

78.021

N2
CO2
H2S
C1
C2
C3
iC4
nC4
iC5
nC5
C6
C7
C8
C9
C10
C11
C7+

0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000
0.000

0.039
0.178
0.000
5.404
0.751
0.944
0.236
0.416
0.158
0.154
0.219
0.000
0.000
0.000
0.000
0.000
4.111

0.031
0.212
0.000
5.932
0.938
1.158
0.312
0.537
0.210
0.203
0.313
0.000
0.000
0.000
0.000
0.000
6.066

Total

0.000

12.610

15.912

#VALUE!

#VALUE!

Calculated liquid phase composition (mol %)


N2
0.31
CO2
1.41
H2S
0.00
C1
42.86
C2
5.96
C3
7.48
iC4
1.88
nC4
3.30
iC5
1.25
nC5
1.22
C6
1.74
C7
0.00
C8
0.00

0.20
1.33
0.00
37.28
5.89
7.28
1.96
3.37
1.32
1.28
1.97
0.00
0.00

C9
C10
C11
C7+

0.00
0.00
0.00
32.60

0.00
0.00
0.00
38.12

1.3073
1.2985
#DIV/0!
1.6779
1.2051
0.8687
0.7210
0.6608
0.6390
0.6434
0.4933
0.1902

2.2137
1.3975
#DIV/0!
1.9941
1.2291
0.8930
0.6701
0.6261
0.5800
0.5932
0.3922
0.1023

Backward material balance calculation


Calculate original gas composition from residual liquid and produced gas compositions
4514.7

3514.7

K-values
N2
CO2
H2S
C1
C2
C3
iC4
nC4
iC5
nC5
C6
C7+

N2
CO2
H2S
C1
C2
C3
iC4
nC4
iC5
nC5
C6

C7+

0.3869
1.7327
0.0000
67.4574
6.9787
6.5551
1.4121
2.3008
0.8518
0.8401
0.9781
0.0000
0.0000
0.0000
0.0000
0.0000
10.5054

0.0323
0.1459
0.0000
5.7358
0.5725
0.5185
0.1078
0.1737
0.0638
0.0628
0.0684
0.0000
0.0000
0.0000
0.0000
0.0000
0.4945

0.0606
0.2609
0.0000
10.4104
1.0144
0.9104
0.1837
0.2959
0.1073
0.1060
0.1080
0.0000
0.0000
0.0000
0.0000
0.0000
0.5462

99.9991

7.9760

14.0039

UGC

2514.7

1714.7

914.7

16.7

0.39965
0.23832
0.8369

0.56259
0.22309
0.8568

0.73951
0.19063
0.9069

0.93845
0.14967
1

0.442
1.899
0
75.538
7.464
6.501
1.3
2.113
0.724
0.716
0.701
0
0
0
0
0
2.6

0.437
1.936
0
76.049
7.621
6.501
1.324
2.113
0.69
0.681
0.647
0
0
0
0
0
2

0.428
1.945
0
74.723
7.691
7.112
1.462
2.36
0.815
0.762
0.701
0
0
0
0
0
2

0.335
1.612
0
60.118
7.178
8.091
1.991
3.243
1.213
1.151
1.268
0
0
0
0
0
13.8

126.627

120.849

116.4

131.537

25.106

24.292

24.701

40.164

2.5811
9.727
155.80

3.8754
6.268
100.41

7.6896
3.212
51.45

464.4128
0.086
1.39

0.17985
1.1521
0.4463
0.1540

0.16294
1.1751
0.3032
0.1342

0.17692
1.2242
0.1592
0.1013

0.19894
1.2861
0.0028
0.0588

4.515
11.21
15.31
99.41

3.958
7.37
15.19
113.21

4.370
3.93
14.26
140.74

7.990
0.11
10.09
171.59

42.47
680.35

45.02
721.18

49.44
791.94

44.55
713.67

0.221
1.028

0.149
0.712

0.074
0.368

0.007
0.047

Vcell
Init mass

10.732

1.513
37.26

0.000
38.518
4.095
4.027
0.893
1.469
0.556
0.544
0.666
0.000
0.000
0.000
0.000
0.000
8.021

0.000
26.127
2.853
2.968
0.677
1.125
0.443
0.433
0.560
0.000
0.000
0.000
0.000
0.000
7.695

