Você está na página 1de 92

Airport Information For WSSS

Printed on 10 Apr 2014


Page 1
(c) JEPPESEN SANDERSON, INC., 2014, ALL RIGHTS RESERVED

Lighting:
Edge,
ALS, Centerline, REIL
General
Information
Displaced Threshold: 2428 ft
Stopway: 197 ft
Location: Singapore Sgp
IATA Code: SIN
Communication
Information
Lat/Long: N01 21.55' E103
59.36'
Elevation: 22 ft
ATIS 128.6
Singapore
Airport
Use:Tower
Public118.25
SingaporeVariation:
Magnetic
Tower 118.6
0.2E
Singapore Ground Control 124.3
Singapore Ground Control 121.725
Singapore
Fuel
Types:Ground
Jet A-1Control 121.85
Changi Types:
Repair
Ramp/Taxi
MajorControl
Airframe,
121.9
Major Engine
SingaporeYes
Customs:
Clearance Delivery 121.65
Singapore
Airport
Type:
Pre-Taxi
IFR Clearance 121.65
Singapore
Landing
Fee:
Approach
No
Control 124.6 Secondary
Singapore
Control
Tower:
Approach
Yes Control 120.3
Singapore
Jet
Start Unit:
Arrival
No Control 119.3
Singapore
LLWS
Alert:
Radar
Yes 124.05 Arrival Service
Beacon: Yes
Sunrise: 2302 Z
Sunset: 1110 Z,

Runway Information
Runway: 02C
Length x Width: 13123 ft x 197 ft
Surface Type: bitu
TDZ-Elev: 15 ft
Lighting: Edge, ALS, Centerline, REIL
Stopway: 197 ft
Runway: 02L
Length x Width: 13123 ft x 197 ft
Surface Type: bitu
TDZ-Elev: 22 ft
Lighting: Edge, ALS, Centerline, REIL, TDZ
Stopway: 197 ft
Runway: 20C
Length x Width: 13123 ft x 197 ft
Surface Type: bitu
TDZ-Elev: 15 ft
Lighting: Edge, ALS, Centerline, REIL, TDZ
Stopway: 197 ft
Runway: 20R
Length x Width: 13123 ft x 197 ft
Surface Type: bitu
TDZ-Elev: 14 ft

jep=JEPPESEN

JeppView for Windows

Airport Information For WSSS


Printed on 10 Apr 2014
Page 2
(c) JEPPESEN SANDERSON, INC., 2014, ALL RIGHTS RESERVED

Lighting:
Edge,
ALS, Centerline, REIL
General
Information
Displaced Threshold: 2428 ft
Stopway: 197 ft
Location: Singapore Sgp
IATA Code: SIN
Communication
Information
Lat/Long: N01 21.55' E103
59.36'
Elevation: 22 ft
ATIS 128.6
Airport Use:Tower
Singapore
Public118.25
Magnetic Variation:
Singapore
Tower 118.6
0.2E
Singapore Ground Control 124.3
Singapore Ground Control 121.725
Fuel Types:Ground
Singapore
Jet A-1Control 121.85
Repair Types:
Changi
Ramp/Taxi
MajorControl
Airframe,
121.9
Major Engine
Customs: Yes
Singapore
Clearance Delivery 121.65
Airport Type:
Singapore
Pre-Taxi
IFR Clearance 121.65
Landing Fee:
Singapore
Approach
No
Control 124.6 Secondary
Control Tower:
Singapore
Approach
Yes Control 120.3
Jet Start Unit:
Singapore
Arrival
No Control 119.3
LLWS Alert:
Singapore
Radar
Yes 124.05 Arrival Service
Beacon: Yes
Sunrise: 2302 Z
Sunset: 1110 Z,

Runway Information
Runway: 02C
Length x Width: 13123 ft x 197 ft
Surface Type: bitu
TDZ-Elev: 15 ft
Lighting: Edge, ALS, Centerline, REIL
Stopway: 197 ft
Runway: 02L
Length x Width: 13123 ft x 197 ft
Surface Type: bitu
TDZ-Elev: 22 ft
Lighting: Edge, ALS, Centerline, REIL, TDZ
Stopway: 197 ft
Runway: 20C
Length x Width: 13123 ft x 197 ft
Surface Type: bitu
TDZ-Elev: 15 ft
Lighting: Edge, ALS, Centerline, REIL, TDZ
Stopway: 197 ft
Runway: 20R
Length x Width: 13123 ft x 197 ft
Surface Type: bitu
TDZ-Elev: 14 ft

jep=JEPPESEN

JeppView for Windows

WSSS/SIN

JEPPESEN
16 MAR 12

CHANGI

10-1P

SINGAPORE, SINGAPORE

.AIRPORT.BRIEFING.

FLIGHT AND GROUND PROCEDURES


1. LOW VISIBILITY PROCEDURES (LVP) FOR CATEGORY II ILS OPERATIONS
1.1 INTRODUCTION
1.1.1 Category II ILS approaches will be made available at Singapore Changi
Airport to authorized flights during prolonged periods of low visibility,
except during thunderstorms.
1.2 AUTHORIZATION FOR CATEGORY II ILS APPROACHES
1.2.1 Operators who wish to conduct Category II ILS operations at Singapore
Changi Airport are required to submit the following documents to the
Airworthiness/Flight Operations Division of the Civil Aviation Authority
of Singapore at least one month before the commencement of the
operations:
a) Authorization for Category II ILS operations by the relevant authority of
the State of Registry/Operator of the operators:
b) Operators' minima for Category II ILS operations; and
c) Operators' method of verifying its pilots' Category II qualification and
currency.
1.3 CATEGORY II ILS RUNWAYS
1.3.1 At Singapore Changi Airport, Category II ILS approaches are available only
on RWY 02L and RWY 20C, which are also equipped with precision approach
Category II lighting system. When required, pilots making Category II ILS
approaches to Singapore Changi Airport should refer to the procedures in
the Instrument Approach Charts WSSS AD 2-101 to WSSS AD 2-119 and
the Precision Approach Terrain Charts for RWY 02L and RWY 20C at WSSS
AD 2-43 and WSSS AD 2-45 respectively.
1.4 INITIATION OF CATEGORY II ILS OPERATIONS
1.4.1 Preparations will be made to implement LVP for Category II ILS operations
at Singapore Changi Airport during prolonged period of low visibility,
except during thunderstorms, when the RVR drops below 2625' (800m).
1.4.2 Availability of the Category II ILS approaches will be made known through
NOTAM and ATIS broadcasts as well as air traffic control radio
communications.
1.4.3 During LVP operations, aircraft will not be cleared for Category II ILS
approach if any of the ILS or approach/runway lights fall below Category
II requirements. Aircraft will not be cleared for landing if the Touchdown
Zone RVR is unserviceable.

1.5 ILS SENSITIVE AREAS


1.5.1 Upon landing, pilots shall report to Changi Tower once the aircraft has
cleared the runway and has passed the ILS sensitive areas demarcated by
alternate yellow and green lights along the centerlines of Rapid Exit
Taxiways and Cross Taxiways.
1.6 TERMINATION OF LVP FOR CATEGORY II ILS OPERATIONS
1.6.1 LVP for Category II ILS operations will be terminated when RVR has
improved above 2625' (800m). Termination of LVP for Category II ILS
operations will be made known through NOTAM and ATIS broadcasts as
well as air traffic control radio communications.

2. RUNWAY UTILIZATION

2.1 RUNWAY-IN-USE
2.1.1 The runway-in-use (Departure/Arrival) is selected by Aerodrome Control
as the optimum for general purposes and to maximize runway utilization.
If the assigned runway is unsuitable for a particular operation, the pilot
can obtain permission from ATC to use another runway but should
anticipate delay.
2.2 DEPARTURES - WAKE VORTEX SEPARATION
2.2.1 To maximize runway utilization and minimize runway occupancy time,
departing aircraft when in receipt of line up clearance must inform ATC if
greater wake vortex separation will be required behind the proceeding
aircraft than that laid down in PANS ATM Doc 4444, else are required to
commence take-off roll as soon as take-off clearance is issued by ATC.
Failure to do so may result in additional delay.

CHANGES: Departures text revised.

| JEPPESEN, 2011, 2012. ALL RIGHTS RESERVED.

WSSS/SIN
CHANGI

JEPPESEN
16 MAR 12

10-1P1

SINGAPORE, SINGAPORE

.AIRPORT.BRIEFING.

2.3 CLEARANCE FOR IMMEDIATE TAKE-OFF


2.3.1 A pilot receiving the ATC instruction 'cleared for immediate take-off' is
required to act as follows:
(a) if waiting clear of the runway, taxi immediately on to it and begin
take-off run immediately without stopping the aircraft;
(b) if already lined-up on the runway, take-off without delay;
(c) if unable to comply with the instruction, inform ATC immediately.
2.4 ARRIVALS - MINIMUM RUNWAY OCCUPANCY TIME
2.4.1 Arriving aircraft upon landing are reminded that it is imperative to vacate
the runway as quickly as practicable to enable ATC to apply minimum
spacing on final approach and minimize the occurrence of "go-arounds".
2.4.2 To ensure minimum Runway Occupancy Time (ROT), each runway has
multiple Rapid Exit Taxiways (RETs). Pilots should vacate via the first
available RET corresponding to operational requirements, or as instructed
by ATC.
2.4.3 Aircraft vacating the runway-in-use should not stop on the exit taxiway
until the entire aircraft has passed the runway holding point.
2.4.4 Between 0830 - 1030 daily estimated delays of 15 minutes can be expected
for arrivals into Changi Airport.

2.5 LAND AFTER PROCEDURES


2.5.1 Normally, only one aircraft is permitted to land or take-off on the
runway-in-use at any one time. However, when the traffic sequence is two
successive landing aircraft, the second aircraft may be allowed to land
before the first aircraft has cleared the runway-in-use provided:
(a) the runway is long enough;
(b) during daylight hours;
(c) the second aircraft will be able to see the first aircraft clearly and
continuously until it is clear of the runway;
(d) the second aircraft has been warned.
2.5.2 ATC will provide this warning in the landing clearance as shown in para 2.7.
2.5.3 Responsibility for ensuring adequate separation between the two aircraft
rests with the pilot of the second aircraft.

2.6 SPECIAL LANDING PROCEDURES


2.6.1 Special landing procedures may be in force at Singapore Changi Airport in
conditions shown as follows:
(a) When the runway-in-use is temporarily occupied by other traffic,
landing clearance may be issued to an arriving aircraft provided that
at the time the aircraft crosses the threshold of the runway-in-use
the following separation distances will exist:
i) Landing following landing - The preceding landing aircraft will be
clear of the runway-in-use or will be at least 8202' (2500m) from
the threshold of the runway-in-use.
ii) Landing following departure - The departing aircraft will be
airborne and at least 8202' (2500m) from the threshold of the
runway-in-use, or if not airborne, will be at least 8202' (2500m)
from the threshold of the runway-in-use.
2.6.2 These procedures will be used only under the following conditions:
(a) during daylight hours;
(b) visibility of at least 5km;
(c) cloud ceiling of 1,500ft in the departure/missed approach area;
(d) ATC is satisfied that the pilot of the next arriving aircraft will
be able to observe continuously the relevant traffic;
(e) no unfavourable surface wind conditions (including significant
tailwind, windshear, turbulence, etc);
(f) when the runway is dry and free of all precipitants such that there is
no evidence that the braking action may be adversely affected.
2.7 PHRASEOLOGY
2.7.1 When issuing a landing clearance following the application of these
procedures, ATC will issue the second aircraft with the following
instructions:
...(call sign)...after the landing / departing...(Aircraft Type) Runway...
(Designator) cleared to land.
CHANGES: Arrivals text revised.

| JEPPESEN, 2011, 2012. ALL RIGHTS RESERVED.

WSSS/SIN
CHANGI

JEPPESEN
14 MAR 14

10-1P2

SINGAPORE, SINGAPORE

.AIRPORT.BRIEFING.

3. TOTAL RADIO FAILURE - SPECIAL PROCEDURES - SINGAPORE CHANGI AP ARRIVALS


3.1 In VMC during daylight hours, if total radio communication failure occurs to an
aircraft bound for Singapore Changi Airport, the pilot shall maintain VMC to
land at the most suitable airfield and report to the appropriate air traffic
control unit by the most expeditious means.
3.2 For IFR flights to Singapore Changi Airport, aircraft experiencing radio failure
shall:
3.2.1 Proceed according to the last acknowledged clearance received from
Singapore ATC, or
3.2.2 If no specific instructions or clearance has been received from
Singapore ATC:
a) Maintain the last assigned altitude or flight level and proceed via airways
thereafter the appropriate transition and STAR for Rwy 02L/02C to SAMKO
Holding Area (SHA) except for the following STARS: LAVAX 1A and
PASPU 1A shall proceed to SHA after SANAT.
b) Commence descent from SHA at or as close as possible to the ETA as
indicated on the flight plan.
c) Carry out the appropriate instrument approach procedure from SHA to
land on Rwy 02L/02C.

3.2.3 If unable to effect a landing on:


a) Rwy 02L
Carry out missed approach procedure to AKOMA (PU R-356/20DME).
Leave AKOMA at 4,000' to NYLON Holding Area (NHA) and execute the
appropriate instrument procedure from NHA to land on Rwy
20R or Rwy 20C, as appropriate.
b) Rwy 02C
Carry out missed approach procedure to NYLON Holding Area (NHA) and
execute the appropriate instrument procedure from NHA to land on Rwy
20R or Rwy 20C, as appropriate.
c) Rwy 20R
Carry out missed approach procedure to SAMKO Holding Area (SHA) and
execute the appropriate instrument procedure from SHA to land on Rwy
02L or Rwy 02C, as appropriate.
d) Rwy 20C
Carry out missed approach procedure to EXOMO (VTK R-158/22DME).
Leave EXOMO at 4,000' to SAMKO Holding Area (SHA) and execute the
appropriate instrument procedure from SHA to land on Rwy
02L or Rwy 02C, as appropriate.

4. IDENTIFICATION OF RUNWAY-IN-USE
4.1 ATC will switch on the appropriate approach lights and the ILS serving the
runway-in-use to assist the pilot in its identification. If the approach lights
for the runway-in-use are sighted but the ILS frequency is not received, the
pilot shall assume that the ILS is inoperative and shall proceed to land on the
runway on which the approach lights have been sighted.
4.2 If unable to land within 30 minutes of EAT or ETA, if no EAT has been received
and acknowledged, proceed to cross SAMKO Holding Area (SHA) at 4,000' then
via A457 at FL200 if Kuala Lumpur is the nominated alternate or via B470 at
FL 290 if Soekarno-Hatta is the nominated alternate or otherwise proceed at
the planned flight level to other nominated alternate.

5. TOTAL RADIO FAILURE - SPECIAL PROCEDURES - SINGAPORE CHANGI AP DEPARTURES


5.1 When an aircraft which has been cleared by ATC to an intermediate level
experiences total radio communication failure immediately after departure
from Singapore Changi Airport and it is deemed unsafe for it to continue to
its destination, the pilot will set the aircraft transponder to Mode A/C Code
7600 and adhere to the procedures below.

CHANGES: None.

| JEPPESEN, 2013, 2014. ALL RIGHTS RESERVED.

WSSS/SIN
CHANGI

JEPPESEN
14 MAR 14

10-1P3

SINGAPORE, SINGAPORE

.AIRPORT.BRIEFING.

5.2 When radio communication failure occurs immediately after the aircraft has
departed on Rwy 02L/02C, the pilot shall proceed according to the following
procedures:
a) Proceed straight ahead to NYLON Holding Area (NHA) climbing to the last
assigned altitude. At NHA, climb/descend to maintain 7,000'.
b) Hold at NHA for 4 minutes and leave NHA on track 203^. At 10 DME north
of VTK, turn left for HOSBA Holding Area (HHA) to jettison fuel,
maintaining 7,000'.
c) After fuel jettison, proceed to SAMKO Holding Area (SHA) via AWY G580
and SINJON DVOR. Maintain 7,000'. At SHA descend for an instrument
approach on Rwy 02L/02C. Identify the runway-in-use in accordance with
paragraph 4 on 10-1P2.
5.3 When radio communication failure occurs immediately after the aircraft has
departed on Rwy 20R/20C, the pilot shall proceed according to the following
procedures:
a) Proceed straight ahead to SAMKO Holding Area (SHA) climbing to the last
assigned altitude. At SHA climb/descend to maintain 7,000'.
b) Hold at SHA for 4 minutes. Leave SHA for HOSBA Holding Area (HHA) via
SJ DVOR and Airway G580 to jettison fuel, maintaining 7,000'.
c) After fuel jettison, proceed to NHA via Airway W401. Maintain 7,000'.
On crossing VTK 042R turn right to intercept VTK 023R. At NHA descend to
carry out an instrument approach on Rwy 20R/20C.
5.4 ATC action is based on the assumption that the aircraft will take a minimum
of 10 min to jettison fuel. An aircraft therefore should not leave earlier than
10 min after arrival at HOSBA Holding Area even if fuel jettison is completed
at a shorter time of if jettisoning is not necessary or possible unless
circumstances require an immediate return.
5.5 Alternatively, aircraft may jettison fuel between HOSBA and point 90 NM

from SJ DVOR/DME on airway G580.

6. RNAV (GNSS) SID/STAR OPERATIONS


6.1 For RNAV (GNSS) SIDs and STARs operations, the aircraft shall be
GNSS-equipped and the navigation systems shall meet ICAO RNP-1 standard of
accuracy, or equivalent, such as JAA TGL 10 or FAA AC 90-96A Apendix 2 Precision Area Navigation (P-RNAV).

CHANGES: Paragraph 6.

| JEPPESEN, 2013, 2014. ALL RIGHTS RESERVED.

WSSS/SIN

JEPPESEN

SINGAPORE, SINGAPORE

.RNAV.STAR.
CONTINUOUS DESCENT OPERATION (CDO) FOR ARRIVALS

CHANGI

15 FEB 13

10-2

1. Introduction
1.1 CDO is an aircraft operating technique which enables the pilot to execute an
optimized arrival descent profile utilizing the onboard capability of the aircraft. CDO
is facilitated by appropriate instrument flight procedure design and ATC procedures.

1.2 The vertical profile of CDO takes the form of a continuously descending path with
minimum level flight segments to enable smooth aircraft deceleration and configuration
prior to an ILS approach. New CDO RNAV STARs have been constructed in accordance
with ICAO Doc 9931 CDO Manual and ICAO Doc 8168 Procedures for Air Navigation,
Aircraft Operations, to facilitate CDO into Singapore Changi Airport.
2. Conditions for conducting a CDO
2.1 Pilots shall adhere to the instructions as depicted on the CDO RNAV STARs and the
conditions for ILS procedures into Changi. In addition, the following conditions must
be met:
a) Changi Runway 02L/20R is open for landing;
b) ILS for the intended runway of landing into Changi is in operation;
c) Visibility is greater than or equal to 800m;
d) RVR is greater than or equal to 550m for runway-in-use; and
e) No other system degradation that may affect a GNSS or ILS operation.
3. Requirements for individual flights
3.1 Flights that fulfill the following requirements can be allowed to conduct a CDO
subject to ATC and real-time traffic condition:
a) Flight enters Singapore FIR via one of the following waypoints and ATS routes:

ATETI (G-580)
BAVUS (L-504)
ESPOB (L-642)
IGARI (N-891)

IPRIX (M-753)
KADAR (M-774)
KAMIN (B-348)
MELAS (N-892)

PARDI (G-579)
SURGA (M-635)
TAROS (R-469)
TEGID (M-767)

VPK (B-469)

b) RNAV-equipped aircraft with FMC capable of:


-LNAV and VNAV;
-flying Changi RNAV STARs and to abide by all speed and altitude restrictions
depicted on the charts;
-continuing on planned vertical path from RNAV STAR onto ILS of intended
runway of landing.
4. Preparations for CDO
4.1 To ensure that the CDO procedures can be effectively carried out, pilots are
advised to abide by the following:
a) Check if conditions for conducting the CDO are met;
b) Check if flight meets requirement for executing a CDO; and
c) Plan the lateral route in your FMC as shown below based on FIR entry point
and landing runway-in-use. The landing runway-in-use is available from D-ATIS.
FIR entry point RWY
02L
ESPOB, IPRIX,
IGARI
20R
02L
MELAS
20R
02L
VPK
20R
02L
TEGID, KAMIN,
AGOBA
20R
02L
KADAR, BAVUS
20R
02L
SURGA
20R
02L
PARDI
20R
02L
TAROS
20R

STAR
PASPU 1K
PASPU 1L
PASPU 1K
PASPU 1L
PASPU 1K
PASPU 1L
LAVAX 1K
LAVAX 1L
LAVAX 1K
LAVAX 1L
LAVAX 1K
LAVAX 1L
REMES 1K
REMES 1L
BOBAG 1K
BOBAG 1L

Transition

VEPLI
MABAL
BIKTA
TOMAN
OBDOS
SURGA

5. CDO Execution
5.1 On first contact with Singapore RADAR, use the following when requesting for a CDO:
"Request C-D-O "
-Depending on the situation, Singapore ATC will make an early assessment to approve/
disapprove your request accordingly. When it is obvious to ATC that the conduct of
CDO flight will not reap any operational benefit, ATC shall disapprove your request
and inform you accordingly.
CHANGES: Text.

| JEPPESEN, 2011, 2013. ALL RIGHTS RESERVED.

WSSS/SIN

JEPPESEN

SINGAPORE, SINGAPORE

.RNAV.STAR.
CONTINUOUS DESCENT OPERATION (CDO) FOR ARRIVALS

CHANGI

15 FEB 13

10-2A

5.2 If CDO is approved, Singapore ATC shall reply using the following phraseology:
"[flight callsign], EXPECT C-D-O and cleared to Singapore via [STAR] Arrival,
[transition, if any] transition, Runway [runway-in-use].
MAINTAIN [cruising altitude],
report ready for descent"
On receipt of this clearance from Singapore ATC, pilot shall plan the arrival route
using the FMC and to report estimated time/distance for Top Of Descent (TOD) once
the information is available. CDO RNAV STARs have been designed for arrivals into
Runway 02L or Runway 20R and linking up to the ILS of these respective runways. As
such, please refrain from requesting for a change in landing runway (i.e. 02C or 20C).
5.3 Prior to reaching TOD, pilot shall make another call to request CDO execution:
"Request descent"
Once cleared for descent:
a) Start descent at the calculated FMC TOD based on the planned lateral and vertical
path;
b) Use lateral and vertical navigation functions of the FMC throughout CDO execution.
5.4 When transferred to another ATC sector/frequency, always inform the next sector
that flight is on CDO upon initial contact:
"Singapore [ATC sector transferred to], [flight callsign],
on C-D-O
to [last cleared altitude by ATC], Runway [runway-in-use]"
5.5 Once in contact with Singapore Arrival, ATC shall issue onward clearance to facilitate
final phase of the CDO flight. Clearance would be in the following form:
"[flight callsign], descend to [altitude], cleared ILS approach
Runway [runway-in-use]"
-With this clearance, pilot may proceed on remaining route of CDO flight procedure to
intercept on the appropriate ILS.
NOTE:
-During CDO, standard ATC procedures continue to apply. ATC may at times clear
you to an intermediate level which would still facilitate a CDO profile. In doing so,
ATC shall endeavor to issue further descent clearance prior to the CDO flight
reaching 3000' from last assigned altitude so as to prevent leveling off.
-If CDO flight has commenced and in the course of the CDO execution, Changi changes
direction of its runway-in-use, i.e. Rwy 02 to Rwy 20 or vice versa, ATC shall advise
if the CDO flight can resume and issue the necessary re-clearance. Pilot shall then
re-plan arrival route to the revised landing runway and advise ATC if the flight would
still be able to meet all the required speed/altitude restrictions.
5.6 Deviation from lateral or vertical path - At times, it may be necessary for ATC to take
you off track temporarily or stop descent at an intermediate level due to a change in
traffic situation. When instructed, pilot shall comply with ATC instructions until such
a time when informed that the CDO flight can resume.
5.7 Termination of a CDO - In the event that traffic complexity reaches a stage where
cancellation of the CDO flight becomes necessary, ATC shall issue a clearance to
terminate the CDO flight. In doing so, ATC shall use the following phrase to terminate
the CDO flight:
"[callsign], [reason for CDO termination], C-D-O is now terminated.
[other ATC instructions that may follow]..."
5.8 Radio Communication Failure - In the event of a radio communication failure, CDO
flight is to be terminated immediately and pilot is to apply the radio communication
failure procedures.
6. CDO Flight procedures
6.1 The CDO flight shall track along the CDO RNAV STARs up to the intermediate segment
and ILS procedure for the final and missed approaches for the respective runways. The
CDO RNAV STARs have been designed as closed approaches into Changi, special
provisions have been made herein to facilitate CDO flight joining the ILS Approach
from the RNAV STAR.

6.2 In the event that airborne RNAV equipment fails, pilot shall inform ATC as soon as
practicable. ATC shall then terminate CDO operation and resume with RADAR vectors
to aid pilot in landing into Changi.
6.3 For each set of RNAV STAR, information on distance to threshold has been added to
aid pilot in CDO planning and execution and to reduce radio voice transmissions
between pilot and ATC.
CHANGES: Radio communication failure text.

| JEPPESEN, 2011, 2013. ALL RIGHTS RESERVED.

^
141

CHANGES: Airport elevation, lost comms.

MAX

^
147

.R.42069.

D4

6000' - FL180
MAX 220 KT

083^

263^

4000' - FL140
MAX 220 KT

168^

6000'

348^

At or above

N01 04.4
E103 43.9

BOKIP

(VTK R-221/D27.0)

083

^ ^
235 243

6
8.
D3 24.0
D
^ 14

10000'

At or above

220 KT

1 ROUTING

From REKOP track 141^ to BOBAG.

From ARAMA track 147^ to BOBAG.

1 TRANSITIONS

Direct distance from SAMKO to:


Changi Apt 17 NM

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

BOBAG ONE ALPHA


(BOBAG1A) ARRIVAL
[BOBA1A]

At BOBAG track 083^ to BOKIP then to SAMKO. From SAMKO,


EXPECT RADAR vectors for ILS approach Rwy 02.

ARAMA
(A-464)
REKOP
(A-576)

4000'

At or above

MAX

N01 05.5
E103 52.9

(SJ R-168/D8.0)
(VTK R-204/D21.1)

SAMKO

EXPECT RADAR
vectors for ILS
approach Rwy 02

VTK

TEKONG

116.5 VTK
(RWYS 02L/C)

250 KT

N00 59.8
E103 09.9

P
KO9
E
R 3

^ 52^
2443.62

41 MA

220 KT

N01 13.4 E103 51.3

SJ

SINJON

113.5 SJ

N01 24.9 E104 01.3

LOST COMMS

MSA SJ VOR

10-2B

3
57.

A
AR

MAX

N01 02.5
E103 29.9

BOBAG

LOST COMMS

2100'

JEPPESEN

ASUNA

250 KT

LOST COMMS

LOST COMMS

MAX

NOT TO SCALE

LOST COMMS

LOST COMMS

LOST COMMS

MSA VTK VOR

2500'

22'

N01 33.1
E103 05.4

250 KT

3400'

090^

128.6

(SJ R-293/D50.0)
(VTK R-278/D56.6)

MAX

2100'

1900'

Apt Elev

4.

N01 36.9 E103 07.2

3400'

090^

D-ATIS

REKOP

.A.576

.A.46

(SJ R-298/D50.0)
(VTK R-282/D55.5)

ARAMA

1. Set transponder to Mode A/C code 7600.


2. When cleared via BOBAG 1A by Singapore ATC:
a. MAINTAIN last assigned flight level or altitude
and proceed on BOBAG 1A to SAMKO.
b. From SAMKO commence descent and carry out
appropriate landing procedure for Rwy 02 as
close as possible to EAT or ETA.
c. If unable to effect a landing, refer to Singapore
Special Procedures for missed approach procedure.
3. No clearance or instruction received from
Singapore ATC:
Refer to 10-1P pages for radio communications
failure procedure.

180^
360^

180^
360^

LOST
LOST COMMS
LOST COMMS

LOST COMMS

22 NOV 13

CHANGI

22 11.6
0^

WSSS/SIN
.RNAV.STAR.

SINGAPORE, SINGAPORE

Alt Set: hPa Trans level: FL130 Trans alt: 11000'


1. RADAR required.
2. Non-RNP-1/P-RNAV approved aircraft shall fly this as a basic RNAV
(B-RNAV) procedure 1 or EXPECT RADAR vectors from ATC.

| JEPPESEN, 2006, 2013. ALL RIGHTS RESERVED.

REKOP

6.

4.

MAX

CHANGES: Airport elevation, lost comms.

MAX

N01 05.5
E103 52.9

or as directed by ATC

7000'
MAX 220 KT

At or above

3400'
2500'

090^

2100'

MSA SJ VOR

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

(SJ R-107/D17.5)
(VTK R-158/D17.9)

1900'

MSA VTK VOR

1 TRANSITIONS
ARAMA (A-464) From ARAMA track 147^ to BOBAG.
REKOP (A-576) From REKOP track 141^ to BOBAG.
1 ROUTING
At BOBAG track 083^ to BOKIP then to SAMKO. Turn LEFT, track 080^ to
BTM, then turn LEFT and track 023^ to DOVAN. Then turn LEFT, track 348^ to
BIPOP. From BIPOP, EXPECT RADAR vectors for ILS approach Rwy 20.

0
D 8.

Direct distance from BIPOP to:


Changi Apt 15 NM

263^

N01 04.4
E103 43.9

(VTK R-221/D27.0)

SAMKO

15

BTM

BATAM

*116.0 BTM

4000'

At or above

N01 19.6
E104 12.8

DOVAN

3000'

N01 08.2 E104 08.0

220 KT

At or above

MAX

2100'

BOBAG ONE BRAVO


(BOBAG1B) ARRIVAL

6000' - FL180
MAX 220 KT

.R.4260 9.

168^

083^

D43

080^

D1
2.7

.5
D22

7^
04

2
6.

D2

N01 31.4
E104 10.3

BIPOP

3400'

090^

(RWYS 20C/R)

074^

115

D1

^
0551.0

EXPECT RADAR
vectors for ILS
approach Rwy 20

3000' - FL140
MAX 220 KT

[BOBA1B]

250 KT

N00 59.8
E103 09.9

41 MA

^ 52^
244 .62

P
KO9
E
R 3

3
57.

A
AR

6
8.
D3 24.0
D
3
08 ^ 14 BOKIP

10000'

^ ^
235 243

220 KT

SJ

113.5 SJ

SINJON

N01 13.4 E103 51.3

116.5 VTK
VTK

TEKONG

LOST COMMS

N01 24.9 E104 01.3

LOST COMMS

LOST COMMS

At or above

MAX

N01 02.5
E103 29.9

LOST COMMS

BOBAG

LOST COMMS

N01 37.0
E104 06.4

NYLON

(VTK R-023/D13.0)

10-2C

ASUNA

LOST COMMS

1. Set transponder to Mode A/C code 7600.


2. When cleared via BOBAG 1B by Singapore ATC:
a. MAINTAIN last assigned flight level or altitude
and proceed on BOBAG 1B to BIPOP, then direct
to NYLON.
b. From NYLON commence descent and carry out
appropriate landing procedure for Rwy 20 as
close as possible to EAT or ETA.
c. If unable to effect a landing, refer to Singapore
Special Procedures for missed approach procedure.
3. No clearance or instruction received from
Singapore ATC:
Refer to 10-1P pages for radio communications
failure procedure.

348^

NOT TO SCALE

250 KT

^
141

MAX

N01 33.1
E103 05.4

250 KT

^
147

(SJ R-293/D50.0)
(VTK R-278/D56.6)

.A.57

.A.46

LOST COMMS

LOST COMMS

LOST COMMS

N01 36.9
E103 07.2

ARAMA

LOST COMMS

D1
1.
6

12

22
0^

22'

204
^

.0
D3
0

203^
023^

180^
360^
180^

(SJ R-298/D50.0)
(VTK R-282/D55.5)

JEPPESEN

D2 1
.1

Apt Elev

128.6

033
^

D-ATIS

360^

LOST COMMS

22 NOV 13

12

CHANGI

023^

WSSS/SIN
.RNAV.STAR.

SINGAPORE, SINGAPORE

Alt Set: hPa Trans level: FL130 Trans alt: 11000'


1. RADAR required. 2. Non-RNP-1/P-RNAV approved aircraft shall fly this
as a basic RNAV (B-RNAV) procedure 1 or EXPECT RADAR vectors from
ATC. 3. All SOUTHBOUND flights from the WEST landing at Singapore
Changi Apt are to request for the STAR only from Singapore ATC on 133.25
or 135.8 when Rwy 20 is in use and within SJ 120 DME. Flight shall remain
under the control of WMKK ATC.

| JEPPESEN, 2006, 2013. ALL RIGHTS RESERVED.

CHANGES: Lost comms.

083^

20

NOT TO SCALE

14

6000'

At or above

SADET

023^

220 KT
4000'

At or above

MAX

N01 05.5 E103 52.9

SAMKO

N01 10.1
E103 54.2

BOBAG ONE KILO (BOBAG1K) ARRIVAL


[BOBA1K]

(RWY 02L)

ROUTING
From ASUNA to BOBAG, to BOKIP, to SAMKO, to SADET,
to ADNIK.

BOKIP

N01 04.4
E103 43.9

ADNIK

N01 16.9
E103 56.9

10-2D

N00 59.8
E103 09.9

10000'

SJ

SINJON

113.5 SJ

N01 13.4 E103 51.3

JEPPESEN

ASUNA

250 KT

At or above

MAX

N01 02.5
E103 29.9

BOBAG

LOST COMMS

WAYPOINT TO
THRESHOLD DISTANCE
ADNIK - 4.5 NM
ASUNA - 59.4 NM
BOBAG - 39.4 NM
BOKIP - 25.4 NM
SADET - 11.7 NM
SAMKO - 16.4 NM

LOST COMMS

LOST COMMS

LOST COMMS

22'

LOST COMMS

2100'

MSA SJ VOR

2500'

090^

3400'

Apt Elev

LOST COMMS

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

D-ATIS

128.6

LOST COMMS

1. Set transponder to Mode A/C code 7600.


2. When cleared via BOBAG 1K by Singapore ATC:
a. MAINTAIN last assigned flight level or altitude
and proceed on BOBAG 1K to ADNIK.
b. From ADNIK commence descent and carry out
appropriate landing procedure for Rwy 02L as
close as possible to EAT or ETA.
c. If unable to effect a landing, refer to Singapore
Special Procedures for missed approach procedure.
3. No clearance or instruction received from
Singapore ATC:
Refer to 10-1P pages for radio communications
failure procedure.
180^
360^

LOST

LOST COMMS

LOST COMMS

LOST COMMS

22 NOV 13

015^

CHANGI

WSSS/SIN
.RNAV.STAR.

SINGAPORE, SINGAPORE

Alt Set: hPa Trans level: FL130 Trans alt: 11000'


1. RNAV 1.
2. RADAR required.
3. RNAV (GNSS) CDO.
4. Changi arrivals via ATS route A-464 shall flight plan BOBAG 1A or
BOBAG 1B as STAR route. When traffic permits, BOBAG 1K, BOBAG 1L
or LELIB 2B STAR will be issued to pilots.

| JEPPESEN, 2011, 2013. ALL RIGHTS RESERVED.

CHANGES: Lost comms.

LOST COMMS

LOST COMMS

N00 59.8
E103 09.9

083^

20

7000'

MAX 250 KT
At or above

MSA VTK VOR

360^

(RWY 20R)

ROUTING
From ASUNA to BOBAG, to BOKIP, to SAMKO, to BTM, to DOVAN,
to BIPOP, to BIPAL, to IDURO.

N01 05.5
E103 52.9

SAMKO

BTM

BATAM

*116.0 BTM

4000'

At or above

N01 19.6
E104 12.8

DOVAN

3000'

180^

[BOBA1L]

NOT TO SCALE

N01 04.4
E103 43.9

BOKIP

LOST

N01 08.2 E104 08.0

348^

14

15

12

080^

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

220 KT

At or above

MAX

N01 31.4
E104 10.3

BIPOP

2100'

1900'

10-2E

10000'

116.5 VTK
VTK

N01 24.9 E104 01.3

TEKONG

28
5^

090^

3400'

22 NOV 13

At or above

N01 02.5
E103 29.9

LOST COMMS

BOBAG

LOST COMMS

N01 26.7
E104 01.1

IDURO

BIPAL

JEPPESEN

ASUNA

LOST COMMS

WAYPOINT TO
THRESHOLD DISTANCE
ASUNA - 100.2 NM
BIPAL - 11.5 NM
BIPOP - 18.2 NM
BOBAG - 80.2 NM
BOKIP - 66.2 NM
BTM - 42.2 NM
DOVAN - 30.2 NM
IDURO - 4.5 NM
SAMKO - 57.2 NM

LOST COMMS

LOST COMMS

COMMS

N01 33.1
E104 03.9

203^

LOST COMMS

128.6

023^

D-ATIS

LOST COMMS

1. Set transponder to Mode A/C code 7600.


2. When cleared via BOBAG 1L by Singapore ATC:
a. MAINTAIN last assigned flight level or altitude
and proceed on BOBAG 1L to IDURO.
b. From IDURO commence descent and carry out
appropriate landing procedure for Rwy 20R as
close as possible to EAT or ETA.
c. If unable to effect a landing, refer to Singapore
Special Procedures for missed approach procedure.
3. No clearance or instruction received from
Singapore ATC:
Refer to 10-1P pages for radio communications
failure procedure.

CHANGI

12

WSSS/SIN
.RNAV.STAR.

SINGAPORE, SINGAPORE

Alt Set: hPa Trans level: FL130 Trans alt: 11000'


1. RNAV (GNSS) CDO.
Apt Elev 2. RNAV 1.
3. RADAR required.
22'
4. Changi arrivals via ATS route A-464 shall flight plan BOBAG 1A or
BOBAG 1B as STAR route. When traffic permits, BOBAG 1K, BOBAG 1L
or LELIB 2B STAR will be issued to pilots.

BOBAG ONE LIMA (BOBAG1L) ARRIVAL

| JEPPESEN, 2011, 2013. ALL RIGHTS RESERVED.

CHANGES: Airport elevation, lost comms.

SJ

SINJON

113.5 SJ

168.^0

D8

N01 05.5
E103 52.9

(VTK R-204/D21.1)

168^

348^
250 KT

IKAGO

291^

SURGA

S00 37.0 E106 31.3

OBDOS
(SJ R-105/D191)
(VTK R-109/D185)

27 9^

.M.6
35.

N00 25.1 E106 55.9

87

OBDOS

FL260 - FL310
MAX 280 KT

269^

(SJ R-124/D194)
(VTK R-129/D193)

N00 38.3 E105 29.5

(SJ R-110/D104)
(VTK R-118/D99.8)

N00 43.2 E104 55.0

27 9^
35

A
RG
SU 97

FL180

IKIMA

(SJ R-115/D70.5)
(VTK R-128/D67.9)

20

089^

NOT TO SCALE

N01 11.4 E105 33.7

0^
32

At or below

At

N00 50.6
E104 36.0

(SJ R-117/D50.2)
(VTK R-135/D48.7)

IBULA

21

Direct distance from SANAT to:


Changi Apt 14 NM

4000'

7000'

or as directed
by ATC

1^

269^
FL150 - FL250
MAX 250 KT
111^
29

46

FL160

(SJ R-091/D103)
(VTK R-098/D93.5)

KARTO

3400'
2500'

090^

2100'

MSA SJ VOR

.M.L.7.5704.
4.

[LAVA1A]
(RWYS 02L/C)

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

220 KT

^
335

At or above

MAX

At or above

N01 08.8
E104 13.0

089^

21

250 KT

At or below

At

MSA VTK VOR

LAVAX ONE ALPHA


(LAVAX1A) ARRIVAL

4000' - FL140
MAX 220 KT

N01 07.8
E103 59.5

266^

D3
0 .0
D36.2

220 KT

N01 21.8 E105 47.3

(SJ R-086/D117)
(VTK R-092/D106)

LOST COMMS

1900'

10-2F

(SJ R-102/D22.2)
(VTK R-144/D19.8)

IGNON

At

N01 10.3
E104 48.3

LOST COMMS

TOMAN

LOST COMMS

2100'

JEPPESEN

(SJ R-124/D9.9)
(VTK R-186/D17.1)

SANAT

14

14

096^

120

N01 09.8
E104 27.2

LAVAX

(SJ R-093/D57.2)
(VTK R-107/D49.2)

KEXAS

LOST COMMS

LOST COMMS

EXPECT RADAR
vectors for ILS
approach Rwy 02

2
7000' - FL140
MAX 220 KT

LOST COMMS

3400'

090^

22 NOV 13

SAMKO

N01 13.4 E103 51.3

116.5 VTK
VTK

N01 24.9 E104 01.3

TEKONG

1. Set transponder to Mode A/C code 7600.


2. When cleared via LAVAX 1A by Singapore ATC:
a. MAINTAIN last assigned flight level or altitude
and proceed on LAVAX 1A to SANAT, then direct
to SAMKO.
b. From SAMKO commence descent and carry out
appropriate landing procedure for Rwy 02 as
close as possible to EAT or ETA.
c. If unable to effect a landing, refer to Singapore
Special Procedures for missed approach procedure.
3. No clearance or instruction received from
Singapore ATC:
Refer to 10-1P pages for radio communications
failure procedure.
LOST COMMS

OBDOS
279^ from OBDOS to IKAGO, then track 279^ to IKIMA,
(L-504/ Track
then
track
291^ to IBULA, then track 335^ to LAVAX.
M-774)
SURGA Track 320^ from SURGA to IKAGO, then track 279^ to IKIMA,
(M-635) then track 291^ to IBULA. Then track 335^ to LAVAX.
233^ from TOMAN to KARTO, turn RIGHT track 269^ to
TOMAN Track
KEXAS, then to LAVAX.
1 ROUTING
At LAVAX track 266^ to IGNON and then to SANAT. From SANAT,
EXPECT RADAR vectors for ILS approach Rwy 02.

LOST COMMS
LOST COMMS

180^
360^

LOST COMMS

180^

1 TRANSITIONS

22'

LOST COMMS

128.6

17

Apt Elev

360^

D-ATIS

233
^

CHANGI

TO
MA
N

WSSS/SIN
.RNAV.STAR.

SINGAPORE, SINGAPORE

Alt Set: hPa Trans level: FL130 Trans alt: 11000'


1. RADAR required.
2. Non-RNP-1/P-RNAV approved aircraft shall fly this as a basic RNAV
(B-RNAV) procedure 1 or EXPECT RADAR vectors from ATC.

| JEPPESEN, 2006, 2013. ALL RIGHTS RESERVED.

SINJON

LOST COMMS

(SJ R-047/D26.2)

BIPOP

LOST COMMS

220 KT

LOST COMMS

096^

D28.6

087^

LAVAX

3
089^

220 KT

IBULA

LOST COMMS

250 KT

1^

46

FL160

IKIMA

20

LOST COMMS

N00 43.2 E104 55.0

N01 21.8 E105 47.3

089^

A
RG7
U
S 9

SURGA

S00 37.0 E106 31.3

2500'

2100'

OBDOS

27 9^

MSA SJ VOR

(SJ R-105/D191)
(VTK R-109/D185)

.M.6
35.

3400'

090^
MSA VTK VOR

2100'

1900'

N00 25.1 E106 55.9

87

OBDOS

FL260 - FL310
MAX 280 KT

269^

3400'

090^

N01 11.4 E105 33.7

(SJ R-091/D103)
(VTK R-098/D93.5)

KARTO

0^
32
(SJ R-124/D194)
(VTK R-129/D193)

N00 38.3 E105 29.5

(SJ R-110/D104)
(VTK R-118/D99.8)

IKAGO

291^

35

27 9^

269^
FL150 - FL250
MAX 250 KT
111^
29

(SJ R-115/D70.5)
(VTK R-128/D67.9)

FL180

21

250 KT

At or below

At

N01 10.3
E104 48.3

(SJ R-093/D57.2)
(VTK R-107/D49.2)

KEXAS

TOMAN

(SJ R-086/D117)
(VTK R-092/D106)

.M..L7.5704.
4.

[LAVA1B]
(RWYS 20C/R)

At or below

At

N00 50.6
E104 36.0

(SJ R-117/D50.2)
(VTK R-135/D48.7)

9 04^
D36.2

At

N01 09.8
E104 27.2

1 TRANSITIONS
OBDOS
279^ from OBDOS to IKAGO, then track 279^ to IKIMA,
(L-504/ Track
then
track
291^ to IBULA, then track 335^ to LAVAX.
M-774)
SURGA Track 320^ from SURGA to IKAGO, then track 279^ to IKIMA,
(M-635) then track 291^ to IBULA. Then track 335^ to LAVAX.
233^ from TOMAN to KARTO, turn RIGHT track 269^ to
TOMAN Track
KEXAS, then to LAVAX.
1 ROUTING
At LAVAX track 304^ to RUTOT and then to DOVAN. Then track 348^ to
BIPOP. From BIPOP, EXPECT RADAR vectors for ILS approach Rwy 20.

2
7000' - FL140
MAX 220 KT

or as directed
by ATC
(VTK R-120/D30.0)

8000'

At or above

N01 14.9
E104 19.8

(VTK R-118/D21.0)

RUTOT

3000'

At or above

MAX

N01 31.4
E104 10.3
NOT TO SCALE

3000' - FL140
MAX 220 KT

^
335

21

1. Set transponder to Mode A/C code 7600.


2. When cleared via LAVAX 1B by Singapore ATC:
a. MAINTAIN last assigned flight level or altitude
and proceed on LAVAX 1B to BIPOP, then direct
to NYLON.
b. From NYLON commence descent and carry out
appropriate landing procedure for Rwy 20 as
close as possible to EAT or ETA.
c. If unable to effect a landing, refer to Singapore
Special Procedures for missed approach procedure.
3. No clearance or instruction received from
Singapore ATC:
Refer to 10-1P pages for radio communications
failure procedure.

LOST COMMS

4000'

At or above

N01 19.6 E104 12.8

(VTK R-115/D12.7)

Direct distance from BIPOP to:


Changi Apt 15 NM

LOST COMMS

D2

0742^.5

DOVAN

^
05511.0

12

N01 13.4 E103 51.3

N01 24.9 E104 01.3

116.5 VTK

TEKONG

VTK
113.5 SJ
SJ

N01 37.0
E104 06.4

(VTK R-023/D13.0)

EXPECT RADAR
vectors for ILS
approach Rwy 20

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

NYLON

D3
0

033 .0
^

203^

023^

348^

LOST COMMS

17

CHANGES: Airport elevation, lost comms.

233
^

22'

10-2G

LOST COMMS

JEPPESEN

LOST COMMS

22 NOV 13

T
O
MA
N

128.6

180^

Apt Elev

180^

D-ATIS

360^

CHANGI

360^

WSSS/SIN
.RNAV.STAR.

SINGAPORE, SINGAPORE

Alt Set: hPa Trans level: FL130 Trans alt: 11000'


1. RADAR required.
2. Non-RNP-1/P-RNAV approved aircraft shall fly this as a basic RNAV
(B-RNAV) procedure 1 or EXPECT RADAR vectors from ATC.

LAVAX ONE BRAVO


(LAVAX1B) ARRIVAL

LOST COMMS

| JEPPESEN, 2006, 2013. ALL RIGHTS RESERVED.

CHANGES: Lost comms.

SJ

SINJON

113.5 SJ

SADET

WAYPOINT TO THRESHOLD DISTANCE


KEXAS - 68.2 NM
ADNIK - 4.5 NM
OBDOS - 208.5 NM
IBULA - 68.2 NM
LAVAX - 47.2 NM
IGNON - 31.5 NM
IKAGO - 121.5 NM
SADET - 11.7 NM
SANAT - 17.6 NM
IKIMA - 88.2 NM
SURGA - 218.5 NM
KARTO - 114.2 NM
TOMAN - 131.2 NM

4000'

NOT TO SCALE

21
IBULA

N00 50.6
E104 36.0

^
335

220 KT

21

20

N00 43.2
E104 55.0

IKIMA

291^

N01 10.3
E104 48.3

KEXAS

46

35

N00 38.3
E105 29.5

IKAGO

279^

87

320

OBDOS

G
97 A

SU
R

N01 11.4
E105 33.7

KARTO

269^

S00 37.0
E106 31.3

LAVAX ONE KILO (LAVAX1K) ARRIVAL


SURGA

279^

N00 25.1
E106 55.9

OBDOS

N01 21.8
E105 47.3

TOMAN

[LAVA1K]

At or above

14

266^

FL140

LOST COMMS

(RWY 02L)

MAX

14

250 KT

At or below

MAX

LOST COMMS

180^
360^
MSA SJ VOR

2500'

2100'

10-2H

N01 07.8
E103 59.5

293
^

N01 09.8
E104 27.2

LAVAX

LOST COMMS

3400'

JEPPESEN

SANAT

7000'

At or above

N01 08.8
E104 13.0

IGNON

LOST COMMS
LOST COMMS

090^

Alt Set: hPa Trans level: FL130


1. RNAV 1.
2. RADAR required.
3. RNAV (GNSS) CDO.

N01 10.1
E103 54.2

N01 16.9
E103 56.9

ADNIK

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

LOST COMMS

LOST

N01 13.4 E103 51.3

LOST COMMS

1. Set transponder to Mode A/C code 7600.


2. When cleared via LAVAX 1K by Singapore ATC:
a. MAINTAIN last assigned flight level or altitude
and proceed on LAVAX 1K to ADNIK.
b. From ADNIK commence descent and carry out
appropriate landing procedure for Rwy 02L as
close as possible to EAT or ETA.
c. If unable to effect a landing, refer to Singapore
Special Procedures for missed approach procedure.
3. No clearance or instruction received from
Singapore ATC:
Refer to 10-1P pages for radio communications
failure procedure.
LOST COMMS

TRANSITIONS
OBDOS From OBDOS to IKAGO, to IKIMA, to IBULA, to LAVAX.
SURGA From SURGA to IKAGO, to IKIMA, to IBULA, to LAVAX.
TOMAN From TOMAN to KARTO, to KEXAS, to LAVAX.
ROUTING
From LAVAX to IGNON, to SANAT, to SADET, to ADNIK.

22'

128.6

COMMS

Apt Elev

233
^

D-ATIS

TO
M

LOST COMMS

22 NOV 13

023^

CHANGI

17 AN

WSSS/SIN
.RNAV.STAR.

SINGAPORE, SINGAPORE

Trans alt: 11000'

| JEPPESEN, 2011, 2013. ALL RIGHTS RESERVED.

VTK

TEKONG

CHANGES: Lost comms.

250 KT

21

FL140

348^

12

21

^
335
IKIMA

291^
N00 43.2
E104 55.0

NOT TO SCALE

20

35

N00 38.3
E105 29.5

IKAGO

279^

87

S00 37.0
E106 31.3

[LAVA1L]
SURGA

279^

OBDOS

N00 25.1
E106 55.9

N01 21.8
E105 47.3

TOMAN

320

OBDOS

G
97 A

SU
R

N01 11.4
E105 33.7

KARTO

269^

LOST COMMS

(RWY 20R)

IBULA

46

LOST COMMS

10-2J

N00 50.6
E104 36.0

N01 10.3
E104 48.3

KEXAS

At or below

MAX

LOST COMMS

JEPPESEN

TRANSITIONS
OBDOS From OBDOS to IKAGO, to IKIMA, to IBULA, to LAVAX.
SURGA From SURGA to IKAGO, to IKIMA, to IBULA, to LAVAX.
TOMAN From TOMAN to KARTO, to KEXAS, to LAVAX.
ROUTING
From LAVAX to RUTOT, to DOVAN, to BIPOP, to BIPAL, to IDURO.