0.000
12.907
1.492
1.709
0.418
0.708
0.299
0.299
0.436
0.000
0.000
0.000
0.000
0.000
7.341

0.000
0.947
0.064
0.100
0.022
0.062
0.058
0.070
0.184
0.000
0.000
0.000
0.000
0.000
4.596

60.036

43.743

26.051

6.157

0.023
0.180
0.000
4.803
0.763
1.125
0.312
0.526
0.233
0.225
0.353
0.000
0.000
0.000
0.000
0.000
6.860

0.017
0.125
0.000
3.067
0.542
0.996
0.275
0.484
0.234
0.227
0.364
0.000
0.000
0.000
0.000
0.000
7.088

0.006
0.058
0.000
1.011
0.268
0.577
0.185
0.332
0.169
0.177
0.325
0.000
0.000
0.000
0.000
0.000
7.023

0.006
0.043
0.000
0.780
0.044
0.077
0.017
0.053
0.054
0.067
0.180
0.000
0.000
0.000
0.000
0.000
4.557

15.404

13.421

10.131

5.880

#VALUE!

#VALUE!

#VALUE!

#VALUE!

Measured
liquid
composition
189.3

0.15
1.17
0.00
31.18
4.95
7.30
2.03
3.42
1.51
1.46
2.29
0.00
0.00

0.13
0.93
0.00
22.85
4.04
7.42
2.05
3.61
1.74
1.69
2.71
0.00
0.00

0.05
0.58
0.00
9.98
2.64
5.70
1.83
3.28
1.67
1.75
3.20
0.00
0.00

0.10
0.73
0.00
13.27
0.75
1.31
0.28
0.91
0.93
1.13
3.07
0.00
0.00

0.00
0.00
0.00
0.00
0.01
0.15
0.19
0.61
0.84
1.10
3.23
0.00
0.00

0.00
0.00
0.00
44.54

0.00
0.00
0.00
52.82

0.00
0.00
0.00
69.32

0.00
0.00
0.00
77.51

0.00
0.00
0.00
93.87

2.9239
1.6242
#DIV/0!
2.4227
1.5065
0.8899
0.6410
0.6185
0.4795
0.4905
0.3061
0.0584

3.4798
2.0753
#DIV/0!
3.3275
1.8870
0.8757
0.6451
0.5855
0.3956
0.4026
0.2386
0.0379

7.8811
3.3693
#DIV/0!
7.4884
2.9099
1.2485
0.7985
0.7205
0.4876
0.4353
0.2188
0.0289

3.2467
2.2057
#DIV/0!
4.5290
9.5262
6.1532
7.0379
3.5717
1.3107
1.0177
0.4133
0.1780

2514.7

1714.7

914.7

16.7

0.0795
0.3415
0.0000
13.5855
1.3424
1.1692
0.2338
0.3800
0.1302
0.1288
0.1261
0.0000
0.0000
0.0000
0.0000
0.0000
0.4676

0.0712
0.3155
0.0000
12.3914
1.2418
1.0593
0.2157
0.3443
0.1124
0.1110
0.1054
0.0000
0.0000
0.0000
0.0000
0.0000
0.3259

0.0757
0.3441
0.0000
13.2200
1.3607
1.2583
0.2587
0.4175
0.1442
0.1348
0.1240
0.0000
0.0000
0.0000
0.0000
0.0000
0.3538

0.0666
0.3207
0.0000
11.9599
1.4280
1.6096
0.3961
0.6452
0.2413
0.2290
0.2523
0.0000
0.0000
0.0000
0.0000
0.0000
2.7454

0.0009
0.0041
0.0000
0.1543
0.0184
0.0208
0.0051
0.0083
0.0031
0.0030
0.0033
0.0000
0.0000
0.0000
0.0000
0.0000
0.0354

0.0000
0.0000
0.0000
0.0001
0.0005
0.0091
0.0111
0.0359
0.0495
0.0648
0.1908
0.0000
0.0000
0.0000
0.0000
0.0000
5.5366

17.9846

16.2938

17.6918

19.8940

0.2567

5.8983

Residual gas Residual liquid

Moles of residual liquid


Gas molar vol
Liq molar vol
Total moles
Liq sat
Liq mole frac
Moles resid liq
Moles_resid_gas

464.4128
3.5571
0.0616
0.1497
0.9583
0.0590
0.0026

Você também pode gostar