304
^

8000'

N01 09.8
E104 27.2

LAVAX

LOST COMMS

180^
360^
MSA VTK VOR

Alt Set: hPa Trans level: FL130


1. RNAV 1.
2. RADAR required.
3. RNAV (GNSS) CDO.

WAYPOINT TO THRESHOLD DISTANCE


BIPAL - 11.5 NM
KARTO - 114.2 NM
BIPOP - 18.2 NM
KEXAS - 68.2 NM
LAVAX - 47.2 NM
DOVAN - 30.2 NM
OBDOS - 210.2 NM
IBULA - 68.2 NM
RUTOT - 38.2 NM
IDURO - 4.5 NM
SURGA - 220.2 NM
IKAGO - 123.2 NM
IKIMA - 88.2 NM
TOMAN - 131.2 NM

4000'

At or above

LOST
LOST COMMS
LOST COMMS

LOST COMMS

At or above

N01 14.9
E104 19.8

RUTOT

3000'

2100'

1900'

22 NOV 13

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

DOVAN

N01 19.6
E104 12.8

220 KT

At or above

MAX

LOST COMMS

28
5^

3400'

090^

22'

116.5 VTK

N01 31.4
E104 10.3

BIPOP

128.6

N01 24.9 E104 01.3

N01 26.7
E104 01.1

IDURO

203^

LOST COMMS

LOST COMMS

N01 33.1
E104 03.9

1. Set transponder to Mode A/C code 7600.


2. When cleared via LAVAX 1L by Singapore ATC:
a. MAINTAIN last assigned flight level or altitude
and proceed on LAVAX 1L to IDURO.
b. From IDURO commence descent and carry out
appropriate landing procedure for Rwy 20R as
close as possible to EAT or ETA.
c. If unable to effect a landing, refer to Singapore
Special Procedures for missed approach procedure.
3. No clearance or instruction received from
Singapore ATC:
Refer to 10-1P pages for radio communications
failure procedure.

Apt Elev

TO
M

D-ATIS

233
^

BIPAL

CHANGI

17 AN

WSSS/SIN
.RNAV.STAR.

SINGAPORE, SINGAPORE

Trans alt: 11000'

LAVAX ONE LIMA (LAVAX1L) ARRIVAL

| JEPPESEN, 2011, 2013. ALL RIGHTS RESERVED.

N01 27.5
E103 24.8

LOST COMMS

D30 D36.6
.0

082^

LOST COMMS

298

274^

18

LOST COMMS

7000'

1. Set transponder to Mode A/C code 7600.


2. When cleared via LELIB 2B by Singapore ATC:
a. MAINTAIN last assigned flight level or altitude
and proceed on LELIB 2B to BIDUS, then direct
to NYLON.
b. From NYLON commence descent and carry out
appropriate landing procedure for Rwy 20 as
close as possible to EAT or ETA.
c. If unable to effect a landing, refer to Singapore
Special Procedures for missed approach procedure.
3. No clearance or instruction received from
Singapore ATC:
Refer to 10-1P pages for radio communications
failure procedure.

LOST COMMS

10000'

LOST COMMS

4.
LELIB

.A246

VTK
116.5

220 KT

At or above

At

400 JB
JB

SJ

SINJON

113.5 SJ

220 KT

BIDUS

N01 35.9
E103 57.9

D12

296
^

NYLON

N01 37.0
E104 06.4

EXPECT RADAR
vectors for ILS
approach Rwy 20

^
326

MSA VTK VOR

3400'

VTK

TEKONG

116.5 VTK

2100'

MSA SJ VOR

2500'

090^

3000' - FL140
MAX 220 KT

N01 24.9 E104 01.3

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

2100'

1900'

LELIB TWO BRAVO


(LELIB2B) ARRIVAL
[LELI2B]

(RWYS 20C/R)

LOST COMMS
LOST COMMS

1 ROUTING
At LELIB, turn LEFT and track 082^ to JB. Then track 086^ to ALFA, then
turn LEFT and track 057^ to BIDUS. From BIDUS, EXPECT RADAR vectors
for ILS approach Rwy 20.

.9

^
057 10

3000'

At or above

MAX

355^

N01 13.4 E103 51.3

(SJ R-333/D18.6)
(VTK R-285/D19.3)

N01 30.0 E103 42.7

JAYBEE

086^

6000'

At or above

N01 30.6
E103 49.7

ALFA

D17.2

At or above

118

282^

250 KT

D55.5

At

N01 36.9 E103 07.2

(SJ R-298/D50.0)

ARAMA

NOT TO SCALE

Direct distance from BIDUS to:


Changi Apt 14 NM

3400'

090^

10-2K

LOST COMMS

22 NOV 13

LOST COMMS

JEPPESEN

LOST COMMS

007^

CHANGES: Lost comms.

3.2
D1

D22.6

180^
360^

180^
360^

203^

D-ATIS

023^

128.6

033

CHANGI

023^D30^.0
D13
.0

WSSS/SIN
.RNAV.STAR.

SINGAPORE, SINGAPORE

Alt Set: hPa Trans level: FL130 Trans alt: 11000'


1. RADAR required. 2. Non-RNP-1/P-RNAV approved aircraft shall fly this
as a basic RNAV (B-RNAV) procedure 1 or EXPECT RADAR vectors from
Apt Elev ATC. 3. All SOUTHBOUND flights from the WEST landing at Singapore
Changi Apt are to request the STAR only from Singapore ATC on 133.25 or
22'
135.8 when Rwy 20 is in use and within 120 DME SJ. Flight shall remain
under the control of WMKK ATC. 4. Changi arrivals via ATS route A-464
shall flight plan BOBAG 1A or BOBAG 1B as STAR route. When traffic
permits, BOBAG 1K, BOBAG 1L or LELIB 2B STAR will be issued to pilots.

LOST COMMS

| JEPPESEN, 2006, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN
CHANGI

128.6

22'

Alt Set: hPa Trans level: FL130 Trans alt: 11000'


1. RADAR required.
2. Non-RNP-1/P-RNAV approved aircraft shall fly this as a basic RNAV
(B-RNAV) procedure 1 or EXPECT RADAR vectors from ATC.
180^

PASPU ONE ALPHA (PASPU1A) ARRIVAL


[PASP1A]

3400'

090^

.L642.

180^

360^

(SJ R-009/D102)
(VTK R-003/D89.8)

180^

172^

(SJ R-050/D21.7)

At or above

6000'

21
(VTK R-204/D21.1)

N01 05.5
E103 52.9

D8.0

168^

SAMKO

124

D9 ^
.9

SANAT

(VTK R-186/D17.1)

N01 07.8 E103 59.5


MAX

220 KT

At or above

4000'
168^

348^

4000' - FL140
MAX 220 KT

EXPECT RADAR
vectors for ILS
approach Rwy 02

LOST COMMS

N01 13.4 E103 51.3

At 220 KT
or as directed
by ATC

LOST COMMS

203^

D6

SINJON

Direct distance from SANAT to:


Changi Apt 14 NM

N01 27.4 E104 07.8

069.^9

N01 24.9 E104 01.3


D

POSUB

10

VTK
113.5 SJ
SJ

116.5 VTK

N03 02.3 E104 40.4

250 KT

LOST COMMS

(SJ R-033/D30.0)
(VTK R-023/D13.0)

TEKONG

FL280 - FL350
MAX 300 KT

(SJ R-024/D119)
(VTK R-022/D105)

3000' - FL140
MAX 220 KT

023^

NYLON

N01 37.0 E104 06.4

MSA SJ VOR

KILOT

COMMS

22

220 KT

MSA VTK VOR

FL210

203^

N01 59.3 E104 06.3

2500'

At or below

31

^
PASPU

L
BA
A
2
M 4

N02 30.4 E104 06.3

(SJ R-018/D48.1)
(VTK R-008/D34.5)

2100'

2100'

^
051

N892

(SJ R-011/D78.1)
(VTK R-004/D65.3)

At

At

^
231 .

PIBAP

25

BIK
TA

35

180^

27

N02 55.0
E104 06.3

258^

090^

^
231

N03 28.4 E105 12.6

VINIL

120^

MABAL

(SJ R-031/D157)
(VTK R-030/D142)

180^

FL160 - FL260
MAX 250 KT

.4 347
D80
355^
D90.2

N02 43.6
E103 43.1

57

.B.M476591. .
BIKTA

VEPLI

N03 52.4 E104 05.7

FL280 - FL350
MAX 300 KT

360^

VEPLI

(SJ R-005/D159)
(VTK R-002/D147)

3400'
1900'

360^

(RWYS 02L/C)

NOT TO SCALE

180^

Apt Elev

360^

D-ATIS

.RNAV.STAR.

10-2L

22 NOV 13

LOST COMMS

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft
LOST COMMS

LOST COMMS

LOST COMMS

1. Set transponder to Mode A/C code 7600.


2. When cleared via PASPU 1A by Singapore
ATC:
a. MAINTAIN last assigned flight level or
altitude and proceed on PASPU 1A to
SANAT, then direct to SAMKO.
b. From SAMKO commence descent and
carry out appropriate landing procedure for
Rwy 02 as close as possible to EAT or ETA.
c. If unable to effect a landing, refer to
Singapore Special Procedures for
missed approach procedure.
3. No clearance or instruction received from
Singapore ATC:
Refer to 10-1P pages for radio
communications failure procedure.
LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

1 TRANSITIONS
BIKTA
(M-751/B-469)
MABAL
(N-892)
VEPLI
(L-642)

At BIKTA track 120^ to PIBAP, then turn RIGHT and track 180^ to PASPU.
At MABAL track 231^ to KILOT, then turn RIGHT to track 258^ to VINIL. Turn
LEFT and track 180^ to PIBAP and then to PASPU.
At VEPLI track 180^ to PIBAP then to PASPU.

1 ROUTING
At PASPU track 180^ to NYLON then track 172^ to POSUB. Turn RIGHT and track 203^ to
SANAT. From SANAT, EXPECT RADAR vectors for ILS approach Rwy 02.
CHANGES: Lost comms.

| JEPPESEN, 2006, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN
CHANGI

22'

180^

PASPU ONE BRAVO (PASPU1B) ARRIVAL


[PASP1B]

3400'

090^

(RWYS 20C/R)

.L642.

180^
(SJ R-009/D102)
(VTK R-003/D89.8)

31

220 KT

EXPECT RADAR
vectors for ILS
approach Rwy 20

NOT TO SCALE
Direct distance from NYLON to:
Changi Apt 17 NM

3000' - FL140
MAX 220 KT
NYLON

(SJ R-033/D30.0)
(VTK R-023/D13.0)

3000'

MAX 220 KT
or as directed by ATC

VTK

LOST COMMS

N01 24.9 E104 01.3

SINJON

LOST COMMS

113.5 SJ

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

COMMS

N01 13.4 E103 51.3

1
BIKTA
(M-751/B-469)
MABAL
(N-892)
VEPLI
(L-642)

N03 02.3 E104 40.4

At or above

TEKONG

SJ

FL280 - FL350
MAX 300 KT

N01 37.0 E104 06.4

116.5 VTK

MSA SJ VOR

250 KT

LOST COMMS

2100'

(SJ R-024/D119)
(VTK R-022/D105)

FL210

023^

6000'

22

At or above

2500'

KILOT

At or below

203^

N01 59.3 E104 06.3


At

L
BA
A
2
M 4

N02 30.4 E104 06.3


At

^
051

N892

(SJ R-011/D78.1)
(VTK R-004/D65.3)

180^

7^

PASPU

(SJ R-018/D48.1)
(VTK R-008/D34.5)

^
231 .

PIBAP

25

BIK
TA

35

180^

4
.4 3
D80
355^
D90.2

27

N02 55.0
E104 06.3

258^

090^

^
231

N03 28.4 E105 12.6

360^

VINIL

120^

MABAL

(SJ R-031/D157)
(VTK R-030/D142)

180^

BIKTA

N02 43.6
E103 43.1

57

.B.M476591. .

FL160 - FL260
MAX 250 KT

VEPLI

N03 52.4 E104 05.7

MSA VTK VOR

FL280 - FL350
MAX 300 KT

360^

VEPLI

(SJ R-005/D159)
(VTK R-002/D147)

3400'
1900'

2100'

180^

128.6

Alt Set: hPa Trans level: FL130 Trans alt: 11000'


1. RADAR required.
2. Non-RNP-1/P-RNAV approved aircraft shall fly this as a basic RNAV
(B-RNAV) procedure 1 or EXPECT RADAR vectors from ATC.

360^

Apt Elev

360^

D-ATIS

.RNAV.STAR.

10-2M

22 NOV 13

LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

1. Set transponder to Mode A/C code 7600.


2. When cleared via PASPU 1B by Singapore
ATC:
a. MAINTAIN last assigned flight level or
altitude and proceed on PASPU 1B to
NYLON.
b. From NYLON commence descent and
carry out appropriate landing procedure for
Rwy 20 as close as possible to EAT or ETA.
c. If unable to effect a landing, refer to
Singapore Special Procedures for
missed approach procedure.
3. No clearance or instruction received from
Singapore ATC:
Refer to 10-1P pages for radio
communications failure procedure.
LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

TRANSITIONS

At BIKTA track 120^ to PIBAP, then turn RIGHT and track 180^ to PASPU.
At MABAL track 231^ to KILOT, then turn RIGHT to track 258^ to VINIL. Turn
LEFT and track 180^ to PIBAP and then to PASPU.
At VEPLI track 180^ to PIBAP then to PASPU.

1 ROUTING
At PASPU track 180^ to NYLON. From NYLON, EXPECT RADAR vectors for ILS approach
Rwy 20.
CHANGES: Airport elevation, lost comms.

| JEPPESEN, 2006, 2013. ALL RIGHTS RESERVED.

JEPPESEN

WSSS/SIN
CHANGI
D-ATIS

Apt Elev

128.6

22'

.RNAV.STAR.

10-2N

22 NOV 13

SINGAPORE, SINGAPORE

Alt Set: hPa Trans level: FL130 Trans alt: 11000'


1. RADAR required. 2. RNAV 1.
3. RNAV (GNSS) CDO.
180^

PASPU ONE KILO (PASPU1K) ARRIVAL


[PASP1K]

3400'

(RWY 02L)

090^

2100'

360^

2500'

MSA SJ VOR

VEPLI

180^

N03 52.4
E104 05.7

VEPLI

^
231

57

NOT TO SCALE

L
BA 42
A
M

BIKTA

258^

VINIL

120^

BIK
TA

35

KILOT

N03 02.3
E104 40.4

25

27

N02 55.0
E104 06.3

180^

N02 43.6
E103 43.1

PIBAP

31

180^

N02 30.4
E104 06.3
At or below

FL270

PASPU
22

N01 59.3
E104 06.3

POSUB

NYLON

SJ

N01 27.4
E104 07.8
MAX

At or above

6000'

SINJON

N01 13.4 E103 51.3


ADNIK

293
^
SANAT

N01 07.8
E103 59.5
MAX

220 KT

At or above

4000'

COMMS

SADET

N01 10.1
E103 54.2

LOST COMMS

LOST COMMS

023^

21

N01 16.9
E103 56.9

LOST COMMS

113.5 SJ

WAYPOINT TO
THRESHOLD DISTANCE
ADNIK - 4.5 NM
BIKTA - 128.6 NM
KILOT - 161.6 NM
MABAL - 203.6 NM
NYLON - 48.6 NM
PASPU - 70.6 NM
PIBAP - 101.6 NM
POSUB - 38.6 NM
SADET - 11.7 NM
SANAT - 17.6 NM
VEPLI - 183.6 NM
VINIL - 126.6 NM

250 KT

203^

^
17210

N01 37.0
E104 06.4

MABAL

N03 28.4
E105 12.6

LOST COMMS

1
Changi EAST Rwy 02R/20L
is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

LOST COMMS

LOST COMMS

LOST COMMS

1. Set transponder to Mode A/C code 7600.


2. When cleared via PASPU 1K by Singapore
ATC:
a. MAINTAIN last assigned flight level or
altitude and proceed on PASPU 1K to
ADNIK.
b. From ADNIK commence descent and
carry out appropriate landing procedure for
Rwy 02L as close as possible to EAT or ETA.
c. If unable to effect a landing, refer to
Singapore Special Procedures for
missed approach procedure.
3. No clearance or instruction received from
Singapore ATC:
Refer to 10-1P pages for radio
communications failure procedure.
LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

TRANSITIONS
From BIKTA to PIBAP.
From MABAL to KILOT, to VINIL , to PIBAP.
From VEPLI to VINIL, to PIBAP.
ROUTING
From BIPAP to PASPU, to NYLON, to POSUB, to SANAT, to SADET, to ADNIK.
BIKTA
MABAL
VEPLI

CHANGES: Airport elevation, lost comms.

| JEPPESEN, 2011, 2013. ALL RIGHTS RESERVED.

JEPPESEN

WSSS/SIN

22 NOV 13

CHANGI

Apt Elev

128.6

22'

.RNAV.STAR.

10-2P

Alt Set: hPa Trans level: FL130 Trans alt: 11000'


1. RADAR required. 2. RNAV 1.
3. RNAV (GNSS) CDO.

180^

D-ATIS

SINGAPORE, SINGAPORE
3400'

PASPU ONE LIMA (PASPU1L) ARRIVAL

090^

1900'

2100'

360^

[PASP1L]

(RWY 20R)

MSA VTK VOR

VEPLI

180^

N03 52.4
E104 05.7

57

VEPLI

NOT TO SCALE

258^

VINIL

BIKTA

120^

27

BIK
TA

PIBAP

180^
31

PASPU

N02 30.4
E104 06.3
At or below

FL250

N01 59.3
E104 06.3

MAX

250 KT

At or above

6000'
22

^
2154

BIPAL

NYLON

N01 37.0
E104 06.4
MAX

220 KT

WAYPOINT TO
THRESHOLD DISTANCE
BIKTA - 96.1 NM
BIPAL - 11.5 NM
IDURO - 4.5 NM
KILOT - 129.1 NM
MABAL - 171.1 NM
NYLON - 16.1 NM
PASPU - 38.1 NM
PIBAP - 69.1 NM
VEPLI - 151.1 NM
VINIL - 94.1 NM

1
Changi EAST Rwy 02R/20L
is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

At or above

3000'

203^

N01 33.1
E104 03.9

N03 28.4
E105 12.6

KILOT

N03 02.3
E104 40.4

25

N02 43.6
E103 43.1

35

180^

N02 55.0
E104 06.3

L
BA 42
A
M

^
231 MABAL

VTK
TEKONG

LOST COMMS

116.5 VTK

N01 24.9 E104 01.3

COMMS

LOST COMMS

LOST COMMS

IDURO

N01 26.7
E104 01.1

LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

1. Set transponder to Mode A/C code 7600.


2. When cleared via PASPU 1L by Singapore
ATC:
a. MAINTAIN last assigned flight level or
altitude and proceed on PASPU 1L to
IDURO.
b. From IDURO commence descent and
carry out appropriate landing procedure for
Rwy 20R as close as possible to EAT or ETA.
c. If unable to effect a landing, refer to
Singapore Special Procedures for missed
approach procedure.
3. No clearance or instruction received from
Singapore ATC:
Refer to 10-1P pages for radio
communications failure procedure.
LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

TRANSITIONS
From BIKTA to PIBAP.
From MABAL to KILOT, to VINIL, to PIBAP.
From VEPLI to VINIL, to PIBAP.
ROUTING
From BIPAP to PASPU, to NYLON, to BIPAL, to IDURO.
BIKTA
MABAL
VEPLI

CHANGES: Airport elevation, lost comms.

| JEPPESEN, 2011, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

CHANGI
D-ATIS

Apt Elev

128.6

22'

.RNAV.STAR.

10-2Q

22 NOV 13

180^

WSSS/SIN

Alt Set: hPa Trans level: FL130 Trans alt: 11000'


1. RADAR required. 2. RNAV 1.
3. RNAV (GNSS) CDO.

3400'

090^

REMES ONE KILO (REMES1K) ARRIVAL

2100'

2500'

360^

[REME1K]

(RWY 02L)

MSA SJ VOR

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

SJ

ADNIK

SINJON

N01 16.9
E103 56.9

113.5 SJ
7

N01 13.4 E103 51.3

023^

SADET

N01 05.5
E103 52.9
MAX

SAMKO

015^

N01 10.1
E103 54.2

220 KT

NOT TO SCALE

At or above

4000'
22

REMES

N00 43.7
E103 57.6
MAX

250 KT

At or above

6000'

28

WAYPOINT TO
THRESHOLD DISTANCE
ADNIK - 4.5 NM
REMES - 38.4 NM
REPOV - 66.4 NM
SADET - 11.7 NM
SAMKO - 16.4 NM

REPOV

N00 16.4
E104 03.0
At or below

348^

LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS
COMMS

LOST

CHANGES: Airport elevation, lost comms.

LOST COMMS

1. Set transponder to Mode A/C code 7600.


2. When cleared via REMES 1K by Singapore ATC:
a. MAINTAIN last assigned flight level or altitude
and proceed on REMES 1K to ADNIK.
b. From ADNIK commence descent and carry out
appropriate landing procedure for Rwy 02L as
close as possible to EAT or ETA.
c. If unable to effect a landing, refer to Singapore
Special Procedures for missed approach procedure.
3. No clearance or instruction received from
Singapore ATC:
Refer to 10-1P pages for radio communications
failure procedure.
ROUTING
From REPOV to REMES, to SAMKO, to SADET, to ADNIK.

LOST COMMS

LOST COMMS

LOST COMMS

FL250

| JEPPESEN 2011, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN
CHANGI
D-ATIS

Apt Elev

128.6

22'

.RNAV.STAR.

10-2S

22 NOV 13

Alt Set: hPa Trans level: FL130


1. RADAR required. 2.RNAV 1.
3. RNAV (GNSS) CDO.

Trans alt: 11000'


180^

REMES ONE LIMA (REMES1L) ARRIVAL


[REME1L]

3400'

(RWY 20R)

090^

1900'

360^

2100'

MSA VTK VOR

BIPAL

N01 33.1
E104 03.9

VTK
TEKONG

IDURO

N01 26.7
E104 01.1

N01 31.4
E104 10.3

5^
28

203^

BIPOP

WAYPOINT TO
THRESHOLD DISTANCE
BIPAL - 11.5 NM
BIPOP - 18.2 NM
BTM - 42.2 NM
DOVAN - 30.2 NM
IDURO - 4.5 NM
REMES - 69.2 NM
REPOV - 97.2 NM

MAX 220 KT
At or above

3000'

116.5 VTK

N01 24.9 E104 01.3


12

348^

DOVAN

N01 19.6
E104 12.8
At or above

4000'

023
^

12

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

BTM
BATAM

*116.0 BTM

N01 08.2 E104 08.0


MAX 250 KT
At or above

27

7000'

LOST COMMS

0 23
^

NOT TO SCALE

REMES

COMMS

28

LOST COMMS

N00 43.7
E103 57.6

REPOV

At or below

348^

N00 16.4
E104 03.0

LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

1. Set transponder to Mode A/C code 7600.


2. When cleared via REMES 1L by Singapore ATC:
a. MAINTAIN last assigned flight level or altitude
and proceed on REMES 1L to IDURO.
b. From IDURO commence descent and carry out
appropriate landing procedure for Rwy 20R as
close as possible to EAT or ETA.
c. If unable to effect a landing, refer to Singapore
Special Procedures for missed approach procedure.
3. No clearance or instruction received from
Singapore ATC:
Refer to 10-1P pages for radio communications
failure procedure.
LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

FL270
ROUTING
From REPOV to REMES, to BTM, to DOVAN, to BIPOP, to BIPAL, to IDURO.
CHANGES: Airport elevation, lost comms.

| JEPPESEN, 2011, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN
CHANGI

22'

180^

REMES FIVE ALPHA (REMES5A) ARRIVAL


[REME5A]

180^

128.6

Alt Set: hPa Trans level: FL130 Trans alt: 11000'


1. RADAR required.
2. Non-RNP-1/P-RNAV approved aircraft shall fly this as a basic RNAV
(B-RNAV) procedure 1 or EXPECT RADAR vectors from ATC.
3400'

3400'

090^

(RWYS 02L/C)

1900'

2100'

2500'

MSA VTK VOR


D

090^

2100'

360^

Apt Elev

360^

D-ATIS

.RNAV.STAR.

10-2T

22 NOV 13

MSA SJ VOR

VTK
TEKONG

116.5 VTK

N01 24.9 E104 01.3

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft
D

SJ
SINJON

113.5 SJ

N01 13.4 E103 51.3

204^

D21
.

EXPECT RADAR
vectors for ILS
approach Rwy 02

4000' - FL140
MAX 220 KT

(SJ R-168/D8.0)

N01 05.5
E103 52.9
MAX

220 KT

At or above

4000'

22

N00 43.7
E103 57.6

220 KT

D41.2

185^

168^

REMES

(SJ R-168/D30.2)

At

SAMKO

At or above

NOT TO SCALE

168^

6000'

179^

6000' - FL140
MAX 220 KT

28

LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

250 KT

51 ARDI
MP
FRO

LOST COMMS

At

.G.57394.8^

LOST COMMS

LOST COMMS

COMMS

N00 16.4
E104 03.0

FL210

LOST COMMS

1. Set transponder to Mode A/C code 7600.


2. When cleared via REMES 5A by Singapore ATC:
a. MAINTAIN last assigned flight level or altitude
and proceed on REMES 5A to SAMKO.
b. From SAMKO commence descent and carry out
appropriate landing procedure for Rwy 02 as
close as possible to EAT or ETA.
c. If unable to effect a landing, refer to Singapore
Special Procedures for missed approach procedure.
3. No clearance or instruction received from
Singapore ATC:
Refer to 10-1P pages for radio communications
failure procedure.

D68.2

LOST COMMS

(SJ R-168/D57.9)

At or below

168^

LOST COMMS

LOST COMMS

LOST COMMS

348^

FL150 - FL250
MAX 250 KT

REPOV

Direct distance from SAMKO to:


Changi Apt 17 NM

1 ROUTING
At PARDI track 348^ to REPOV, then to REMES, then to SAMKO. From SAMKO, EXPECT
RADAR vectors for ILS approach Rwy 02.
CHANGES: Airport elevation, lost comms.

| JEPPESEN, 2006, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN
CHANGI

22'

180^

REMES SIX BRAVO (REMES6B) ARRIVAL


[REME6B]

3400'

090^

(RWYS 20C/R)

2100'

3000' - FL140
MAX 220 KT

203^

NYLON

N01 37.0 E104 06.4

VTK
TEKONG

1
D1 .2
6
D2 47^

116.5 VTK

N01 24.9 E104 01.3

MAX 220 KT
At or above

3000'

113.5 SJ

N01 13.4 E103 51.3

115^D12.7
074^22.5

7000'
At 220 KT

NOT TO SCALE

BTM
BATAM

*116.0 BTM

LOST COMMS

27

185^

LOST COMMS

(SJ R-107/D17.5)
(VTK R-158/D17.9)

LOST COMMS

168^

179^

6000' - FL140
MAX 220 KT

4000'

N01 08.2 E104 08.0

023
^

.2
D30

220 KT

D41.2

168^
REMES

At or above

or as directed
by ATC

N00 43.7 E103 57.6

N01 19.6
E104 12.8

023
^

2
At or above

At

DOVAN

348^

SJ
SINJON

MSA SJ VOR

12

2100'

2500'

N01 31.4
E104 10.3

12

090^

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

BIPOP

^
055 .0

3400'
1900'

MSA VTK VOR

EXPECT RADAR
vectors for ILS
approach Rwy 20

023^

(SJ R-033/D30.0)
(VTK R-023/D13.0)

180^

128.6

Alt Set: hPa Trans level: FL130 Trans alt: 11000'


1. RADAR required.
2. Non-RNP-1/P-RNAV approved aircraft shall fly this as a basic RNAV
(B-RNAV) procedure 1 or EXPECT RADAR vectors from ATC.

360^

Apt Elev

360^

D-ATIS

.RNAV.STAR.

10-2U

22 NOV 13

LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

1. Set transponder to Mode A/C code 7600.


2. When cleared via REMES 6B by Singapore ATC:
a. MAINTAIN last assigned flight level or altitude
and proceed on REMES 6B to BIPOP, then direct
to NYLON.
b. From NYLON commence descent and carry out
appropriate landing procedure for Rwy 20 as
close as possible to EAT or ETA.
c. If unable to effect a landing, refer to Singapore
Special Procedures for missed approach procedure.
3. No clearance or instruction received from
Singapore ATC:
Refer to 10-1P pages for radio communications
failure procedure.
LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

28

REPOV

(SJ R-168/D57.9)

D68.2

348^

N00 16.4
E104 03.0
At 250 KT
At or below

FL150 - FL250
MAX 250 KT

FL210

.G.573948. ^

51 ARDI
MP
FRO

168^

Direct distance from BIPOP to:


Changi Apt 15 NM

1 ROUTING
At PARDI track 348^ to REPOV, then to REMES. Then turn RIGHT and track 023^ to BTM,
then to DOVAN. Turn LEFT and track 348^ to BIPOP. From BIPOP, EXPECT RADAR vectors for
ILS approach Rwy 20.
CHANGES: Airport elevation, lost comms.

| JEPPESEN, 2006, 2013. ALL RIGHTS RESERVED.

WSSS/SIN

+ JEPPESEN
26 JAN 07

10-3

SINGAPORE, SINGAPORE

CHANGI

MINIMUM CLIMB GRADIENT CRITERIA


The Instrument Departure Procedures are only applicable for aircraft with all engines
operating. It remains the responsibility of the operator to develop contingency procedures for the individual type of aircraft and to conduct the necessary examination of
obstacles throughout the areas concerned in relation to the certificated performance of
the individual aircraft type. It is also the responsibility of the operator to ensure that
contingency procedures comply fully with the airplane performance requirements of
Annex 6.
The specific routes to be followed are depicted in SID Charts pages. Altitude restrictions at fixes and/or DME specify ATC/airspace requirements. Minimum net climb gradient specifies obstacle clearance requirements.
In the event that the minimum net climb gradient cannot be achieved, pilots shall
inform ATC and ATC shall hold departures if pilots indicate that they are unable to
meet the required net climb gradient.
RUNWAY 02L
When there are no reports of vessel movement along the northern shipping channel, or
where the reported vessel height is less than 35m (115 ft) AMSL, the aircraft minimum
net climb gradient shall be at 3.3%.
Where the reported vessel height is 35m (115 ft) AMSL or higher, ATC shall advise
departing pilots of the vessel height. Pilots, on receipt of this information, shall apply
the minimum net climb gradient in accordance with the table below.
Ht of Vessel
(meters AMSL)

Gradient
(%)

35

Minimum Crossing Altitude Over Vessel


meters

feet

3.4

44

142

40

3.9

49

158

50

4.8

59

191

60

5.8

69

224

70

6.8

79

257

80

7.8

89

290

90

8.8

99

322

100

9.7

109

355

110

10.7

119

388

120

11.7

129

421

130

12.7

139

454

140

13.7

149

486

After the aircraft has reached or passed the minimum crossing altitude over vessel,
the minimum net climb gradient shall be 3.3%.
RUNWAY 02C
When there are no reports of vessel movement along the northern shipping channel, or
where the reported vessel height is less than 70m (230 ft) AMSL, the aircraft minimum
net climb gradient shall be at 3.3%.
Where the reported vessel height is 70m (230 ft) AMSL or higher, ATC shall advise
pilots of the vessel height. Pilots, on receipt of this information, shall apply the minimum net climb gradient in accordance with the following table.

| JEPPESEN SANDERSON, INC., 1998, 2007. ALL RIGHTS RESERVED.

WSSS/SIN

+ JEPPESEN
26 JAN 07

SINGAPORE, SINGAPORE

10-3A

CHANGI

MINIMUM CLIMB GRADIENT CRITERIA


Ht of Vessel
(meters AMSL)

Gradient
(%)

70

Minimum Crossing Altitude Over Vessel


meters

feet

3.4

89

292

80

3.8

99

325

90

4.3

109

358

100

4.7

119

390

110

5.1

129

423

120

5.5

139

456

130

6.0

149

489

140

6.4

159

522

After the aircraft has reached or passed the minimum crossing altitude over vessel,
the minimum net climb gradient shall be 3.3%.
RUNWAYS 20C/20R
All departures on Runway 20C/20R shall be on a minimum net climb gradient of 5%
until reaching or passing 400 ft. Thereafter, the minimum net climb gradient shall be
3.3%.
Refer to Standard Instrument Departures for Runways 20C and 20R.
DETERMINATION OF CLIMB GRADIENT BY OPERATORS
The minimum net climb gradients specified above need not apply to operators who wish
to calculate their own climb gradients based on actual lift-off point, provided the calculation ensures the following:

^ the most penalizing obstacle is taken into account under both all-engines operating
procedures as well as one-engine-out procedures; and
^ the required minimum obstacle clearance (MOC) is met under all engines operating
procedures.
For the above calculations, operators shall use the following information:
a. The most penalizing obstacle is a tall vessel which is on the extended center line of
the runway. (ATC shall advise pilots of the height of the tall vessel.)
b. The required MOC is 0.8% of the distance (d) from the departure end of runway
(DER) to the obstacle, in accordance with Volume II of ICAO Doc 8168 Procedures for Air Navigation Services Operations (PANS-OPS)
where, in the case
of Singapore Changi Airport, the DER is defined as the end of the clearway.
c. The distance (d) for departure Runways 02L/02C is measured from the DER to the
shipping channel north of Changi. The distance (d) for departure Runways 20C/20R is
measured from the DER to the boundary of the restricted waters south of Changi
wherein tall vessels of height above 49m (161 ft) AMSL are not permitted. The distance (d) for the various departure runways is as follows:
Departure Runway

Distance (d)

02L

1020m

02C

2360m

20C

5945m

20R

8370m

| JEPPESEN SANDERSON, INC., 1998, 2007. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

CHANGI

22 NOV 13

.RNAV.SID.

10-3B

180^

Trans level: FL130 Trans alt: 11000'


1. These SIDs will be assigned during air defense exercises.
Apt Elev 2. RADAR required. 3. RNAV 1 (GNSS, DME/DME).
4. All SIDs include noise preferential routes. 5. Cruising levels
22'
will be issued after take-off by Singapore RADAR. 6. Aircraft
unable to fly SID profile shall inform ATC prior to departure and
to EXPECT RADAR vectoring, if necessary.

3400'

090^

1900'

2100'

360^

WSSS/SIN

MSA VTK VOR

180^

ADPAX 1U [ADPA1U],
ADPAX 1W [ADPA1W]
DEPARTURES

3400'

090^

2100'

(RWYS 02L, 02C)

360^

2500'

SPEED: MAX 220 KT UNTIL PASSING 4000' AND


250 KT UNTIL PASSING 10000'

MSA SJ VOR

At or above

6000'

ADPAX

N01 44.0 E103 15.6


TOREK

N01 43.3 E104 01.6

16

MA 30
A
FL1 FL2
40 40

297
^

JB
JAYBEE

001^

24
MAA FL240
FL140

400 JB

NUGSI

266^

N01 31.3
E104 06.4
At or above

FL140

N01 30.0 E103 42.7

001^

N01 27.4
E104 01.4

023^

022D^PAX 1U

VIDAX

VTK
TEKONG

116.5 VTK

N01 24.9 E104 01.3


ADPAX 1W

NOT TO SCALE

SJ
SINJON

113.5 SJ

N01 13.4 E103 51.3

LOST COMMS

LOST COMMS

LOST COMMS

LOST

LOST COMMS

LOST COMMS

LOST COMMS

LOST

LOST COMMS

1. Set transponder to Mode A/C code 7600.


2. Communications failure occurs immediately
after departure on Rwys 02L/C:
Proceed straight ahead to Nylon Holding
Area (NHA) climbing to the last assigned
altitude. Thereafter refer to 10-1P pages
for radio communications failure procedure.

COMMS

LOST COMMS

LOST COMMS

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

Direct distance from Changi Apt


(Rwy 02L) to: VIDAX 6 NM
(Rwy 02C) to: VTK 4 NM

For minimum climb gradient criteria:


Rwys 02L/C- See 10-3 and 10-3A.

Initial climb clearance 3000' or as directed by ATC


SID
ADPAX 1U
ADPAX 1W

RWY
02L
02C

INITIAL CLIMB

To VIDAX on course 022^.


To VTK on course 023^.
ROUTING
To TOREK. Climb on track 001^, at or above 6000' turn RIGHT direct to NUGSI. Then to
JB (JAYBEE), to ADPAX.
CHANGES: Airport elevation, lost comms.

| JEPPESEN, 2009, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN
CHANGI

.RNAV.SID.

10-3C

22 NOV 13

2100'

(RWYS 20C/R)

3400'

090^

1900'

MSA VTK VOR

SPEED: MAX 220 KT UNTIL PASSING


4000' AND 250 KT UNTIL
PASSING 10000'

MSA SJ VOR

VTK
TEKONG

116.5 VTK

N01 24.9 E104 01.3

PA

SUNVA

AD

N01 17.9
E103 57.4

A
SUDPO

203^

203X^ 1V

35
FL240
MAA
FL140

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

N01 17.5
E103 58.1

At or above

N01 13.4 E103 51.3

2000'

344^

SUSIN

N01 12.5
E103 58.1

180^

BOBAG

BASIX

11

N01 02.5
E103 29.9
At or above

FL140

326

40
FL2
A 40
MA FL1 9

N01 10.0
E103 24.9

At or above

ADPAX 1X

180^

113.5 SJ
SJ
SINJON

171^

2000'
D

2100'

2500'

360^

N01 44.0
E103 15.6

3400'

090^

360^

ADPAX

180^

ADPAX 1V [ADPA1V],
ADPAX 1X [ADPA1X]
DEPARTURES

180^

Trans level: FL130 Trans alt: 11000'


1. These SIDs will be assigned during air defense exercises.
2. RADAR required. 3. RNAV 1 (GNSS, DME/DME). 4. 1 The restriction to cross
SUDPO or SUNVA at or above 2000' is applicable between 2301-1100 UTC. All
departure aircraft on Runways 20C/R issued with heading instructions by ATC shall
Apt Elev also cross VTK 8 DME at or above 2000' between 2301-1100 UTC. If the altitude
restriction cannot be complied with, the pilot-in-command of an aircraft departing on
22'
Runways 20C/R shall inform ATC during the time when the aircraft commences taxiing
to the holding point for departure. 5. All SIDs include noise preferential routes.
6. Cruising levels will be issued after take-off by Singapore RADAR. 7. Aircraft unable
to fly SID profile shall inform ATC prior to departure and to EXPECT RADAR
vectoring, if necessary.

28

DUNAL

LOST COMMS

Rwys 20C/R: Departures shall be on a


minimum net climb gradient of 5.0% until
reaching or passing 400'.
Gnd speed-KT
75 100 150 200 250 300
5.0% V/V (fpm) 380 506 760 1013 1266 1519

LOST COMMS

LOST

Direct distance from Changi Apt


(Rwy 20C) to: SUDPO 4 NM
(Rwy 20R) to: SUNVA 4 NM

NOT TO SCALE

N01 01.6
E103 58.1

271^
LOST COMMS

LOST COMMS

LOST COMMS

LOST

1. Set transponder to Mode A/C code 7600.


2. Communications failure occurs immediately
after departure on Rwys 20C/R:
Proceed straight ahead to Samko Holding
Area (SHA) climbing to the last assigned
altitude. Thereafter refer to 10-1P pages
for radio communications failure procedure.

LOST

LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

Initial climb clearance 3000' or as directed by ATC


SID
ADPAX 1V
ADPAX 1X

RWY
20R
20C

INITIAL CLIMB
To SUNVA on course 203^, then to SUSIN.
To SUDPO on course 203^, then to SUSIN.
ROUTING
At SUSIN to DUNAL, BOBAG, BASIX, ADPAX.
CHANGES: Airport elevation, lost comms.

| JEPPESEN, 2009, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN

10-3D
.RNAV.SID.
Trans level: FL130 Trans alt: 11000'
1. RADAR required. 2. Non-RNP-1/P-RNAV approved aircraft shall fly this as
a basic RNAV (B-RNAV) procedure 1 or EXPECT RADAR vectors from ATC.
3. 2 The restriction to cross SUDPO at or above 2000' is applicable between
2301-1100 UTC. All departure aircraft on Runway 20C issued with heading
Apt Elev instructions by ATC shall also cross VTK 8 DME at or above 2000' between 23011100 UTC. If the altitude restriction cannot be complied with, the pilot-in-command
22'
of an aircraft departing on Runway 20C shall inform ATC during the time when the
aircraft commences taxiing to the holding point for departure. 4. All SIDs include
noise preferential routes. 5. Cruising levels will be issued after take-off by
Singapore RADAR. 6. On initial contact when requesting ATC, inform ATC of the FL
can cross at ANITO.

CHANGI

180^

ANITO FIVE ALPHA (ANI5A),


ANITO FOUR BRAVO (ANI4B) DEPARTURES

180^

22 NOV 13

3400'

090^

2500'

MSA VTK VOR

MSA SJ VOR

360^

SPEED: MAX 220 KT UNTIL PASSING


4000' AND 250 KT UNTIL
PASSING 10000'

2100'

2100'

360^

(RWYS 02C, 20C)

3400'

090^

1900'

TOKIM

(SJ R-037/D20.1)
(VTK R-023/D5.0)

023^

N01 17.5
E103 58.1

N01 13.4 E103 51.3

AN

SUSIN

N01 12.5
E103 58.1

ITO

(ANOUR B
I4 R
17 B) AVO

4000'

LOST COMMS

LOST

LOST COMMS

LOST

N01 03.8 E104 13.3


At or below 6000'
or as directed by ATC

DOSNO

N00 48.0 E104 14.2

ANITO

(SJ R-146/D109)
(VTK R-153/D113)

S00 17.0 E104 52.0

.B.47

NOT TO SCALE

0.

RWY

LOST COMMS

(SJ R-113/D24.0)

^
15075

SID

D3
4.
1

LOST COMMS

DOBLU

16

Rwy 20C: Departures shall be on a


minimum net climb gradient of 5.0% until
reaching or passing 400'.
Gnd speed-KT 75 100 150 200 250 300
5.0% V/V(fpm) 380 506 760 1013 1266 1519

.0
D39

For minimum climb gradient criteria:


Rwy 02C: See 10-3 and 10-3A.

177^
161^

Direct distance from Changi Apt


(Rwy 02C) to: TOKIM 9 NM
(Rwy 20C) to: SUDPO 4 NM

138
^

LOST COMMS

1. Set transponder to Mode A/C code


7600.
2. Communications failure occurs
immediately after departure on:
Rwy 02C: Proceed straight ahead to
Nylon Holding Area (NHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure
procedure.
Rwy 20C: Proceed straight ahead to
Samko Holding Area (SHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages
for radio communications failure
procedure.
LOST COMMS

4.2

At or above

D2

113.5 SJ
SJ
SINJON

^
150

120

22

^
059
097^
D6.

N01 24.9 E104 01.3

(ANI5A)

180^

0
D8.

VTK
TEKONG

116.5 VTK

D12.8

2000'

E ALPHA
ANITO FIV

203^
195^

At or above

LOST COMMS

(VTK R-203/D8.0)

4000'

173^

SUDPO

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

At or above

083^D9.4
.2
23
^
D
7
05

LOST COMMS

2000'

N01 26.1
E104 10.7

COMMS

At or above

DOKTA

LOST

115^

N01 29.6 E104 03.3

Initial climb clearance 3000' or as directed by ATC


1 INITIAL CLIMB

Climb straight ahead to TOKIM, turn RIGHT and track 115^ to DOKTA.
Turn RIGHT and track 173^ to DOBLU. Then track 177^ to DOSNO.
Climb straight ahead to SUDPO, turn LEFT and track 180^ to SUSIN.
ANI4B
20C
Turn LEFT and track 120^ to DOBLU. Turn RIGHT and track 177^ to DOSNO.
1 ROUTING
At DOSNO turn LEFT and track 150^ to ANITO and join ATS route B-470.
ANI5A

02C

CHANGES: Lost comms.

| JEPPESEN, 2006, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN
CHANGI

22 NOV 13

.RNAV.SID.

10-3E

SPEED: MAX 220 KT UNTIL PASSING


4000' AND 250 KT UNTIL
PASSING 10000'
TOPOM

(SJ R-034/D20.0)
(VTK R-013/D5.1)

At or above

4000'

4.1

180^
LOST

LOST COMMS

LOST COMMS

LOST COMMS

LOST

(SJ R-113/D24.0)

N01 03.8 E104 13.3


At or below 6000'
or as directed by ATC

DOSNO

N00 48.0 E104 14.2

ANITO

(SJ R-146/D109)
(VTK R-153/D113)

S00 17.0 E104 52.0

.B.47

NOT TO SCALE

0.

RWY

D3

LOST COMMS

DOBLU

^
15075

Rwy 20R: Departures shall be on a


minimum net climb gradient of 5.0% until
reaching or passing 400'.
Gnd speed-KT 75 100 150 200 250 300
5.0% V/V(fpm) 380 506 760 1013 1266 1519
SID

LOST COMMS

16

For minimum climb gradient criteria:


Rwy 02L: See 10-3 and 10-3A.

.0
D39

138
^

177^
161^

Direct distance from Changi Apt


(Rwy 02L) to: TOPOM 9 NM
(Rwy 20R) to: SUNVA 4 NM

LOST COMMS

LOST COMMS

195^
D12.8

4
17 F)

LOST COMMS

COMMS

203^
N01 12.5
E103 58.1

22

SUSIN

AN
FOITO F
(ANXTROOUR
I T

4.2

N01 13.4 E103 51.3

D2

SJ
SINJON

113.5 SJ

120

^
150

VTK

N01 24.9 E104 01.3

E ECHO
ANITO FIV

6.9

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

1. Set transponder to Mode A/C code


7600.
2. Communications failure occurs
immediately after departure on:
Rwy 02L: Proceed straight ahead to
Nylon Holding Area (NHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure
procedure.
Rwy 20R: Proceed straight ahead to
Samko Holding Area (SHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages
for radio communications failure
procedure.

TEKONG

116.5 VTK

(ANI5E)

172^

^
053
097^
D

LOST

083^D9.4
2
^ D23.
7
5
0

N01 17.9
E103 57.4

.6
D7

MSA SJ VOR

4000'

173^

SUNVA

(VTK R-210/D8.0)

2000'

MSA VTK VOR

At or above

023^

2000'

2500'

N01 26.1
E104 10.7

115^

At or above

2100'

2100'

DOKTA

N01 29.9 E104 02.5

At or above

3400'

090^

1900'

360^

(RWYS 02L, 20R)

3400'

090^

360^

ANITO FIVE ECHO (ANI5E),


ANITO FOUR FOXTROT (ANI4F) DEPARTURES

180^

Trans level: FL130 Trans alt: 11000'


1. RADAR required. 2. Non-RNP-1/P-RNAV approved aircraft shall fly this as
a basic RNAV (B-RNAV) procedure 1 or EXPECT RADAR vectors from ATC.
3. 2 The restriction to cross SUNVA at or above 2000' is applicable between
2301-1100 UTC. All departure aircraft on Runway 20R issued with heading
Apt Elev instructions by ATC shall also cross VTK 8 DME at or above 2000' between 23011100 UTC. If the altitude restriction cannot be complied with, the pilot-in-command
22'
of an aircraft departing on Runway 20R shall inform ATC during the time when the
aircraft commences taxiing to the holding point for departure. 4. All SIDs include
noise preferential routes. 5. Cruising levels will be issued after take-off by
Singapore RADAR. 6. On initial contact when requesting ATC, inform ATC of the FL
can cross at ANITO.

Initial climb clearance 3000' or as directed by ATC


1 INITIAL CLIMB

Climb straight ahead to TOPOM, turn RIGHT and track 115^ to DOKTA.
Turn RIGHT and track 173^ to DOBLU. Then track 177^ to DOSNO.
Climb straight ahead to SUNVA, turn LEFT and track 172^ to SUSIN.
ANI4F
20R
Turn LEFT and track 120^ to DOBLU. Turn RIGHT and track 177^ to DOSNO.
1 ROUTING
At DOSNO turn LEFT and track 150^ to ANITO and join ATS route B-470.
ANI5E

02L

CHANGES: Lost comms.

| JEPPESEN, 2006, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN
CHANGI

.RNAV.SID.

10-3F

22 NOV 13

Trans level: FL130 Trans alt: 11000'


1. RADAR required. 2. 1 The restriction to cross SUDPO at or above 2000' is
applicable between 2301-1100 UTC. All departure aircraft on Runway 20C issued
Apt Elev with heading instructions by ATC shall also cross VTK 8 DME at or above 2000'
between 2301-1100 UTC. If the altitude restriction cannot be complied with, the
22'
pilot-in-command of an aircraft departing on Runway 20C shall inform ATC during the
time when the aircraft commences taxiing to the holding point for departure. 3. All
SIDs include noise preferential routes. 4. Cruising levels will be issued after take-off
by Singapore RADAR.
3400'

(RWYS 02C, 20C)

090^

1900'

2100'

360^

02C ARO 1A: MAX 220 KT UNTIL 4000'


250 KT UNTIL PASSING 10000'
20C ARO 1B: MAX 220 KT UNTIL SAKIN
250 KT UNTIL PASSING 10000'

MSA VTK VOR

180^

SPEED: RWY
AND
RWY
AND

180^

AROSO 1A (ARO1A), AROSO 1B (ARO1B) DEPARTURES

3400'

090^

AKMET

N02 08.8
E103 24.4

N01 53.9
E103 43.7

24

MSA SJ VOR

At or above

11000'
LOST COMMS

LOST COMMS

N01 45.4
E103 54.7

308
^

AROSO 1A
At or above

7000'
1A
O )
OS 1A
AR (ARO 17

( 21

1B
SO B )
ARO
ARO1

TOKIM

332

LOST

LOST COMMS

14

LOST COMMS

LOST COMMS

AKOMA

LOST COMMS

LOST COMMS

NOT TO SCALE

LOST COMMS

1. Set transponder to Mode A/C code


7600.
2. Communications failure occurs
immediately after departure on:
Rwy 02C: Proceed straight ahead to
Nylon Holding Area (NHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure
procedure.
Rwy 20C: Proceed straight ahead to
Samko Holding Area (SHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure
procedure.

LOST COMMS

LOST COMMS

2100'

2500'

360^

AROSO

LOST COMMS

N01 29.6
E104 03.3
At or above

2000'

342^

SUDPO

N01 17.5
E103 58.1
MAX

220 KT

At or above

203^

N01 13.4 E103 51.3

342^

SJ
SINJON

113.5 SJ
5

180^

For minimum climb gradient criteria:


Rwy 02C- See 10-3 and 10-3A.

AROSO 1B
At or above

2000'
D

SUSIN

N01 12.5 E103 58.1


MAX

7000'
SULUG

N01 15.6
E104 04.4
SAKIN

097^

026 4
^

Rwy 20C: Departures shall be on a


minimum net climb gradient of 5.0% until
reaching or passing 400'.
Gnd speed-KT 75 100 150 200 250 300
5.0% V/V(fpm) 380 506 760 1013 1266 1519

VTK
TEKONG

116.5 VTK

N01 24.9 E104 01.3

10

Direct distance from Changi Apt


(Rwy 02C) to: TOKIM 9 NM
(Rwy 20C) to: SUDPO 4 NM

023^

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

220 KT

N01 12.0
E104 02.6
MAX

220 KT

At or above

4000'

Initial climb clearance 3000' or as directed by ATC


INITIAL CLIMB
To TOKIM on course 023^, then to AKOMA.
To SUDPO on course 203^, then to SUSIN, SAKIN, SULUG, VTK, AKOMA.
ROUTING
At AKOMA to AKMET, AROSO.
SID
AROSO 1A
AROSO 1B

RWY
02C
20C

CHANGES: Airport elevation, lost comms.

| JEPPESEN, 2012, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN

22 NOV 13

CHANGI

.RNAV.SID.

10-3G

Trans level: FL130 Trans alt: 11000'


1. RADAR required. 2. 1 The restriction to cross SUNVA at or above 2000' is
applicable between 2301-1100 UTC. All departure aircraft on Runway 20R issued with
Apt Elev heading instructions by ATC shall also cross VTK 8 DME at or above 2000' between
2301-1100 UTC. If the altitude restriction cannot be complied with, the pilot-in22'
command of an aircraft departing on Runway 20R shall inform ATC during the time when
the aircraft commences taxiing to the holding point for departure. 3. All SIDs include
noise preferential routes. 4. Cruising levels will be issued after take-off by Singapore
RADAR.
180^

AROSO 1E (ARO1E), AROSO 1F (ARO1F) DEPARTURES


(RWYS 02L, 20R)

ARO 1E: MAX 220 KT UNTIL 4000'


KT UNTIL PASSING 10000'
ARO 1F: MAX 220 KT UNTIL SAKIN
KT UNTIL PASSING 10000'

1900'

2100'

360^

02L
250
20R
250

MSA VTK VOR

180^

SPEED: RWY
AND
RWY
AND

3400'

090^

3400'

AROSO

090^

AKMET

N02 08.8
E103 24.4

360^

N01 53.9
E103 43.7

24

MSA SJ VOR

At or above

11000'
LOST COMMS

LOST COMMS

AROSO 1E
At or above

7000'
1E
O
OS 1E)
AR (ARO

17

( 21

1F
SO
AROARO1F)

TOPOM

N01 29.9
E104 02.5

333

At or above

LOST

LOST COMMS

N01 45.4
E103 54.7

308
^

14

LOST COMMS

LOST COMMS

AKOMA

LOST COMMS

LOST COMMS

NOT TO SCALE

2000'

LOST COMMS

342^

SUNVA

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

N01 24.9 E104 01.3

7000'

203^

At or above

2000'

SJ
SINJON

113.5 SJ

N01 13.4 E103 51.3

SULUG

N01 15.6
E104 04.4

Rwy 20R: Departures shall be on a


minimum net climb gradient of 5.0% until
reaching or passing 400'.
Gnd speed-KT 75 100 150 200 250 300
5.0% V/V(fpm) 380 506 760 1013 1266 1519

342^

VTK
TEKONG

116.5 VTK

At or above

172^

For minimum climb gradient criteria:


Rwy 02L- See 10-3 and 10-3A.

220 KT

10

Direct distance from Changi Apt


(Rwy 02L) to: TOPOM 9 NM
(Rwy 20R) to: SUNVA 4 NM

MAX

023^

N01 17.9
E103 57.4

SAKIN

SUSIN

N01 12.5 E103 58.1


MAX

097^

026 4
^

LOST COMMS

1. Set transponder to Mode A/C code


7600.
2. Communications failure occurs
immediately after departure on:
Rwy 02L: Proceed straight ahead to
Nylon Holding Area (NHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure
procedure.
Rwy 20R: Proceed straight ahead to
Samko Holding Area (SHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure
procedure.

LOST COMMS

LOST COMMS

2100'

2500'

220 KT

N01 12.0
E104 02.6
MAX

220 KT

At or above

4000'

Initial climb clearance 3000' or as directed by ATC


INITIAL CLIMB
To TOPOM on course 023^, then to AKOMA.
To SUNVA on course 203^, then to SUSIN, SAKIN, SULUG, VTK, AKOMA.
ROUTING
At AKOMA to AKMET, AROSO.
SID
AROSO 1E
AROSO 1F

RWY
02L
20R

CHANGES: Airport elevation, lost comms.

| JEPPESEN, 2012, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN
CHANGI

.RNAV.SID.

10-3H

22 NOV 13

180^
3400'
2100'

SPEED: MAX 220 KT UNTIL PASSING 4000' AND


250 KT UNTIL PASSING 10000'

090^

1900'

2100'

2500'

360^

(RWYS 02C, 20C)

MSA VTK VOR

MSA SJ VOR

TOKIM

(SJ R-037/D20.1)
(VTK R-023/D5.0)

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

At or above

2000'

023^

For minimum climb gradient criteria:


Rwy 02C- See 10-3 and 10-3A.
Rwy 20C: Departures shall be on a
minimum net climb gradient of 5.0% until
reaching or passing 400'.
Gnd speed-KT 75 100 150 200 250 300
5.0% V/V(fpm) 380 506 760 1013 1266 1519
SID

RWY

BOG1A

02C

BOG1B

20C

188^

D23.4
LOST COMMS

DUNAL

N01 01.6
E103 58.1

LOST COMMS

Direct distance from Changi Apt


(Rwy 02C) to: TOKIM 9 NM
(Rwy 20C) to: SUDPO 4 NM

LOST COMMS

272^

LOST COMMS

6000'

or as directed
by ATC

D24
.

15

28

113^

N01 03.8
E104 13.3

4.2

13.

^D

10000'

DOBLU

At or below

D2

149

At or above

4000'

^
150

N01 02.5 E103 29.9

SUSIN

At or above

11

BOBAG ONE
BRAVO

(BOG1B)

(SJ R-243/D24.0)
(VTK R-235/D38.6)

N01 24.9 E104 01.3

N01 12.5
E103 58.1

BOBAG

.R.469.

195^

203^
5

N01 13.4 E103 51.3

D12.8

SJ

VTK
TEKONG

116.5 VTK

22

^
059
097^
D6.

SINJON

4000'

(B

180^

0
D8.

113.5 SJ

083^D9.4
.2
23
^
D
7
05

A
NE ALPH
BOBAG O
OG1A)

2000'

NOT TO SCALE

At or above

173^

N01 17.5
E103 58.1

N01 26.1
E104 10.7
9

(VTK R-203/D8.0)

At or above

DOKTA

115^

N01 29.6 E104 03.3

SUDPO

3400'

090^

360^

BOBAG ONE ALPHA (BOG1A),


BOBAG ONE BRAVO (BOG1B) DEPARTURES

180^

Trans level: FL130 Trans alt: 11000'


1. RADAR required. 2. Non-RNP-1/P-RNAV approved aircraft shall fly this as
a basic RNAV (B-RNAV) procedure
1 or EXPECT RADAR vectors from ATC.
3. 2 The restriction to cross SUDPO at or above 2000' is applicable between
2301-1100 UTC. All departure aircraft on Runway 20C issued with heading
Apt Elev instructions by ATC shall also cross VTK 8 DME at or above 2000' between 23011100 UTC. If the altitude restriction cannot be complied with, the pilot-in-command
22'
of an aircraft departing on Runway 20C shall inform ATC during the time when the
aircraft commences taxiing to the holding point for departure. 4. All SIDs include
noise preferential routes. 5. Cruising levels will be issued after take-off by
Singapore RADAR.

262^
LOST COMMS

LOST COMMS

LOST COMMS

1. Set transponder to Mode A/C code 7600.


2. Communications failure occurs
immediately after departure on:
Rwy 02C: Proceed straight ahead to Nylon
Holding Area (NHA) climbing to the last
assigned altitude. Thereafter refer to
10-1P pages for radio communications
failure procedure.
Rwy 20C: Proceed straight ahead to Samko
Holding Area (SHA) climbing to the last
assigned altitude. Thereafter refer to
10-1P pages for radio communications
failure procedure.
LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

Initial climb clearance 3000' or as directed by ATC


1 INITIAL CLIMB
Climb straight ahead to TOKIM, turn RIGHT and track 115^ to DOKTA.
turn RIGHT and track 173^ to DOBLU. Turn RIGHT and track 262^ to DUNAL,
then track 272^ to BOBAG and join ATS route R-469.
Climb straight ahead to SUDPO, turn LEFT and track 180^ to SUSIN.
Then track 180^ to DUNAL, turn RIGHT and track 272^ to BOBAG and join
ATS route R-469.

CHANGES: Airport elevation, lost comms.

| JEPPESEN, 2006, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN

10-3J
.RNAV.SID.
Trans level: FL130 Trans alt: 11000'
1. RADAR required. 2. Non-RNP-1/P-RNAV approved aircraft shall fly this as
a basic RNAV (B-RNAV) procedure
1 or EXPECT RADAR vectors from ATC.
3. 2 The restriction to cross SUNVA at or above 2000' is applicable between
Apt Elev 2301-1100 UTC. All departure aircraft on Runway 20R issued with heading
instructions by ATC shall also cross VTK 8 DME at or above 2000' between 230122'
1100 UTC. If the altitude restriction cannot be complied with, the pilot-in-command
of an aircraft departing on Runway 20R shall inform ATC during the time when the
aircraft commences taxiing to the holding point for departure. 4. All SIDs include
noise preferential routes. 5. Cruising levels will be issued after take-off by
Singapore RADAR.

CHANGI

180^
3400'
2100'

SPEED: MAX 220 KT UNTIL PASSING 4000' AND


250 KT UNTIL PASSING 10000'
A

TOPOM

(SJ R-034/D20.0)
(VTK R-013/D5.1)

023^

203^
272^
DUNAL

D12.8

188^

For minimum climb gradient criteria:


Rwy 02L- See 10-3 and 10-3A.

LOST COMMS

N01 01.6
E103 58.1

Rwy 20R: Departures shall be on a


minimum net climb gradient of 5.0% until
reaching or passing 400'.
Gnd speed-KT 75 100 150 200 250 300
5.0% V/V(fpm) 380 506 760 1013 1266 1519

LOST COMMS

Direct distance from Changi Apt


(Rwy 02L) to: TOPOM 9 NM
(Rwy 20R) to: SUNVA 4 NM

LOST COMMS

.R.469.

SID

RWY

BOG1E

02L

BOG1F

20R

LOST COMMS

N01 03.8
E104 13.3

6000'

or as directed
by ATC

D24
.

15

28

113^

DOBLU

4.2

13.

^D

10000'

NOT TO SCALE

At or below

D2

149

At or above

4000'

^
150

N01 02.5 E103 29.9

11

(BOG1F)

(SJ R-243/D24.0)
(VTK R-235/D38.6)

BOBAG ONE
FOXTROT

BOBAG

At or above

D23.4

6.9

N01 12.5
E103 58.1

22

N01 13.4 E103 51.3

N01 24.9 E104 01.3

(B

SJ

VTK
TEKONG

116.5 VTK

SUSIN

180^

^
053
097^
D

SINJON

113.5 SJ

172^

.6
D7

195^

2000'

173^

4000'

NE ECHO
BOBAG O
OG1E)

At or above

At or above

083^D9.4
.2
23
^
D
7
05

SUNVA

MSA SJ VOR

N01 26.1
E104 10.7

(VTK R-210/D8.0)

N01 17.9 E103 57.4

MSA VTK VOR

DOKTA

At or above

2000'

2100'

2500'

115^

N01 29.9 E104 02.5

090^

1900'

360^

(RWYS 02L, 20R)

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

3400'

090^

360^

BOBAG ONE ECHO (BOG1E),


BOBAG ONE FOXTROT (BOG1F) DEPARTURES

180^

22 NOV 13

LOST COMMS

262^

LOST COMMS

LOST COMMS

1. Set transponder to Mode A/C code 7600.


2. Communications failure occurs
immediately after departure on:
Rwy 02L: Proceed straight ahead to Nylon
Holding Area (NHA) climbing to the last
assigned altitude. Thereafter refer to
10-1P pages for radio communications
failure procedure.
Rwy 20R: Proceed straight ahead to Samko
Holding Area (SHA) climbing to the last
assigned altitude. Thereafter refer to
10-1P pages for radio communications
failure procedure.
LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

Initial climb clearance 3000' or as directed by ATC


1 INITIAL CLIMB
Climb straight ahead to TOPOM, turn RIGHT and track 115^ to DOKTA.
Turn RIGHT and track 173^ to DOBLU. Turn RIGHT and track 262^ to
DUNAL, then track 272^ to BOBAG and join ATS route R-469.
Climb straight ahead to SUNVA, turn LEFT and track 172^ to SUSIN.
Then track 180^ to DUNAL, then turn RIGHT and track 272^ to BOBAG and
join ATS route R-469.

CHANGES: Airport elevation, lost comms.

| JEPPESEN, 2006, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN

10-3K
.RNAV.SID.
Trans level: FL130 Trans alt: 11000'
1. RADAR required. 2. These SIDs will be assigned during air defense exercises.
3. Non-RNP-1/P-RNAV approved aircraft shall fly this as a basic RNAV (B-RNAV)
procedure 1 or EXPECT RADAR vectors from ATC. 4. 2 The restriction to cross
SUDPO or SUNVA at or above 2000' is applicable between 2301-1100 UTC. All
Apt Elev departure aircraft on Runways 20C/R issued with heading instructions by ATC
shall also cross VTK 8 DME at or above 2000' between 2301-1100 UTC. If the
22'
altitude restriction cannot be complied with, the pilot-in-command of an aircraft
departing on Runways 20C/R shall inform ATC during the time when the aircraft
commences taxiing to the holding point for departure. 5. All SIDs include noise
preferential routes. 6. Cruising levels will be issued after take-off by Singapore.
RADAR.

CHANGI

180^
3400'

090^
2100'

SPEED: MAX 220 KT UNTIL PASSING 4000' AND


250 KT UNTIL PASSING 10000'
ARAMA

(SJ R-298/D50.0)
(VTK R-282/D55.5)

VTK
TEKONG

BO
BA
VIC G ON
(BO TOR E

SUNVA

2031^V)

(VTK R-210/D8.0)

(VTK R-278/
D56.6)

A
SUDPO

(SJ R-059/D8.0)
(VTK R-203/D8.0)

N01 17.9
E103 57.4

At or above

203^

293
^

N01 33.1
E103 05.4

N01 17.5
E103 58.1

BOBAG ONE
X-RAY

N01 13.4 E103 51.3

At or above

2000'

(BOG1X)
5

113.5 SJ
SJ
SINJON

180^

D7
.6

172^

41 A

P
KO
RE 39

M
ARA

2000'

097^
D

SUSIN

(VTK R-195/D12.8)

N01 12.5
E103 58.1

BOBAG

At or above

SID
BOG1V
BOG1X

DUNAL

N01 01.6
E103 58.1

272^
LOST COMMS
LOST COMMS

Rwys 20C/R: Departures shall be on a


minimum net climb gradient of 5.0% until
reaching or passing 400'.
Gnd speed-KT 75 100 150 200 250 300
5.0% V/V(fpm) 380 506 760 1013 1266 1519

28

COMMS

Direct distance from Changi Apt


(Rwy 20C) to: SUDPO 4 NM
(Rwy 20R) to: SUNVA 4 NM

4000'

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

.
D13

327^
^
321

FL140

At or above

D23.4

N01 02.5 E103 29.9

11

NOT TO SCALE

149

(SJ R-243/D24.0)
(VTK R-235/D38.6)

188^

180^

6.9

MSA SJ VOR

N01 24.9 E104 01.3

N01 36.9 E103 07.2

REKOP

MSA VTK VOR

116.5 VTK

053

D5
0 .0

2100'

2500'

360^

(RWYS 20C/R)

3400'

090^

1900'

360^

BOBAG ONE VICTOR (BOG1V),


BOBAG ONE X-RAY (BOG1X) DEPARTURES

180^

22 NOV 13

LOST COMMS

LOST COMMS

LOST COMMS

LOST

1. Set transponder to Mode A/C code 7600.


2. Communications failure occurs immediately
after departure on:
Rwys 20C/R: Proceed straight ahead to
Samko Holding Area (SHA) climbing to the
last assigned altitude. Thereafter refer to
10-1P pages for radio communications
failure procedure.

LOST

LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

Initial climb clearance 3000' or as directed by ATC


RWY
1 INITIAL CLIMB
20R
20C

Climb straight ahead to SUNVA, turn LEFT and track 172^ to SUSIN.
Climb straight ahead to SUDPO, turn LEFT and track 180^ to SUSIN.
1 ROUTING
At SUSIN track 180^ to DUNAL, then turn RIGHT and track 272^ to BOBAG. From BOBAG
follow the appropriate transition route to join the ATS route.
CHANGES: Airport elevation, lost comms.

| JEPPESEN, 2008, 2013. ALL RIGHTS RESERVED.

JEPPESEN

WSSS/SIN
CHANGI

22'

.SID.

10-3L

Trans level: FL130 Trans alt: 11000'


1. This SID will be assigned during air defense exercises.
2. All SIDs include noise preferential routes.
3. Cruising levels will be issued after take-off by Singapore
RADAR.

180^

Apt Elev

22 NOV 13

SINGAPORE, SINGAPORE
3400'

090^

1900'

2100'

360^

LELIB ONE CHARLIE (LLB1C) DEPARTURE


(RWYS 02L/C)

MSA VTK VOR

SPEED: MAX 220 KT UNTIL PASSING 4000' AND


250 KT UNTIL PASSING 10000'

NYLON

N01 37.0
E104 06.4

FL140
MAINTAIN
FL140
At

NOT TO SCALE

to LELIB

Passing

10000'

JB
400 JB

JAYBEE

KONG KONG

N01 30.0 E103 42.7

N01 31.3 E103 59.4

LELIB

285^

D13

023^
001^

D 19

D19

FL140

266^

343^

64.

17
FL140

262^

D7

.A.4
18

KK

286 KK

N01 27.5
E103 24.8

332^

VTK
TEKONG

116.5 VTK

N01 24.9 E104 01.3

SJ
SINJON

113.5 SJ

N01 13.4 E103 51.3

A
Changi EAST Rwy 02R/20L
is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

Direct distance from Changi Apt to:


(Rwy 02C) to: VTK 4 NM

For minimum climb gradient criteria:


Rwys 02L/C- See 10-3 and 10-3A.

Initial climb clearance 3000' or as directed by ATC


RWY
02L
02C

INITIAL CLIMB

Climb straight ahead.


Climb straight ahead to VTK.

ROUTING
Intercept and proceed on VTK R-001. After passing 10000', turn RIGHT to NYLON. At NYLON,
turn RIGHT and proceed direct to KK. Track 266^ bearing from KK to JB. Track 262^ bearing
from JB to LELIB and join airway A-464. MAINTAIN FL140 from NYLON to LELIB
CHANGES: Airport elevation.

| JEPPESEN, 2004, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN

22 NOV 13

CHANGI

.RNAV.SID.

10-3M

Trans level: FL130 Trans alt: 11000'


1. RADAR required. 2. 1 The restriction to cross SUDPO at or above 2000' is
applicable between 2301-1100 UTC. All departure aircraft on Runway 20C issued with
Apt Elev heading instructions by ATC shall also cross VTK 8 DME at or above 2000' between
2301-1100 UTC. If the altitude restriction cannot be complied with, the pilot-in22'
command of an aircraft departing on Runway 20C shall inform ATC during the time
when the aircraft commences taxiing to the holding point for departure. 3. All SIDs
include noise preferential routes. 4. Cruising levels will be issued after take-off by
Singapore RADAR.
180^

MASBO 1A (MAS1A), MASBO 1B (MAS1B) DEPARTURES


(RWYS 02C, 20C)

02C MAS 1A: MAX 220 KT UNTIL 4000'


250 KT UNTIL PASSING 10000'
20C MAS 1B: MAX 220 KT UNTIL SAKIN
250 KT UNTIL PASSING 10000'

1900'

360^

2100'

MSA VTK VOR

180^

SPEED: RWY
AND
RWY
AND

3400'

090^

3400'

090^

N02 02.8
E102 52.9

NOT TO SCALE

At or above

296
^
SABKA

LOST COMMS

At or above

13

7000'

LOST COMMS

1A
O
SB S1A)
MA(MA 17
At or above

N01 17.5
E103 58.1
MAX

220 KT

At or above

2000'
D

MASBO 1B

203^

At or above

N01 13.4 E103 51.3

342^

SJ
SINJON

113.5 SJ

10

097^
SUSIN

N01 12.5 E103 58.1


MAX

7000'
SULUG

N01 15.6
E104 04.4
SAKIN

026 4
^

Rwy 20C: Departures shall be on a


minimum net climb gradient of 5.0% until
reaching or passing 400'.
Gnd speed-KT 75 100 150 200 250 300
5.0% V/V(fpm) 380 506 760 1013 1266 1519

VTK
TEKONG

116.5 VTK

N01 24.9 E104 01.3

2000'

180^

For minimum climb gradient criteria:


Rwy 02C- See 10-3 and 10-3A.

N01 29.6
E104 03.3

342^

LOST COMMS

SUDPO

LOST COMMS

Direct distance from Changi Apt


(Rwy 02C) to: TOKIM 9 NM
(Rwy 20C) to: SUDPO 4 NM

TOKIM

332

LOST COMMS

( 21

1B
SBO
MAMAS1B)

LOST COMMS

LOST COMMS

MASBO 1A

278^

25

1. Set transponder to Mode A/C code


7600.
2. Communications failure occurs
immediately after departure on:
Rwy 02C: Proceed straight ahead to
Nylon Holding Area (NHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure
procedure.
Rwy 20C: Proceed straight ahead to
Samko Holding Area (SHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure
procedure.
LOST COMMS

N01 45.4
E103 54.7

023^

LOST COMMS

AKOMA

11000'

N01 50.9
E103 17.2

LOST COMMS

MSA SJ VOR

AGVAR

N01 47.3
E103 41.8
27

LOST COMMS

360^

MASBO

2100'

2500'

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

220 KT

N01 12.0
E104 02.6
MAX

220 KT

At or above

4000'

Initial climb clearance 3000' or as depicted by ATC


SID
MASBO 1A
MASBO 1B

RWY
02C
20C

INITIAL CLIMB
To TOKIM on course 023^, then to AKOMA.
To SUDPO on course 203^, then to SUSIN, SAKIN, SULUG, VTK, AKOMA.
ROUTING
At AKOMA to AGVAR, SABKA, MASBO.
CHANGES: Airport elevation, lost comms.

| JEPPESEN, 2012, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN
CHANGI

.RNAV.SID.

10-3N

22 NOV 13

Trans level: FL130 Trans alt: 11000'


1. RADAR required. 2. 1 The restriction to cross SUNVA at or above 2000' is
applicable between 2301-1100 UTC. All departure aircraft on Runway 20R issued with
Apt Elev heading instructions by ATC shall also cross VTK 8 DME at or above 2000' between
2301-1100 UTC. If the altitude restriction cannot be complied with, the pilot-in22'
command of an aircraft departing on Runway 20R shall inform ATC during the time
when the aircraft commences taxiing to the holding point for departure. 3. All SIDs
include noise preferential routes. 4. Cruising levels will be issued after take-off by
Singapore RADAR.
180^

MASBO 1E (MAS1E), MASBO 1F (MAS1F) DEPARTURES


(RWYS 02L, 20R)

MAS 1E: MAX 220 KT UNTIL 4000'


KT UNTIL PASSING 10000'
MAS 1F: MAX 220 KT UNTIL SAKIN
KT UNTIL PASSING 10000'

1900'

2100'

360^

02L
250
20R
250

MSA VTK VOR

180^

SPEED: RWY
AND
RWY
AND

3400'

090^

3400'

090^

A
N02 02.8
E102 52.9

NOT TO SCALE

At or above

296
^
SABKA

13

7000'

17

( 21

1F
SBO
MAMAS1F)

TOPOM

N01 29.9
E104 02.5

333

At or above

LOST COMMS

SUNVA

MAX

023^

N01 17.9
E103 57.4

LOST COMMS

2000'

342^

LOST COMMS

LOST COMMS

At or above

LOST COMMS

1. Set transponder to Mode A/C code


7600.
2. Communications failure occurs
immediately after departure on:
Rwy 02L: Proceed straight ahead to
Nylon Holding Area (NHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure procedure.
Rwy 20R: Proceed straight ahead to
Samko Holding Area (SHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure procedure.
LOST COMMS

MASBO 1E

278^

25

1E
O
SB S1E)
MA(MA

LOST COMMS

N01 45.4
E103 54.7

LOST COMMS

LOST COMMS

AKOMA

11000'

N01 50.9
E103 17.2

LOST COMMS

MSA SJ VOR

AGVAR

N01 47.3
E103 41.8
27

LOST COMMS

360^

MASBO

220 KT

At or above

10

N01 13.4 E103 51.3

SULUG

N01 15.6
E104 04.4

5
SAKIN

SUSIN

N01 12.5 E103 58.1


MAX

097^

026 4
^

Rwy 20R: Departures shall be on a


minimum net climb gradient of 5.0% until
reaching or passing 400'.
Gnd speed-KT 75 100 150 200 250 300
5.0% V/V(fpm) 380 506 760 1013 1266 1519

342^

SINJON

113.5 SJ
172^

For minimum climb gradient criteria:


Rwy 02L- See 10-3 and 10-3A.

SJ

7000'

203^

2000'
D

VTK
TEKONG

116.5 VTK

N01 24.9 E104 01.3

At or above
Direct distance from Changi Apt
(Rwy 02L) to: TOPOM 9 NM
(Rwy 20R) to: SUNVA 4 NM

2100'

2500'

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

220 KT

N01 12.0
E104 02.6
MAX

220 KT

At or above

4000'

Initial climb clearance 3000' or as directed by ATC


SID
MASBO 1E
MASBO 1F

RWY
02L
20R

INITIAL CLIMB
To TOPOM on course 023^, then to AKOMA.
To SUNVA on course 203^, then to SUSIN, SAKIN, SULUG, VTK, AKOMA.
ROUTING
At AKOMA to AGVAR, SABKA, MASBO.
CHANGES: Airport elevation, lost comms.

| JEPPESEN, 2012, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN
CHANGI

22 NOV 13

.RNAV.SID.

10-3P

MERSING 4A (VMR4A), MERSING 5B (VMR5B) DEPARTURES


(RWYS 02C, 20C)

3400'

090^

1900'

2100'

360^

02C VMR 4A: MAX 220 KT UNTIL 4000'


250 KT UNTIL PASSING 10000'
20C VMR 5B: MAX 220 KT UNTIL SAKIN
250 KT UNTIL PASSING 10000'

MSA VTK VOR

180^

SPEED: RWY
AND
RWY
AND

180^

Trans level: FL130 Trans alt: 11000'


1. RADAR required. 2. 1 The restriction to cross SUDPO at or above 2000' is
applicable between 2301-1100 UTC. All departure aircraft on Runway 20C issued with
Apt Elev heading instructions by ATC shall also cross VTK 8 DME at or above 2000' between
2301-1100 UTC. If the altitude restriction cannot be complied with, the pilot-in22'
command of an aircraft departing on Runway 20C shall inform ATC during the time
when the aircraft commences taxiing to the holding point for departure. 3. All SIDs
include noise preferential routes. 4. Cruising levels will be issued after take-off by
Singapore RADAR. 5. MERSING 4A will also be assigned during air defense exercises.

3400'

090^

VMR
MERSING

AKOMA

N01 45.4
E103 54.7

38

356^

116.8 VMR

N02 23.3 E103 52.3

360^

2100'

2500'

MSA SJ VOR

MERSING 4A

NOT TO SCALE

At or above

7000'
LOST COMMS

LOST COMMS

ME

(V

4A
ING )
RS MR4A

( 21

N01 29.6
E104 03.3

332

At or above

SUDPO

N01 17.5
E103 58.1
MAX

At or above

203^

180^

SULUG

N01 15.6
E104 04.4

Direct distance from Changi Apt


(Rwy 02C) to: TOKIM 9 NM
(Rwy 20C) to: SUDPO 4 NM

7000'

342^

N01 13.4 E103 51.3

Rwy 20C: Departures shall be on a


minimum net climb gradient of 5.0% until
reaching or passing 400'.
Gnd speed-KT 75 100 150 200 250 300
5.0% V/V(fpm) 380 506 760 1013 1266 1519

MERSING 5B

2000'

SINJON

For minimum climb gradient criteria:


Rwy 02C- See 10-3 and 10-3A.

VTK
TEKONG

116.5 VTK

N01 24.9 E104 01.3

10

113.5 SJ
SJ

2000'
D

220 KT

At or above

TOKIM

342^

LOST COMMS

17
5B
SING
MERVMR5B)

LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

1. Set transponder to Mode A/C code


7600.
2. Communications failure occurs
immediately after departure on:
Rwy 02C: Proceed straight ahead to
Nylon Holding Area (NHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure procedure.
Rwy 20C: Proceed straight ahead to
Samko Holding Area (SHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure procedure.

097^
SUSIN

026 4
^

LOST COMMS

023^

LOST COMMS

N01 12.5 E103 58.1


MAX

220 KT

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

SAKIN

N01 12.0
E104 02.6
MAX

220 KT

At or above

4000'

Initial climb clearance 3000' or as directed by ATC


SID
VMR4A
VMR5B

RWY
02C
20C

INITIAL CLIMB
To TOKIM on course 023^, then to AKOMA.
To SUDPO on course 203^, then to SUSIN, SAKIN, SULUG, VTK, AKOMA.
ROUTING

At AKOMA to VMR.
CHANGES: Airport elevation, lost comms.

| JEPPESEN, 2006, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN
CHANGI

.RNAV.SID.

10-3Q

22 NOV 13

MERSING 4E (VMR4E), MERSING 5F (VMR5F) DEPARTURES


(RWYS 02L, 20R)

VMR 4E: MAX 220 KT UNTIL 4000'


KT UNTIL PASSING 10000'
VMR 5F: MAX 220 KT UNTIL SAKIN
KT UNTIL PASSING 10000'

2100'

1900'

360^

02L
250
20R
250

3400'

090^

MSA VTK VOR

180^

SPEED: RWY
AND
RWY
AND

180^

Trans level: FL130 Trans alt: 11000'


1. RADAR required. 2. 1 The restriction to cross SUNVA at or above 2000' is
applicable between 2301-1100 UTC. All departure aircraft on Runway 20R issued with
Apt Elev heading instructions by ATC shall also cross VTK 8 DME at or above 2000' between
2301-1100 UTC. If the altitude restriction cannot be complied with, the pilot-in22'
command of an aircraft departing on Runway 20R shall inform ATC during the time
when the aircraft commences taxiing to the holding point for departure. 3. All SIDs
include noise preferential routes. 4. Cruising levels will be issued after take-off by
Singapore RADAR. 5. MERSING 4E will also be assigned during air defense exercises.

3400'

116.8 VMR
VMR
MERSING

2500'

AKOMA

38

MERSING 4E

NOT TO SCALE

LOST COMMS

At or above

LOST COMMS

4E
ING )
RS R4E
7
ME (VM
1
5F
SING )
MER(VMR5F

N01 29.9
E104 02.5
At or above

^
333

2000'

SUNVA

N01 17.9
E103 57.4
MAX

342^

LOST COMMS

TOPOM

21

LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

1. Set transponder to Mode A/C code


7600.
2. Communications failure occurs
immediately after departure on:
Rwy 02L: Proceed straight ahead to
Nylon Holding Area (NHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure procedure.
Rwy 20R: Proceed straight ahead to
Samko Holding Area (SHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure procedure.
LOST COMMS

7000'

LOST COMMS

220 KT

VTK
TEKONG

116.5 VTK

N01 24.9 E104 01.3

023^

LOST COMMS

MSA SJ VOR

N01 45.4
E103 54.7

356^

N02 23.3 E103 52.3

2100'

360^

090^

At or above

7000'

At or above

N01 13.4 E103 51.3

172^

097^

For minimum climb gradient criteria:


Rwy 02L- See 10-3 and 10-3A.

SUSIN

Rwy 20R: Departures shall be on a


minimum net climb gradient of 5.0% until
reaching or passing 400'.
Gnd speed-KT 75 100 150 200 250 300
5.0% V/V(fpm) 380 506 760 1013 1266 1519

SULUG

N01 15.6
E104 04.4

Direct distance from Changi Apt


(Rwy 02L) to: TOPOM 9 NM
(Rwy 20R) to: SUNVA 4 NM

SAKIN

N01 12.0
E104 02.6
MAX

N01 12.5 E103 58.1


MAX

0264
^

113.5 SJ
SJ

203^

2000'

SINJON

342^

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

10

220 KT

220 KT

At or above

4000'

Initial climb clearance 3000'


SID
VMR4E
VMR5F

RWY
02L
20R

or as directed by ATC
INITIAL CLIMB
To TOPOM on course 023^, then to AKOMA.
To SUNVA on course 203^, then to SUSIN, SAKIN, SULUG, VTK, AKOMA.
ROUTING

At AKOMA to VMR.
CHANGES: Airport elevation, lost comms.

| JEPPESEN, 2006, 2013. ALL RIGHTS RESERVED.

CHANGI

22'

22 NOV 13

.SID.

10-3S

Trans level: FL130 Trans alt: 11000'


1. This SID will be assigned during air defense exercises.
2. All SIDs include noise preferential routes.
3. Cruising levels will be issued after take-off by Singapore
RADAR.

180^

Apt Elev

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN

3400'

090^

1900'

2100'

360^

PIMOK ONE CHARLIE (PMK1C) DEPARTURE


(RWYS 02L/C)

MSA VTK VOR

SPEED: MAX 220 KT UNTIL PASSING 4000'


AND 250 KT UNTIL PASSING 10000'
NYLON

N01 36.9
E104 06.4

FL140
MAINTAIN
FL140
At

NOT TO SCALE

to PIMOK

Passing

10000'

JB
JAYBEE

KK

400 JB

286 KK

N01 30.0 E103 42.7

285^

023^

266^

001^

D19

D 19

17
FL140

343^

76.
PIMOK

N01 31.3 E103 59.4


D7

.A.5
23
FL140

262^

D13

KONG KONG

N01 26.8
E103 20.1

332^

VTK
TEKONG

116.5 VTK

N01 24.9 E104 01.3

SJ
SINJON

113.5 SJ

N01 13.4 E103 51.3

A
Changi EAST Rwy 02R/20L
is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

Direct distance from Changi Apt to:


(Rwy 02C) to: VTK 4 NM

For minimum climb gradient criteria:


Rwys 02L/C- See 10-3 and 10-3A.

Initial climb clearance 3000' or as directed by ATC


RWY
02L
02C

INITIAL CLIMB

Climb straight ahead.


Climb straight ahead to VTK.

ROUTING
Intercept and proceed on VTK R-001. After passing 10000', turn RIGHT to NYLON. At NYLON,
turn RIGHT and proceed direct to KK. Track 266^ bearing from KK to JB. Track 262^ bearing
from JB to PIMOK and join airway A-576. MAINTAIN FL140 from NYLON to PIMOK.
CHANGES: Airport elevation.

| JEPPESEN, 2004, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN
CHANGI

22 NOV 13

.RNAV.SID.

10-3T

180^
3400'

(RWYS 02C, 20C)

2100'

SPEED: MAX 220 KT UNTIL PASSING


4000' AND 250 KT UNTIL
PASSING 10000'

TOKIM

N01 29.6 E104 03.3

2000'

4000'

N01 24.9 E104 01.3

^
150

17

D2

N01 12.5
E103 58.1

4.2

At or above

4000'

Direct distance from Changi Apt


(Rwy 02C) to: TOKIM 9 NM
(Rwy 20C) to: SUDPO 4 NM

NOT TO SCALE

For minimum climb gradient criteria:


Rwy 02C- See 10-3 and 10-3A.
Rwy 20C: Departures shall be on a
minimum net climb gradient of 5.0% until
reaching or passing 400'.
Gnd speed-KT 75 100 150 200 250 300
5.0% V/V(fpm) 380 506 760 1013 1266 1519
SID

RWY

TOM1A

02C

TOM1B

20C

TOMAN

N01 21.8 E105 47.3

DOBLU

(SJ R-113/D24.0)

N01 03.8 E104 13.3


At or below 6000'
or as directed by ATC

LOST

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

83

(SJ R-086/D117)
(VTK R-092/D106)

(TO ONE
M B
20 1B) RAV

SUSIN

N01 13.4 E103 51.3

D33.7

079^

089^

TO
MA
N

120

D23.6

D12.8

^
059
097^
D6.

VTK
TEKONG

116.5 VTK

7000'

LOST COMMS

LOST COMMS

LOST COMMS

LOST

1. Set transponder to Mode A/C code


7600.
2. Communications failure occurs
immediately after departure on:
Rwy 02C: Proceed straight ahead to
Nylon Holding Area (NHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure
procedure.
Rwy 20C: Proceed straight ahead to
Samko Holding Area (SHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure
procedure.

LOST COMMS

180^

0
D8.

At or above

LOST COMMS

2000'

203^
195^

At or above

103^

N
(TOO
M1AE ALP
HA
15 )

N01 19.8
E104 24.3

COMMS

N01 17.5
E103 58.1

AN

035

(VTK R-203/D8.0)

HOSBA
TO
M

083^ D9.4
3 .2
^
D2
7
05

023^

SUDPO

SJ

MSA SJ VOR

At or above

SINJON

MSA VTK VOR

2100'

N01 26.1
E104 10.7

115^

At or above

113.5 SJ

2500'

DOKTA

(SJ R-037/D20.1)
(VTK R-023/D5.0)

3400'

090^

1900'

360^

090^

360^

TOMAN ONE ALPHA (TOM1A),


TOMAN ONE BRAVO (TOM1B) DEPARTURES

180^

Trans level: FL130 Trans alt: 11000'


1. RADAR required. 2. Non-RNP-1/P-RNAV approved aircraft shall fly this as
a basic RNAV (B-RNAV) procedure
1 or EXPECT RADAR vectors from ATC.
3. 2 The restriction to cross SUDPO at or above 2000' is applicable between
Apt Elev 2301-1100 UTC. All departure aircraft on Runway 20C issued with heading
instructions by ATC shall also cross VTK 8 DME at or above 2000' between 230122'
1100 UTC. If the altitude restriction cannot be complied with, the pilot-in-command
of an aircraft departing on Runway 20C shall inform ATC during the time when the
aircraft commences taxiing to the holding point for departure. 4. All SIDs include
noise preferential routes. 5. Cruising levels will be issued after take-off by
Singapore RADAR.

LOST COMMS

LOST COMMS

LOST COMMS

LOST

Initial climb clearance 3000' or as directed by ATC


1 INITIAL CLIMB
Climb straight ahead to TOKIM, turn RIGHT and track 115^ to DOKTA,
then track 115^ to HOSBA. Turn LEFT and track 089^ to TOMAN.
Climb straight ahead to SUDPO, turn LEFT and track 180^ to SUSIN.
Turn LEFT and track 120^ to DOBLU. Turn LEFT and track 035^ to HOSBA,
then turn RIGHT and track 089^ to TOMAN.

CHANGES: Airport elevation, lost comms.

| JEPPESEN, 2006, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN
CHANGI

22 NOV 13

.RNAV.SID.

10-3U

180^
3400'

090^

(RWYS 02L, 20R)

TOPOM

023^

N01 17.9
E103 57.4

195^

VTK
TEKONG

N01 24.9 E104 01.3

TOM1F

20R

DOBLU

LOST

LOST COMMS

LOST COMMS

LOST COMMS

LOST COMMS

1. Set transponder to Mode A/C code


7600.
2. Communications failure occurs
immediately after departure on:
Rwy 02L: Proceed straight ahead to
Nylon Holding Area (NHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure
procedure.
Rwy 20R: Proceed straight ahead to
Samko Holding Area (SHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure
procedure.

LOST COMMS

NOT TO SCALE

Rwy 20R: Departures shall be on a


minimum net climb gradient of 5.0% until
reaching or passing 400'.
Gnd speed-KT 75 100 150 200 250 300
5.0% V/V(fpm) 380 506 760 1013 1266 1519

02L

N01 21.8 E105 47.3

At or below 6000'
or as directed by ATC

COMMS

For minimum climb gradient criteria:


Rwy 02L- See 10-3 and 10-3A.

TOM1E

TOMAN

(SJ R-086/D117)
(VTK R-092/D106)

N01 03.8 E104 13.3

4.2

A
Changi EAST Rwy 02R/20L
is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

RWY

83

(SJ R-113/D24.0)

4000'

SID

TO
MA
N

17

At or above

Direct distance from Changi Apt


(Rwy 02L) to: TOPOM 9 NM
(Rwy 20R) to: SUNVA 4 NM

089^

N01 12.5
E103 58.1

7000'

D33.7

079^

LOST

120

At or above

D23.6

D2

N01 13.4 E103 51.3

103^

116.5 VTK

SUSIN

113.5 SJ

(TOMONE E
1 C
1 5 E) H O

D12.8

AN

OT

203^

N01 19.8
E104 24.3

TO
M

^
150

SJ
SINJON

172^

^
053
D6.9
097^

HOSBA

083^D9.4
.2
^
23
D
7
05

(VTK R-210/D8.0)

4000'

035

SUNVA

.6

MSA SJ VOR

At or above

2000'

D7

MSA VTK VOR

(TO NE
M FO
20 1F) XTR

At or above

2000'

2500'

N01 26.1
E104 10.7

115^

N01 29.9 E104 02.5

2100'

2100'

DOKTA

(SJ R-034/D20.0)
(VTK R-013/D5.1)

At or above

090^

360^

SPEED: MAX 220 KT UNTIL PASSING


4000' AND 250 KT UNTIL
PASSING 10000'

3400'
1900'

360^

TOMAN ONE ECHO (TOM1E),


TOMAN ONE FOXTROT (TOM1F) DEPARTURES

180^

Trans level: FL130 Trans alt: 11000'


1. RADAR required. 2. Non-RNP-1/P-RNAV approved aircraft shall fly this as
a basic RNAV (B-RNAV) procedure
1 or EXPECT RADAR vectors from ATC.
3. 2 The restriction to cross SUNVA at or above 2000' is applicable between
Apt Elev 2301-1100 UTC. All departure aircraft on Runway 20R issued with heading
instructions by ATC shall also cross VTK 8 DME at or above 2000' between 230122'
1100 UTC. If the altitude restriction cannot be complied with, the pilot-in-command
of an aircraft departing on Runway 20R shall inform ATC during the time when the
aircraft commences taxiing to the holding point for departure. 4. All SIDs include
noise preferential routes. 5. Cruising levels will be issued after take-off by
Singapore RADAR.

LOST COMMS

LOST COMMS

LOST COMMS

LOST

Initial climb clearance 3000' or as directed by ATC


1 INITIAL CLIMB
Climb straight ahead to TOPOM, turn RIGHT and track 115^ to DOKTA,
then track 115^ to HOSBA. Turn LEFT and track 089^ to TOMAN.
Climb straight ahead to SUNVA, turn LEFT and track 172^ to SUSIN.
Turn LEFT and track 120^ to DOBLU. Turn LEFT and track 035^ to HOSBA,
then turn RIGHT and track 089^ to TOMAN.

CHANGES: Airport elevation, lost comms.

| JEPPESEN, 2006, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN
CHANGI

.RNAV.SID.

10-3V

22 NOV 13

180^
3400'

090^

SPEED: MAX 220 KT UNTIL PASSING 4000' AND


250 KT UNTIL PASSING 10000'
TOKIM

VE
NP
A

(VENONE B
PA RA
17 1B) VO

SUSIN

LOST COMMS

N01 12.5
E103 58.1
At or above

LOST COMMS

(SJ R-138/D34.1)
(VTK R-161/D39.0)

N00 48.0 E104 14.2

6000'

or as directed
by ATC
(SJ R-110/D201)
(VTK R-114/D196)

126
44

N00 05.2 E106 59.8

097^
VENPA 120 87
^
(SJ R-131/D78.1)

(VTK R-142/D79.6)

Rwy 20C- Departures shall be on a


minimum net climb gradient of 5.0% until
reaching or passing 400'.
Gnd speed-KT 75 100 150 200 250 300
5.0% V/V(fpm) 380 506 760 1013 1266 1519

121 TO BAVUS
N00 00.0 E109 00.0

At or below

16

177^
DOSNO

For minimum climb gradient criteria:


Rwy 02C- See 10-3 and 10-3A.

N01 03.8 E104 13.3

ATKAX

NOT TO SCALE

Direct distance from Changi Apt


(Rwy 02C) to: TOKIM 9 NM
(Rwy 20C) to: SUDPO 4 NM

RWY

LOST

(SJ R-113/D24.0)

SID
VENPA1A

LOST COMMS

DOBLU

4000'
Changi EAST Rwy 02R/20L
is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

LOST COMMS

LOST COMMS

22

120
^

LOST COMMS

LOST

D12.8

203^
195^

VTK

N01 24.9 E104 01.3

.
D24

N01 13.4 E103 51.3

05
D
116.5 VTK

LOST COMMS

1. Set transponder to Mode A/C code


7600.
2. Communications failure occurs
immediately after departure on:
Rwy 02C: Proceed straight ahead to
Nylon Holding Area (NHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure
procedure.
Rwy 20C: Proceed straight ahead to
Samko Holding Area (SHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure
procedure.

113.5 SJ
SJ
SINJON

COMMS

TEKONG

150

D9.4
.2
23
D
^
7

PHA
VENPA ONE AL

6.9

4000'

(VENPA1A)

180^

^
0598.0
D
097^
D

MSA SJ VOR

At or above

083^

023^

SUDPO

(VTK R-203/D8.0)

173^

2000'

2000'

MSA VTK VOR

N01 26.1
E104 10.7

LOST

At or above

2500'

LOST COMMS

115^

N01 29.6 E104 03.3

At or above

2100'

2100'

DOKTA

(SJ R-037/D20.1)
(VTK R-023/D5.0)

N01 17.5
E103 58.1

090^

360^

(RWYS 02C, 20C)

3400'
1900'

360^

VENPA ONE ALPHA (VENPA1A),


VENPA ONE BRAVO (VENPA1B) DEPARTURES

180^

Trans level: FL130 Trans alt: 11000'


1. RADAR required. 2. Non-RNP-1/P-RNAV approved aircraft shall fly this as
a basic RNAV (B-RNAV) procedure 1 or EXPECT RADAR vectors from ATC.
3. 2 The restriction to cross SUDPO at or above 2000' is applicable between
Apt Elev 2301-1100 UTC. All departure aircraft on Runway 20C issued with heading
instructions by ATC shall also cross VTK 8 DME at or above 2000' between 230122'
1100 UTC. If the altitude restriction cannot be complied with, the pilot-in-command
of an aircraft departing on Runway 20C shall inform ATC during the time when the
aircraft commences taxiing to the holding point for departure. 4. All SIDs include
noise preferential routes. 5. Cruising levels will be issued after take-off by
Singapore RADAR.

N00 21.7 E104 49.9

VENIX

(SJ R-125/D164)
(VTK R-131/D164)

SU

30

3
BAVUS

131
RG
A

S00 21.9 E106 05.4 SURGA


(SJ R-124/D194)
(VTK R-129/D193)

092^
105^
KA

DA
46 R

KADAR

S00 06.8
E107 43.7

S00 37.0 E106 31.3

Initial climb clearance 3000' or as directed by ATC


1 INITIAL CLIMB

Climb straight ahead to TOKIM, turn RIGHT and track 115^ to DOKTA.
Turn RIGHT and track 173^ to DOBLU, then track 177^ to DOSNO.
VENPA1B
Climb straight ahead to SUDPO, turn LEFT and track 180^ to SUSIN. Turn
20C
[VENP1B]
LEFT and track 120^ to DOBLU, then turn RIGHT and track 177^ to DOSNO.
1 ROUTING
At DOSNO turn LEFT and track 126^ to VENPA and follow the appropriate transition route to
join the ATS route.
[VENP1A]

02C

CHANGES: Airport elevation, lost comms.

| JEPPESEN, 2006, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN
CHANGI

.RNAV.SID.

10-3W

22 NOV 13

180^

VENPA ONE ECHO (VENPA1E),


VENPA ONE FOXTROT (VENPA1F) DEPARTURES

180^

Trans level: FL130 Trans alt: 11000'


1. RADAR required. 2. Non-RNP-1/P-RNAV approved aircraft shall fly this as
a basic RNAV (B-RNAV) procedure
1 or EXPECT RADAR vectors from ATC.
3. 2 The restriction to cross SUNVA at or above 2000' is applicable between
Apt Elev 2301-1100 UTC. All departure aircraft on Runway 20R issued with heading
instructions by ATC shall also cross VTK 8 DME at or above 2000' between 230122'
1100 UTC. If the altitude restriction cannot be complied with, the pilot-in-command
of an aircraft departing on Runway 20R shall inform ATC during the time when the
aircraft commences taxiing to the holding point for departure. 4. All SIDs include
noise preferential routes. 5. Cruising levels will be issued after take-off by
Singapore RADAR.
3400'

090^

SPEED: MAX 220 KT UNTIL PASSING 4000' AND


250 KT UNTIL PASSING 10000'

2100'

2500'

360^

2100'

090^

360^

(RWYS 02L, 20R)

3400'
1900'

MSA VTK VOR

MSA SJ VOR

DOKTA

115^

057

203^

N01 17.9
E103 57.4

LOST COMMS

N01 12.5
E103 58.1

(VENNE FO
PA1 XT
17 F) ROT

.
D24

SUSIN

113.5 SJ
SJ

VE
NP
A

22

120
^

SINJON

N01 13.4 E103 51.3

150

^
053
D6.9
097^

172^

7.6

D12.8

2000'

VTK

N01 24.9 E104 01.3

LOST COMMS

6000'

or as directed
by ATC

ATKAX

DOSNO

(SJ R-138/D34.1)
(VTK R-161/D39.0)

N00 48.0 E104 14.2

(SJ R-110/D201)
(VTK R-114/D196)

126
44

N00 05.2 E106 59.8

097^
VENPA 120 87
^
(SJ R-131/D78.1)

(VTK R-142/D79.6)

Rwy 20R: Departures shall be on a


minimum net climb gradient of 5.0% until
reaching or passing 400'.
Gnd speed-KT 75 100 150 200 250 300
5.0% V/V(fpm) 380 506 760 1013 1266 1519
SID
VENPA1E

RWY

121 TO BAVUS
N00 00.0 E109 00.0

At or below

NOT TO SCALE

For minimum climb gradient criteria:


Rwy 02L- See 10-3 and 10-3A.

LOST

N01 03.8 E104 13.3


16

177^

LOST COMMS

LOST COMMS

(SJ R-113/D24.0)

4000'

Direct distance from Changi Apt


(Rwy 02L) to: TOPOM 9 NM
(Rwy 20R) to: SUNVA 4 NM

LOST COMMS

DOBLU

At or above

Changi EAST Rwy 02R/20L


is solely for use by the
Republic of Singapore
Air Force (RSAF) Aircraft

LOST COMMS

1. Set transponder to Mode A/C code


7600.
2. Communications failure occurs
immediately after departure on:
Rwy 02L: Proceed straight ahead to
Nylon Holding Area (NHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure
procedure.
Rwy 20R: Proceed straight ahead to
Samko Holding Area (SHA) climbing
to the last assigned altitude.
Thereafter refer to 10-1P pages for
radio communications failure
procedure.

TEKONG

116.5 VTK

(VENPA1E)

195^

At or above

VENPA ONE ECHO

.2
^ D23

LOST COMMS

SUNVA

(VTK R-210/D8.0)

COMMS

LOST

083^ D9.4

173^

2000'

At or above

4000'

023^

At or above

LOST COMMS

N01 29.9 E104 02.5

N01 26.1
E104 10.7

COMMS

TOPOM

(SJ R-034/D20.0)
(VTK R-013/D5.1)

N00 21.7 E104 49.9

VENIX

(SJ R-125/D164)
(VTK R-131/D164)

SU

30

3
BAVUS

131
RG
A

S00 21.9 E106 05.4 SURGA


(SJ R-124/D194)
(VTK R-129/D193)

092^
105^
KA

DA
46 R

KADAR

S00 06.8
E107 43.7

S00 37.0 E106 31.3

Initial climb clearance 3000' or as directed by ATC


1 INITIAL CLIMB

Climb straight ahead to TOPOM, turn RIGHT and track 115^ to DOKTA.
Turn RIGHT and track 173^ to DOBLU, then track 177^ to DOSNO.
VENPA1F
Climb straight ahead to SUNVA, turn LEFT and track 172^ to SUSIN. Turn
20R
[VENP1F]
LEFT and track 120^ to DOBLU, then turn RIGHT and track 177^ to DOSNO.
1 ROUTING
From DOSNO turn LEFT and track 126^ to VENPA and follow the appropriate transition route to
join the ATS route.
[VENP1E]

02L

CHANGES: Airport elevation, lost comms.

| JEPPESEN, 2006, 2013. ALL RIGHTS RESERVED.

WSSS/SIN
22'

10-9

5 JUL 13

N01 21.6 E103 59.4

SINGAPORE Delivery (Cpt)

Ground
West of Terminal 2

128.6

121.65

Tower
*East of Terminal 2

124.3

121.72

103-59

104-00

02C/20C - (0000 to 1600).

Bldg Area

FOR PARKING POSITIONS


SEE 10-9B & 10-9C1

197'60m
Stopway

Twy WC centerline behind aircraft


stands 506, 507 and 508 diverted
105' (32m) westward. Pilots to follow
the twy centerline while taxiing along
Twy WC.

243'

20
203 R

01-23

Elev 13'

W1

Fuel
Farm

WP
W2

Twy NC3 (between Twy WA and Twy A6)


is a twy with reduced minimum separation
distances between the twy centerline and
object. Due to the reduced minimum
separation distances, pilots are
advised to adhere strictly to the twy
centerline and to slow down the taxi
speed accordingly. Twy NC3 (between
Twy WA and Twy A6) can only be used by
aircraft with a maximum wingspan of
213' (65m).

V3
W3

ON

AP
R

AIS
N
AP
RO

T1
EA
N

AP
RO
UTH

U3

SC1

E7
L7

L5

L10
L8
L9

Pilots operating aircraft with wheel


base longer than B747 or 85' (26m)
shall take note that judgemental
oversteering
may be required when
01-20
maneuvering around taxiway turns.

EP

E8

02C

023^

Elev 14'
197' 60m
Stopway

CHANGES: Ramp area added.

E6

SOUTH-EAST
REMOTE APRON

CHANGI EAST
(MILITARY ONLY)
01-20

E10

For AIRPORT BRIEFING


refer to 10-1P pages.

500

Taxilane A6 (behind aircraft


stands E20 to E24) and taxilane
C6 (behind aircraft stands F50
to F54) can only be used by
aircraft with maximum
wingspan 213' 65m (towing and
pushback exempted).

Twy L5 can only be used by


aircraft with maximum
wingspan of 118' (36m).
Twys L8, L9, and L10 can only
be used by aircraft with
maximum wingspan 213' (65m).

E9

E11

2000

01-21

TERMINAL

3'

L6

BUDGET
TERMINAL

Taxiway centerline along Twy EP


between Twys B1 and B3 offset
eastward by 8' (2.5m) away from
aircraft stands E7 and F36.
2

C7 EP

L4 SC2

EAST REMOTE
APRON

E5

C1
C3

C6

SC1

Pilots are advised to exercise


caution when taxiing near Twys
L5, L8, L9 and L10.

NORTH-EAST
REMOTE APRON

Rwy

U4

C1

400
0m

SC2

T2 CENTRAL APRON

C2

13,1
2

W8

Pilots are advised to apply


speed limit of 20 Kts when
taxiing along twy South
Cross 1 and South Cross 2.

20
203 C

T2 NORTH APRON

B2
B3 E4

MET
U2

V8
W9 SC1

A3
A4 E3

Elev 15'

EN

A2 E1
A7 EP E2

01-22

197' 60m Stopway

EP

SC2

Meters 0

A5

A1

EP

B1

WA

1000

A3

ST

T
NO 3
AP RTH
RO
N

ARP

WA

W10

Feet 0

CE T1
N
AP TRAL
RO
N

V6

WP

197'60m
Stopway

N1 NC3
N2 N3

VY U1

EAST
SERVICE
APRON

NC1

NC2
A6 A7

A6

WA

T2
SO

177'

U1
VZ

EA

N3
NORTH
REMOTE APRON

T1
WE
ST

3'4000

WP

V7

Elev 17'

NC1

W5

W7

02L

EA

N1

VAR 0^

Twy N1 (behind aircraft stands


C16 to C19 and between Twy NC2
and Twy NC3), Twy N2 and
Twy N3 (behind aircraft stands
D35 to D38 and between Twy NC2
and Twy NC3) can only be used
by aircraft with maximum
wingspan of 213' (65m).

EC

V4

TERMINAL

T3 SOUTH APRON

023^

WC

NC2

W6

NORTH
SERVICE EAST
APRON CARGO
APRON

CARGO
APRON

W4

13,1
2

279'

Bldg Area

164'

WP WEST

Pilots are advised to apply


minimum thrust when turning
into Twy WA from Taxilane V6.

1 Control Tower

118.6 2118.25

2 For ACFT operating on Rwy

Pushback clearance expires in


5 min, see 10-9D and 10-9E.

Taxilane U4 (behind aircraft


stands A18 to A21) can only
be used by aircraft with
maximum wingspan of
200' (61m).

0001Z-1600Z

ACARS:
D-ATIS

CHANGI

02R
/20

D-ATIS

SINGAPORE, SINGAPORE

JEPPESEN

Apt Elev

3000
1000

4000

5000

Twy A2 is a one-way taxiway for aircraft taxiing


from Twy EP to Twy A7 only. No-entry signs have
been mounted on either side of Twy A2 along Twy A7.
Taxiway centerline lights along Twy A2 have been
shielded to provide guidance only from Twy EP in
the direction of Twy A7.
Pilots are advised to apply minimum thrust when turning into
Twy A1, A3, A4 and taxilane A5 while taxiing either Northwards
or Southwards on taxilane A6, and thereafter when taxiing
along Twy A1 up to and including the Twy A7/A1 junction.
This is in view of apron activities at aircraft stands D40, D41,
D47, D48, D49, E22, E24, E27 and E28.

1500
| JEPPESEN, 1998, 2013. ALL RIGHTS RESERVED.

JEPPESEN

WSSS/SIN

10-9A

5 JUL 13

SINGAPORE, SINGAPORE

CHANGI

GENERAL
Due to close proximity of Paya Lebar and Seletar airports, correct approach is vital.
Maritime vessels of variable heights off Changi Apt.
Birds in vicinity of airport.
Low-level wind shear alert system.
Departures on Runway 20R are not permitted between 1600/2200 UTC. However, this restriction is not
applicable when Runway 20C/02C is unavailable because of maintenance work or for other reasons.
Unless it is necessary for operational or safety reasons, when using engine reverse, arrivals on
Runway 02L/20R between 1600/2200 UTC may not exceed idle reverse thrust.
To maximize runway utilization and minimize runway occupancy time, departing aircraft, when
instructed to enter the runway, shall commence the maneuver without delay. Pilots are required to
commence take-off roll as soon as take-off clearance is issued by ATC. Arriving aircraft upon
landing shall vacate the runway as quickly as practicable to enable ATC to apply minimum spacing
on final approach and minimize the occurence of go-arounds.
ADDITIONAL RUNWAY INFORMATION

RWY
02L

HIRL CL ALSF-II TDZ REIL

20R

HIRL CL HIALS REIL

PAPI

USABLE LENGTHS
LANDING BEYOND
Glide Slope
Threshold
TAKE-OFF
11,998'3657m

RVR

1 PAPI

RVR

2 PAPI
2 PAPI-L

RVR

12,014'3662m

RVR

12,014'3662m

10,696'3260m

WIDTH

9613'2930m

197'
60m

1 Angle 3.0^.
HIRL CL ALSF-I REIL

02C
20C

HIRL CL ALSF-II TDZ REIL

197'
60m

2 Angle 3.0^.

TAKE-OFF
AIR CARRIER (JAA)

LVP must be in Force


All Rwys
All Rwys
RL & CL

A
B
C
D

200m (150m)
250m (200m)

CHANGES: None.

RCLM (DAY only)


or RL

250m
300m

AIR CARRIER (FAR 121)

All Rwys
CL & RCLM
any RVR out,
other two required

All Rwys
RCLM (DAY only)
or RL

400m

2
Eng
3&4
Eng

TDZ RVR
MID RVR
Rollout RVR

175m
175m
175m

Adequate Vis Ref

RVR
VIS

500m
400m

| JEPPESEN, 1998, 2013. ALL RIGHTS RESERVED.

CHANGES: 202L and 202R added.

U4

A20
A21

A19

A10

A9

A5

A4

A3

T2 SOUTH
APRON

E6

SOUTHEAST
REMOTE APRON

EP

C3

C7

C1

E5

C1

C6

F42
F37

C2

F41
F34

EP

B3

F35
F36

F40

F59L F59R F56L F56R F52L F52R

RWY 02C-20C

C7

205 206 207 209C3


208

C6

200L200R 202L202R

V6

E4

F33

F32

F31

F30

B2

B2

TERMINAL 2

E4

E3

E1
E2

U1

WA
VZ

VZ

U1

T2 NORTH
APRON
T1 EAST
APRON

TERMINAL 1

T1 CENTRAL
APRON

NORTHEAST
REMOTE APRON

N2
N3

N1

C19
C18
C17
C11 C13 C15 C16

C24

C25 C26

T1 WEST APRON

B6 B7 B8 B9 B10 C1 C20 C22 C23

T3 NORTH
APRON

B5

VY

WP

W5

T2 CENTRAL
APRON

B1
EP

A4

E3

EP
E2

A2

E1

A1
EP

NC3

NC3

NC3

EN

D30 D32 D34


D35 D36
D37
D38
E20 E22 E24 E26 E27 E28 D40 D41 D42 D44 D46
E24LE24R
D47
D48
A6
A6
D49
E10
A6
A5
E11
400 401 403
E12
A4
A3
402 404
E5
A1
E6
E8
A7
E7

B3 B4

WA

B2
B1

TERMINAL 3

A2
A1

V6

WP

W6

A7

A6

EP

308
309
310

307

N3

306

304
305

303

N1

302

300
301

WA

WP

NC2

NC2

NC1

EA

NC1

WC

NC1

NORTH
REMOTE
APRON

NC2

W4

10-9B

SC1

A12

A11

WA

W7

Pilots turning aircraft into bay A2 or bay B2


are advised to wait for any aircraft holding
at taxilane V6, at the inner cul-de-sac portion
of the terminal building to vacate this
portion before turning into bay A2 or bay B2.

A13

U2

V7

T3 SOUTH
APRON

200 201 202 203 F60 F59 F58 F56 F54 F52 F50

EAST REMOTE
APRON

SC1

U4

WA

WP

A17 A15
A18 A16 A14

V8

W8

25 OCT 13

EP

U3

SC1

W9

JEPPESEN

SC2

SC2

SC2

W10

RWY 02L-20R

WSSS/SIN
CHANGI

SINGAPORE, SINGAPORE

| JEPPESEN, 1998, 2013. ALL RIGHTS RESERVED.

SINGAPORE, SINGAPORE

JEPPESEN

WSSS/SIN

25 OCT 13

10-9C

CHANGI

PARKING BAY COORDINATES


BAY No.

COORDINATES

BAY No.

T2 Central Apron

T3 South Apron
A1, A2
A3, A4
A5
A9
A10

N01
N01
N01
N01
N01

21.4
21.3
21.3
21.2
21.2

E103
E103
E103
E103
E103

59.1
59.0
59.1
59.1
59.0

A11 thru A13


A14
A15 thru A17
A18
A19, A20

N01
N01
N01
N01
N01

21.1
21.0
21.0
20.9
20.9

E103
E103
E103
E103
E103

59.0
59.0
58.9
58.9
59.0

A21

N01 21.0 E103 59.0

T3 North Apron
B1
B2 thru B4
B5 thru B7
B8 thru B10

N01
N01
N01
N01

21.4
21.5
21.6
21.7

E103
E103
E103
E103

59.1
59.1
59.2
59.3

E103
E103
E103
E103
E103

59.3
59.3
59.4
59.5
59.4

T1 West Apron
C1, C20
C22
C23
C24
C25

N01
N01
N01
N01
N01

C26

21.8
21.9
21.9
21.9
22.0

N01 22.0 E103 59.5

N01
N01
N01
N01
N01

D30
D32, D34
D35 thru D38

21.8
21.9
21.9
22.0
22.1

E103
E103
E103
E103
E103

59.4
59.4
59.5
59.5
59.5

N01 21.7 E103 59.5


N01 21.8 E103 59.5
N01 21.9 E103 59.7

N01
N01
N01
N01
N01

21.6
21.7
21.8
21.8
21.9

N01
N01
N01
N01
N01

F32, F33
F34 thru F36

21.3
21.3
21.3
21.4
21.2

E103
E103
E103
E103
E103

59.4
59.5
59.6
59.6
59.4

N01 21.2 E103 59.5


N01 21.1 E103 59.5

T2 North Apron
E8
E10
E11
E12
E20, E22

N01
N01
N01
N01
N01

E24 thru E26


E27, E28

21.5
21.4
21.4
21.5
21.4

E103
E103
E103
E103
E103

59.6
59.5
59.6
59.6
59.5

N01 21.5 E103 59.5


N01 21.6 E103 59.5

T2 South Apron
F37
F40, F41
F42
F50
F52L, F52R

N01
N01
N01
N01
N01

21.0
21.1
21.0
21.2
21.0

E103
E103
E103
E103
E103

59.4
59.4
59.4
59.4
59.3

F52, F56R, F56L


F54, F56
F58, F59, F59R
F59L, F60

N01
N01
N01
N01

21.1
21.1
21.0
21.0

E103
E103
E103
E103

59.3
59.3
59.3
59.3

200, 200L, 200R


201
202, 202L, 202R
203

N01
N01
N01
N01

20.8
20.8
20.9
20.9

E103
E103
E103
E103

59.2
59.2
59.2
59.2

South-East Remote Apron


1 103, 104
205
206 thru 208
209

N01
N01
N01
N01

20.5
20.7
20.8
20.9

E103
E103
E103
E103

59.2
59.3
59.3
59.3

North-East Remote Apron

T1 East Apron
D40
D41, D42, D44
D46
D47, D48
D49

E1
E2 thru E4
E5
E6, E7
F30, F31

East Remote Apron

T1 Central Apron
C11, C13
C15
C16, C17
C18
C19

COORDINATES

E103
E103
E103
E103
E103

59.5
59.6
59.6
59.8
59.8

400
401 thru 403
404

N01 21.6 E103 59.7


N01 21.7 E103 59.7
N01 21.8 E103 59.7

North Remote Apron


300, 301
302, 303
304
305, 306
307 thru 309
310

N01
N01
N01
N01
N01

22.1
22.1
22.1
22.0
22.0

E103
E103
E103
E103
E103

59.5
59.6
59.7
59.7
59.8

N01 22.0 E103 59.9

1 For Parking Positions see 10-9C1.


CHANGES: 202L and 202R added.

| JEPPESEN, 1998, 2013. ALL RIGHTS RESERVED.

JEPPESEN

RWY 02L-20R

WSSS/SIN

CHANGI

NORTH
SERVICE
APRON

509

WP
WC

SINGAPORE, SINGAPORE

10-9C1

5 JUL 13

508

612
611

507
V3

506

604

505

EC

603
504

W3

WC

602

503

EA

601

EAST
CARGO
APRON
609

502
WP

EAST
SERVICE
APRON

V4

WEST
CARGO
APRON

NC1

606 607
EA
NC1

NC1

W4
N1

WA

N3

NC2

NC2

PARKING BAY COORDINATES


BAY No.
COORDINATES
West Cargo Apron

BAY No.

502
503, 504
505, 506
507, 508
509

601, 602
603
604
611, 612

N01
N01
N01
N01
N01

22.4
22.4
22.5
22.6
22.7

E103
E103
E103
E103
E103

COORDINATES

East Cargo Apron

59.5
59.6
59.6
59.6
59.6

N01
N01
N01
N01

C7

SC1

SC1

SC2

SC2

PARKING BAY COORDINATES

EP

E6

102L

101L
102R

101R

COORDINATES

Budget Terminal Apron


1, 2
3
4 thru 6
7 thru 11
12, 13
14

L4
EP

101

N01 20.5
N01 20.4
N01 20.4
N01 20.3
N01 20.2
N01 20.2

E103 59.2
E103 59.2
E103 59.1
E103 59.1
E103 59.1
E103 59.0

South-East Remote Apron

L7

101, 101L, 101R


102, 102L, 102R
103, 104

E7
L10

N01 20.6 E103 59.1


N01 20.6 E103 59.1
N01 20.5 E103 59.2

L5
L8

EP

L9
E8

RWY 02C-20C

102 103 104


1
2
3
4
5
6
7
8
9
10
11
BUDGET
12
TERMINAL 13
APRON
14

59.8
59.8
59.9
00.0

N01 22.2 E103 59.9


N01 22.1 E103 59.9
N01 22.2 E103 59.9

BAY No.

L6

E103
E103
E103
E104

East Service Apron


606
607
609

C6

22.3
22.4
22.4
22.4

E9
CHANGES: South-East Remote Apron revised, parking spots added.

| JEPPESEN, 2006, 2013. ALL RIGHTS RESERVED.

WSSS/SIN

JEPPESEN
5 JUL 13

10-9C2

SINGAPORE, SINGAPORE
CHANGI

TAXIING GUIDANCE SYSTEM AT SINGAPORE CHANGI AIRPORT


The taxiing guidance system at Singapore Changi Airport consists of stop bars and
selectable segments of green taxiway centerline lights. The system is designed to provide
pilots with visual guidance while taxiing during night operations and during periods
of low visibility. It is controlled by the Ground Movement Controller (GMC) at Changi
Control Tower using the Taxiway Lighting Control Panel (TLCP).
Route Selection and Priority

When a taxiing route is selected on the TLCP, corresponding segments of taxiway


centerline lights on the maneuvering area are switched on automatically. When two or
more routes are selected, the system will give priority to the first route and activate
red stopbar lights across conflicting routes, as necessary. A segment of the centerline
lights of the conflicting routes that cut across the first route will also be suppressed.
The GMC has the option of overriding the taxiing route priority by selecting or
deselecting the appropriate stopbar lights.
All taxiing guidance lights on taxiways leading to the runways terminate at the runway
holding positions where, by default, red stopbar lights remain on unless deselected by
the runway controller. When deselected, these stopbar lights will re-activate
automatically after 50 seconds.
Information and Mandatory Signs/Markings

When following the directional guidance provided by the green taxiway centerline
lights and red stopbar lights, pilots are advised to also navigate their taxi route with
reference to information and mandatory sign/markings provided at the airport so as
to maintain situational awareness of their whereabouts at all times.

CHANGES: None.

| JEPPESEN, 2007, 2013. ALL RIGHTS RESERVED.

WSSS/SIN

+ JEPPESEN
30 APR 10

10-9C3

SINGAPORE, SINGAPORE

CHANGI

ADVANCED- SURFACE MOVEMENT GUIDANCE


AND CONTROL SYSTEM
(A-SMGCS)- MULTILATERATION SYSTEM DEPLOYMENT
AT SINGAPORE CHANGI AIRPORT
1

Introduction

1.1 The Multilateration System is a new surveillance system which is able to detect
and identify all Mode S equipped aircraft and vehicles moving on the airport
surface even during bad weather conditions such as heavy rain. It will integrate
with the current radar-based ground surveillance system as a part of the
Advanced- Surface Movement Guidance and Control System (A-SMGCS) at
Singapore Changi Airport. This will enhance the efficiency and safety at the
airport.

Carriage of Mode-S SSR Transponder

2.1 Carriage and operation of Mode-S transponder is required for all civil aircraft
operating at Singapore Changi Airport. The Mode-S transponder shall comply, at
least, to the requirements of Level 2 as prescribed in ICAO Annex 10 Volume IV
(Amendment 77 or later) Standards and Recommended Practices.

Multilateration System Outline

3.1 The Multilateration System uses multiple receivers to pick up squitters


transmitted by aircraft or vehicle Mode S transponders. It calculates the position
of an aircraft or a vehicle by comparing the time its squitter arrives at each
receiver.

3.2 The system will derive the identity of an aircraft by selectively interrogating its
transponder to receive its assigned Mode A code or extracting its aircraft
identification (that is, the ICAO callsign used in flight and inserted in the Flight
Management System (FMS) or Transponder Control Panel), if available, from its
squitter. For transponder equipped vehicles, the system will derive their
respective identities from the unique Mode S addresses contained in their
squitters.

Aircraft Requirements

4.1 The Multilateration System is essentially passive. It relies on aircraft


transponders squittering at all times when moving on the airfield. At present,
some aircraft checklist procedures instruct pilots to turn off the transponder
shortly after leaving the runway on arrival and, not to switch it on until reaching
the runway holding point for departure. This is in line with the requirement that
Mode A/C transponders should not transmit on the ground, which does not apply
to Mode S transmissions.

4.2 For the Multilateration System to work effectively, all aircraft Mode S
transponders need to transmit Mode S squitters at all times when moving on the
airfield, starting immediately prior to pushback, and for arrival aircraft until
they are stationary at the aircraft stands. The Mode S transponders should not
respond to All-Call interrogations, but should respond to addressed
interrogations.

| JEPPESEN, 2008, 2010. ALL RIGHTS RESERVED.

WSSS/SIN
5

+ JEPPESEN
30 APR 10

10-9C4

SINGAPORE, SINGAPORE

CHANGI

Procedures / Actions Required By Pilots

5.1 The Multilateration System needs to receive squitters and to acquire the Mode A
code of a Mode S equipped aircraft at all times when it is on the ground. This is
to enable detection and identification of the aircraft (from its Mode A code or
ICAO callsign) as soon as it pushes back. Hence, the following actions from
pilots are required.

5.2 Pre-Push back / Taxi


a) Pilots will be required to enter an assigned Mode A code at start-up. This code
will be either a discrete or non-discrete code (a conspicuity code, e.g. 1000).
b) Pilots shall ensure that the aircraft transponder is operating (that is, XPNDR
or the equivalent according to specific installation, AUTO if available, not
OFF or STBY) and the assigned Mode A code is selected prior to the request
for pushback or taxi, whichever is earlier.
c) Whenever the aircraft is capable of reporting aircraft identification, the
aircraft identification must also be entered prior to the request for pushback
or taxi, whichever is earlier, through the FMS or the Transponder Control
Panel. Flight crew must use the 3-letter ICAO designator of the operator,
followed by flight identification number (for example, BAW123, SIA002).

5.3 After Landing


a) Pilots shall ensure that the aircraft transponder is operating (that is, XPNDR
or the equivalent according to specific installation, AUTO if available, not
OFF or STBY) after landing, and continuously until the aircraft is stationary
at the aircraft stand.
b) Pilots shall ensure that the assigned Mode A code is not changed until the
aircraft is stationary at the aircraft stand. (The system requires it for
identification of the aircraft).

| JEPPESEN, 2008, 2010. ALL RIGHTS RESERVED.

WSSS/SIN

JEPPESEN
22 NOV 13

10-9D

SINGAPORE, SINGAPORE

CHANGI

PROCEDURES FOR PUSH BACK AND ASSIGMENT OF


FLIGHT LEVELS TO DEPARTING AIRCRAFT
GENERAL

a. Aircraft departing Singapore Changi Airport shall adhere to the procedures for push back
and assignment of flight levels.
b. Assignment of flight levels to departing aircraft is made on a first-come-first-served basis.
Aircraft will normally be assigned the level requested unless an alternate level is offered
after coordination with the adjacent ATC centers.
c. Departing flights from Singapore requesting FL280 or FL320 on L759, M770, N571,
N571/N877 or P628 will be cleared as follows:
1. Aircraft departing Singapore will be cleared to FL280.
2. Succeeding aircraft on the same route will be cleared to FL280 with 10 min longitudinal
separation provided there is no closing speed with the preceding aircraft.
3. Additional longitudinal separation as appropriate shall be provided by ATC for the faster
aircraft following a slower aircraft on the same route.
4. The first aircraft from either Singapore or Kuala Lumpur to be over GUNIP on N571 or
N571/N877, the Kuala Lumpur/Bangkok FIR boundary on M770 or L759 and VPL on P628
can expect its requested flight level.
d. To avoid confusion, pilots shall use the correct phraseology as detailed in
PROCEDURES paragraph a. when ready for push back.
PROCEDURES
a. The pilot shall notify ATC when the aircraft is ready to push back within 5 min using
the following phraseology:

call sign
destination
propsed flight level and alternate level, if any
parking position

b. On receipt of the 'ready to push back' call, ATC will advise the pilot whether the proposed
flight level or other alternate flight level is available and an ATC clearance will be issued
accordingly. If pre-departure coordination with an adjacent unit or center is required, the
pilot will be instructed to standby.
c. Once the fight level is accepted by the pilot and an ATC clearance issued, the aircraft
must be pushed back within 5 minutes from the time the ATC clearance is accepted
unless other ATC restrictions are imposed. The ATC clearance will be cancelled upon
expiration of the 5 minute grace period.
d. At the end of the push back, the departing aircraft must have all engines started and be
ready to taxi immediately, unless otherwise instructed by ATC.
NOTE: The first aircraft to taxi may not necessarily be the first aircraft to take-off as
distances between aircraft stands and the departure runway vary.

CHANGES: Note removed.

| JEPPESEN, 1998, 2013. ALL RIGHTS RESERVED.

WSSS/SIN

JEPPESEN
22 NOV 13

10-9E

SINGAPORE, SINGAPORE

CHANGI

GATE HOLD PROCEDURES FOR DEPARTING AIRCRAFT


a. Whenever there are about five to seven departing aircraft at the Rwy holding point,
subsequent push backs of departures will be regulated such that the Ground Movement
Planner (GMP) on frequency 121.65 will start to issue pilots with Expected Pushback
Time (EPT). The determination of EPT will take into account an aircraft's parking stand
as well as taxi time to the Rwy-in-use holding point.
b. When an EPT is issued, pilots will be instructed to either remain on GMP frequency
or to monitor Singapore Ground Control (frequencies 124.3 or 121.72). It should be
noted that when instructed to monitor Singapore Ground frequencies, pilots shall not
establish contact with the Singapore Ground Control, rather, pilots shall maintain a
listening watch on the assigned Singapore Ground Control frequency and wait for
pushback instruction. This is to prevent unnecessary frequency congestion.
c. A flight issued with an EPT but chooses to commence pushback before the assigned
time will be allowed to do so. However, the flight should not expect an earlier
departure time as the planned departure sequences will be maintained.
d. In a situation when a departing aircraft is occupying a gate that has been assigned
to an arriving aircraft, the departing aircraft will be instructed by the GMP to contact
Singapore Ground for pushback for the purpose of better gate utilization.
e. To maximize runway utilization, departure sequence will be planned on the basis of
increasing runway throughput so as to enhance overall efficiency.
DELAY IN PUSH BACK AND/OR TAXI DUE TO OTHER AIRCRAFT
Delays may be expected for the second aircraft to push back and to taxi when two or more
aircraft are parked either adjacent to one another or close together. However, it will retain
its ATC clearance even if the 5 minutes grace period allowed for under
PROCEDURES paragraph c. is exceeded.
DELAY IN TAKE-OFF DUE TO RESTRICTIONS IN THE ATC CLEARANCE
The ATC clearance may require an aircraft to arrive at a reporting point at a specific time
and level or to depart a number of minutes behind a preceding traffic to establish
longitudinal separation. Such a delay will not deprive a departing aircraft of its ATC clearance
even though the 5 minutes grace period would have been exceeded.
DELAY DUE TO OVERFLIGHTS
These are flights operating through Singapore FIR without landing at Changi Airport. Depending
on their positions, a departing aircraft requesting the same level may have to accept an
alternate level or may have to delay its departure in order to establish the prescribed
separation.
FLIGHTS EXEMPTED
The above procedures are not applicable to VIP, CASEVAC, SAR and other special tasks
aircraft. ATC shall have full discretion in the conduct of such operations.
CANCELLATION OF ATC CLEARANCE/ OBTAINING A FRESH CLEARANCE
a. A departing aircraft may have its ATC clearance cancelled under the following circumstances:
1. on expiry of the 5 minutes grace period under
PROCEDURES paragraph c., it is still unable to push back; or
2. after pushing back, the pilot advises that it is returning to blocks; or
3. it develops a technical problem and is unable to continue taxiing.

b. ATC will inform the aircraft when a clearance is cancelled using the following phraseology:
'(Call sign of aircraft) your ATC clearance is cancelled (reason)'.
c. Pilots who are ready to depart following the cancellation of an ATC clearance will adopt the
normal procedures as if it is the first time they are ready to depart.
GROUND MOVEMENT PLANNER ON VHF 121.65
The frequency shall be used for aircraft pre-flight checks and ATC clearances.
Pilot-in-command to make his initial call from the parked position of the frequency.

CHANGES: None.

| JEPPESEN, 1998, 2013. ALL RIGHTS RESERVED.

WSSS/SIN

JEPPESEN
6 JUL 12

10-9E1

SINGAPORE, SINGAPORE

CHANGI

GROUND MOVEMENT CONTROL ON 124.3

a. This frequency shall be used for aircraft start-up/push-back clearance.


b. Unless otherwise instructed by ATC, the pilot-in-command shall prior to starting engines
listen out on the Ground Movement Control frequency on 124.3.
c. The pilot-in-command shall:
1. Request and obtain taxi instructions prior to taxiing;

Note: ATC clearance, including the assigned SSR code will normally be issued prior to push back.
Pilot shall squawk the SSR code immediately when airborne.

2. Change from Ground Movement Control frequency to the Runway Control frequency (118.6)
when nearing the taxiway holding position.
3. Request for take-off clearance on 118.6.
d. The pilot-in-command stopping for a pre-flight check at the taxiway holding position shall
change over from 124.3 to 118.6 and request for further clearance before recommencing
taxiing.
e. Departing aircraft will be instructed when to change from 118.6 to Singapore Approach
frequency of 120.3.
f. In the case of the aircraft having landed, the pilot-in-command shall change from 118.6
to 124.3 immediately after clearing the runway. He shall maintain watch on 124.3 for
taxiing and parking instructions until he arrives at his aircraft stand.
TAXIING
a. Taxi clearance given by Ground Movement Control will relate to movement on the
maneuvering area, but excluding the marshalling area.

b. Aircraft taxiing on the maneuvering area will be regulated by ATC to avoid or reduce
possible conflict and will be provided with traffic information and alerting service.
ATC shall apply taxiing clearance limits whenever necessary.
c. The taxiway routes to be used by aircraft after landing or when taxiing for departure
will be specified by ATC. The issuance by ATC of a taxi route to an aircraft does not
relieve the pilot-in-command of the responsibility to maintain separation with other
aircraft on the maneuvering area or to comply with ATC directions intended to
regulate aircraft on the maneuvering area.
d. Pilots are reminded to always use minimum power when starting engines, when
maneuvering within the apron area or when maneuvering from apron taxiways to other
parts of the aerodrome. It is especially critical when commencing to taxi that
break-away thrusts are kept to an absolute minimum and then be reduced to idle
thrusts as soon as possible.
TAKE-OFF AND LANDING
a. Departing aircraft will normally be directed by ATC to use the full length of the runway
for take-off. On obtaining an ATC clearance the aircraft shall enter the runway via
designated taxiways:
Rwy 02C - Twy E10 or E11
Rwy 02L - Twy W8, W9 OR W10
Rwy 20C - Twy E1, E2
Rwy 20R - Twy W1. W2

b. The pilot-in-command shall not take-off or land without a clearance from Aerodrome Control.
c. The pilot-in-command shall not run-up on the runway in use unless authorized by
Aerodrome Control. Engines run-ups in the holding pan or taxiway holding point clear
of the runway in use may be carried out subject to approval by Aerodrome Control.
d. After landing, the pilot-in-command shall vacate the runway by the shortest suitable
route and to contact Ground Control who will issue specific taxi route instructions to
its assigned aircraft stand.
e. Aircraft with radio communication failure shall vacate the runway and stop on the
taxiway and watch for light signals from Aerodrome Control.
ARRIVING AIRCRAFT
The pilot-in-command of an arriving aircraft shall contact the appropriate Approach
Control Unit 10 minutes before entering the CTR or ATZ.

CHANGES: Text.

| JEPPESEN, 2012. ALL RIGHTS RESERVED.

WSSS/SIN

+ JEPPESEN
12 JUN 09

10-9F

SINGAPORE, SINGAPORE

CHANGI

PROCEDURES FOR START-UP AND PUSHBACK OF AIRCRAFT


1. Ground crew must ensure that the area behind an aircraft is clear of vehicles, equipment and other obstructions before the start-up or pushback of aircraft commences.
2. When the pilot is ready for start-up and pushback, he/she shall seek confirmation
from the ground crew that there is no hazard to the aircraft starting up. The pilot
shall then notify the Ground Movement Controller (Callsign: Singapore Ground) that
the aircraft is ready for pushback. On being informed by Singapore Ground that pushback is approved, the pilot shall coordinate with the ground crew for the start-up and
pushback of the aircraft.
3. The following table describes the procedures for the pushback of aircraft from the
various aircraft stands. When it becomes necessary to vary a procedure to expedite
aircraft movements, Singapore Ground will issue specific instructions to the pilot.
APRON/ACFT
STANDS

PHRASEOLOGY USED
BY SINGAPORE
GROUND

PUSHBACK PROCEDURES

T3 WEST
A1

The aircraft shall be pushed back onto Taxilane V6 to


face West such that the pushback line is always kept
midway between the aircraft main gear until its
nosewheel is at the "END OF PUSH (for A1 nose
gear)" position. The aircraft shall then be towed
forward along the pushback line until its nosewheel is
at the "END OF TOW (for A1, A2, B1, B2)" position.
The aircraft may breakaway from there. Engine start
up is not permitted during standard pushback.

Standard pushback
approved.

Alternate Pushback
The aircraft (on idle thrust) shall be pushed back onto
Taxilane V6 to face East, followed by TWY WA, such
that the alternate pushback line is always kept
midway between the aircraft main gear until the nose
of the aircraft is behind the stopbar behind aircraft
stand A3 or B2. The aircraft may breakaway from
there. This alternate pushback procedure can only be
exercised if the auxiliary power unit of aircraft is
unserviceable.

Pushback approved,
to face North (or
South) on TWY WA.

A2

The aircraft (on idle thrust) shall be pushed back onto


Taxilane V6 to face West such that the pushback line
is always kept midway between the aircraft main
gear until its main gear is at the intersection of the
pushback line and Taxilane V6 centerline and the
nosewheel stops at the "END OF PUSH (A2, B2)"
position. The aircraft shall then be towed forward
along Taxilane V6 centerline until its nosewheel is at
the "END OF TOW (for A1, A2, B1, B2)" position. The
aircraft may breakaway from there.

Standard pushback
approved.

A3

The aircraft (on idle thrust) shall be pushed back onto


TWY WA until its nosewheel is at the intersection of
the aircraft stand lead-in line and TWY WA
centerline. The aircraft may breakaway from there.

Pushback approved,
to face North
(or South).

A4

The aircraft (on idle thrust) shall be pushed back onto


TWY WA to face North (or South) such that the
pushback line is always kept midway between the
aircraft main gear until its nosewheel is at TWY WA
centerline. The aircraft may breakaway from there.

Pushback approved,
to face North
(or South).

| JEPPESEN, 1999, 2009. ALL RIGHTS RESERVED.

JEPPESEN

WSSS/SIN

8 JUN 12

10-9F-0

SINGAPORE, SINGAPORE

CHANGI

GATE HOLD PROCEDURES


FOR DEPARTING AIRCRAFT
GATE HOLD PROCEDURES

1. Whenever there are about five to seven departing aircraft at the runway
holding point, subsequent push-backs of departures will be regulated such that
the Ground Movement Planner (GMP) on VHF frequency 121.65 will start to
issue pilots with Expected Pushback Time (EPT). The determination of EPT
will take into account an aircraft's parking bay as well as taxi time to
the runway-in-use holding point.
2. When an Expected Pushback Time (EPT) is issued, pilots will be instructed
to either remain on Ground Movement Planner (GMP) frequency or to monitor
Singapore Ground Control (frequencies 124.3 or 121.72). It should be noted
that when instructed to monitor Singapore Ground frequencies, pilots shall not
establish contact with the Singapore Ground Control, rather, pilots shall
maintain a listening watch on the assigned Signapore Ground Control
frequency and await for pushback instruction. This is to prevent unnecessary
frequency congestion.
3. A flight issued with an Expected Pushback Time (EPT) but chooses to
commence pushback before the assigned time will be allowed to do so.
However, the flight should not expect an earlier departure time as the planned
departure sequences will be maintained.
MAXIMIZING GATE AND RUNWAY UTILIZATION

4. In a situation when a departing aircraft is occupying a gate that has been


assigned to an arriving aircraft, the departing aircraft will be instructed by
the Ground Movement Planner (GMP) to contact Signapore Ground for
pushback for the purpose of better gate utilization.
5. To maximize runway utilization, departure sequence will be planned on the
basis of increasing runway throughput so as to enhance overall efficiency.

CHANGES: Introduction paragraph removed.

| JEPPESEN, 2012. ALL RIGHTS RESERVED.

WSSS/SIN
APRON/ACFT
STANDS

A5, A9

A10

A11

A12

A13, A14,
A15

A16

+ JEPPESEN
12 JUN 09

10-9G

SINGAPORE, SINGAPORE

CHANGI

PHRASEOLOGY USED
BY SINGAPORE
GROUND

PUSHBACK PROCEDURES

The aircraft (on idle thrust) shall be pushed back onto


TWY U2 to face North such that the pushback line is
always kept midway between the aircraft main gear
until the nose of the aircraft is behind the stopbar
behind aircraft stand A11. The aircraft may
breakaway from there.
OR
The aircraft (on idle thrust) shall be pushed back onto
TWY WA to face South until nose of the aircraft is
behind the stopbar behind aircraft stand A4. The
aircraft may breakaway from there.

Pushback approved,
to face North.

The aircraft (on idle thrust) shall be pushed back onto


TWY U2 to face North until the nose of the aircraft is
behind the stopbar behind aircraft stand A11. The
aircraft may breakaway from there.
OR
The aircraft (on idle thrust) shall be pushed back onto
TWY WA to face South until the nose of the aircraft
is behind the stopbar behind aircraft stand A4. The
aircraft may breakaway from there.

Pushback approved,
to face North.

The aircraft (on idle thrust) shall be pushed back onto


TWY U2 to face North until the nose of the aircraft is
at the intersection of the aircraft stand lead-in line
and TWY U2 centerline. The aircraft shall then be
towed forward until the nose of the aircraft is behind
the stopbar behind aircraft stand A11. The aircraft
may breakaway from there.
OR
The aircraft (on idle thrust) shall be pushed back onto
TWY U2 to face South until the nose of the aircraft is
at the intersection of the aircraft stand lead-in line
and TWY U2 centerline. The aircraft shall then be
towed forward until its nosewheel is behind the
stopbar behind aircraft stand A12. The aircraft may
breakaway from there.

Pushback approved,
to face North.

The aircraft (on idle thrust) shall be pushed back onto


TWY U2 to face North until the nose of the aircraft is
at the intersection of the aircraft stand lead-in line
and TWY U2 centerline. The aircraft shall then be
towed forward until its nosewheel is behind the
stopbar behind aircraft stand 11. The aircraft may
breakaway from there.
OR
The aircraft (on idle thrust) shall be pushed back onto
TWY U2 to face South until its nosewheel is at the
intersection of the aircraft stand lead-in line and
TWY U2 centerline. The aircraft may breakaway from
there.

Pushback approved,
to face North.

The aircraft (on idle thrust) shall be pushed back onto


TWY WA to face North until the nose of the aircraft
is behind the stopbar behind aircraft stand A16. The
aircraft may breakaway from there.
OR
The aircraft (on idle thrust) shall be pushed back onto
TWY U2 to face South until the nose of the aircraft is
behind the stopbar behind aircraft stand A12. The
aircraft may breakaway from there.

Pushback approved
to face North.

The aircraft (on idle thrust) shall be pushed back onto


TWY WA until its nosewheel is at the intersection of
the aircraft stand lead-in line and TWY WA
centerline. The aircraft may breakaway from there.

Pushback approved
to face North
(or South).

Pushback approved,
to face South.

Pushback approved,
to face South.

Pushback approved,
to face South.

Pushback approved,
to face South.

Pushback approved,
to face South.

| JEPPESEN, 1999, 2009. ALL RIGHTS RESERVED.

WSSS/SIN
APRON/ACFT
STANDS

A17

+ JEPPESEN
12 JUN 09

10-9H

SINGAPORE, SINGAPORE

CHANGI

PHRASEOLOGY USED
BY SINGAPORE
GROUND

PUSHBACK PROCEDURES

Pushback facing West


The aircraft (on idle thrust) shall be pushed back onto
Taxiway V8 to face West until its nosewheel is at the
"END OF PUSH" position behind aircraft stand A17.
The aircraft may breakaway from there.
Pushback facing South
The aircraft (on idle thrust) shall be pushed back onto
TWY WA to face South until the nose of the aircraft
is behind the stopbar behind aircraft stand A16. The
aircraft may breakaway from there.

Pushback approved
to face West.

A18

The aircraft (on idle thrust) shall be pushed back onto


Taxiway U4 to face West such that the pushback line
is always kept midway between the aircraft main
gear until its main gear is aligned with the centerline
of Taxiway U4 and the nose of the aircraft is behind
the stopbar behind aircraft stand A18. The aircraft
may breakaway from there. Pushback to face East is
not permitted.

Standard pushback
approved.

A19

The aircraft (on idle thrust) shall be pushed back onto


Taxiway U4 to face West such that the pushback line
is always kept midway between the aircraft main
gear until its main gear is aligned with the centerline
of Taxiway U4 and the nose of the aircraft is behind
the stopbar behind the "END OF PUSH" line. The
aircraft may breakaway from there. Pushback to face
East is not permitted.

Standard pushback
approved.

A20

The aircraft (on idle thrust) shall be pushed back onto


Taxiway U4 to face West such that the pushback line
is always kept midway between the aircraft main
gear until its main gear is aligned with the centerline
of Taxiway U4 and the nose of the aircraft is behind
the stopbar behind the "END OF PUSH (for A20 nose
gear)" position. The aircraft may breakaway from
there. Pushback to face East is not permitted.

Standard pushback
approved.

A21

The aircraft (on idle thrust) shall be pushed back onto


Taxilane U4 to face East such that the pushback line is
always kept midway between the aircraft main gear
until its nosewheel is at the "END OF PUSH (for A21
nose gear)" position. The aircraft shall then be towed
forward to face West until its nose is behind the
stopbar behind aircraft stand A18. The aircraft may
breakaway from there.

Standard pushback
approved.

B1

The aircraft shall be pushed back onto Taxilane V6 to


face West such that the pushback line is always kept
midway between the aircraft main gear until its
nosewheel is at the "END OF PUSH (for B1 nose
gear)" position. The aircraft shall then be towed
forward along the pushback line until its nosewheel is
at the "END OF TOW (for A1, A2, B1, B2)" position.
The aircraft may breakaway from there. Engine
startup is not permitted during standard pushback.

Standard pushback
approved.

Alternate Pushback
The aircraft (on idle thrust) shall be pushed back onto
Taxilane V6 to face East, followed by TWY WA, such
that the alternate pushback line is always kept
midway between the aircraft main gear until the nose
of the aircraft is behind the stopbar behind aircraft
stand A3 or B2. The aircraft may breakaway from
there. This alternate pushback procedure can only be
exercised if the auxiliary power unit of aircraft is
unserviceable.

Pushback approved,
to face North (or
South) on TWY WA.

Pushback approved
to face South.

| JEPPESEN, 1999, 2009. ALL RIGHTS RESERVED.

WSSS/SIN
APRON/ACFT
STANDS

+ JEPPESEN
12 JUN 09

10-9J

SINGAPORE, SINGAPORE

CHANGI

PHRASEOLOGY USED
BY SINGAPORE
GROUND

PUSHBACK PROCEDURES

B2

The aircraft (on idle thrust) shall be pushed back onto


Taxilane V6 to face West such that the pushback line
is always kept midway between the aircraft main
gear until its main gear is at the intersection of the
pushback line and Taxilane V6 centerline and the
nosewheel stops at the "END OF PUSH (A2, B2)"
position. The aircraft shall then be towed forward
along Taxilane V6 centerline until its nosewheel is at
the "END OF TOW (for A1, A2, B1, B2)" position. The
aircraft may breakaway from there.

Standard pushback
approved.

B3

The aircraft (on idle thrust) shall be pushed back onto


TWY WA until its nosewheel is at the intersection of
the aircraft stand lead-in line and TWY WA
centerline. The aircraft may breakaway from there.

Pushback approved,
to face North
(or South).

B4

The aircraft (on idle thrust) shall be pushed back onto


TWY WA to face North (or South) such that the
pushback line is always kept midway between the
aircraft main gear until its nosewheel is at TWY WA
centerline. The aircraft may breakaway from there.

Pushback approved,
to face North
(or South).

B5, B6

The aircraft (on idle thrust) shall be pushed back onto


TWY WA to face North until the nose of the aircraft
is behind the stopbar behind aircraft stand B4. The
aircraft may breakaway from there.
OR
The aircraft (on idle thrust) shall be pushed back onto
TWY U1 to face South such that the pushback line is
always kept midway between the aircraft main gear
until the nose of the aircraft is behind the stopbar
behind aircraft stand B7. The aircraft may breakaway
from there.

Pushback approved,
to face North.

The aircraft (on idle thrust) shall be pushed back onto


TWY U1 to face South until the nose of the aircraft is
behind the stopbar behind aircraft stand B7. The
aircraft may breakaway from there.
OR
The aircraft (on idle thrust) shall be pushed back onto
TWY WA to face North until the nose of the aircraft
is behind the stopbar behind aircraft stand B4. The
aircraft may breakaway from there.

Pushback approved,
to face South.

The aircraft (on idle thrust) shall be pushed back onto


TWY U1 to face South until its nosewheel is at the
intersection of the aircraft stand lead-in line and
TWY U1 centerline. The aircraft may breakaway from
there.
OR
The aircraft (on idle thrust) shall be pushed back onto
TWY U1 to face North until its nosewheel is at the
intersection of the lead-in line and TWY U1
centerline. The aircraft shall then be towed forward
until its nosewheel is at the intersection of the
aircraft stand B9 lead-in line and Twy U1 centerline.
The aircraft may breakaway from there.

Pushback approved,
to face South.

The aircraft (on idle thrust) shall be pushed back onto


TWY U1 until its nosewheel is at the intersection of
the aircraft stand lead-in line and TWY U1 centerline.
The aircraft may breakaway from there.

Pushback approved
to face North (or
South).

B7

B8

B9, B10

Pushback approved,
to face South.

Pushback approved,
to face North.

Pushback approved,
to face North.

| JEPPESEN, 1999, 2009. ALL RIGHTS RESERVED.

JEPPESEN

WSSS/SIN

3 JAN 14

APRON/ACFT
STANDS

10-9K

SINGAPORE, SINGAPORE
CHANGI

PHRASEOLOGY USED
BY SINGAPORE
GROUND

PUSHBACK PROCEDURES

EAST REMOTE
200, 201,
The aircraft (on idle thrust) shall be pushed back
onto Twy C6 to face North (or South).
202, 203

200L

200R, 202L
202R

The aircraft (on idle thrust) shall be pushed back


onto Twy C6 centerline to face North until its
nosewheel is on the end of push behind acft stand
200L. The acft may breakaway from there.
OR
The aircraft (on idle thrust) shall be pushed back
onto Twy C6 centerline to face South.
The aircraft (on idle thrust) shall be pushed back
onto Twy C6 centerline to face North (or South).

Pushback approved,
to face North (or
South).
Pushback approved,
to face North.

Pushback approved,
to face South.
Pushback approved,
to face North (or
South).

SOUTH-EAST REMOTE

103, 104

The aircraft (on idle thrust) shall be pushed back


onto Twy L4 centerline to face East until the aircraft
nose is behind the stopbar behind aircraft stand 102.
The aircraft may break away from there.

Standard pushback
approved

205, 206,
207, 208

The aircraft (on idle thrust) shall be pushed back


onto Twy C7 to face North (or South).

209

The aircraft (on idle thrust) shall be pushed back to


face North (or South) until its nose wheel is at the
intersection of the lead-in line and Twy C7 centerline.

Pushback approved,
to face North (or
South).
Pushback approved,
to face North (or
South).

NORTH REMOTE

300, 303

301, 304,
305
302, 306

The aircraft (on idle thrust) shall be pushed back


facing West until its nose wheel is at the intersection
of the lead-in line and taxiway centerline.
OR
The aircraft (on idle thrust) shall be pushed back
facing East until its nose wheel is at the intersection
of the lead-in line and taxiway centerline.
The aircraft (on idle thrust) shall be pushed back to
face East (or West) until its nose wheel is at the
intersection of the lead-in line and the taxiway
centerline.
The aircraft (on idle thrust) shall be pushed back to
face East until its nose wheel is at the intersection
of the lead-in line and taxiway centerline.
OR
The aircraft (on idle thrust) shall be pushed back to
face West until its nose wheel is at the intersection
of the lead-in line and Twy A6 centerline.

307, 308,
309, 310

Pushback approved,
to face West.
Pushback approved,
to face East.
Pushback approved,
to face East (or
West).
Pushback approved,
to face East.
Pushback approved,
to face West.

The aircraft (on idle thrust) shall be pushed back to


face East (or West) until its nose wheel is at the
intersection of the lead-in line and Twy NC2
centerline.
NORTH-EAST REMOTE

Pushback approved,
to face East (or
West).

400, 401
402, 403
404

The aircraft (on idle thrust) shall be pushed back to


face North (or South) until its nose wheel is at the
intersection of the lead-in line and Twy A6 centerline.

Pushback approved,
to face North (or
South).

The aircraft (on idle thrust) shall be pushed back to


face North (or South). The aircraft may breakaway
from here. There shall be no simultaneous pushback
of aircraft unless with two aircraft stands separation.
The aircraft (on idle thrust) shall be pushed back to
face North (or South).

Pushback approved,
to face North (or
South).

WEST CARGO

502

503, 504,
505, 506

Pushback approved,
to face North (or
South).

| JEPPESEN, 1999, 2014. ALL RIGHTS RESERVED.

WSSS/SIN
APRON/ACFT
STANDS

JEPPESEN
3 JAN 14

10-9L

SINGAPORE, SINGAPORE
CHANGI

PUSHBACK PROCEDURES

PHRASEOLOGY USED
BY SINGAPORE
GROUND
Standard pushback
approved.

507, 508

The aircraft (on idle thrust) shall be pushed back to


face South.

509

The aircraft (on idle thrust) shall be pushed back to


face South until its nose wheel is at the intersection
of the pushback line and Twy WC centerline.

Standard pushback
approved.

The aircraft (on idle thrust) shall be pushed back to


face South until its nose wheel is at the intersection
of the lead-in line and taxilane EA centerline.
The aircraft (on idle thrust) shall be pushed back to
face South until its nose wheel is at the intersection
of the lead-in line and taxilane EA centerline. The
aircraft shall then be towed forward along the
centerline of taxilane EA until its nose wheel is on the
"END OF TOW" marking behind aircraft stand 602.
The aircraft (on idle thrust) shall be pushed back to
face South until its nose wheel is at the position
of "END OF PUSH". The aircraft shall then be towed
forward along the centerline of taxilane EA until its
nose wheel is on the "END OF TOW" marking behind
aircraft stand 602.
The aircraft shall be pushed back to face North until
its nosewheel is at the "END OF PUSH" position.
The aircraft shall then be towed forward along the
centerline of taxilane EC and turn Left onto the
centerline of taxilane EA until its nosewheel is on
the "END OF TOW" marking behind stand 602. The
aircraft may breakaway from there. Engine start up
is not permitted during standard push back.
OR
The aircraft shall be pushed back to face North until
its nosewheel is at the "END OF PUSH" position.
Engine start up is permitted only on the port engine.
The aircraft shall then be towed forward along the
centerline of taxilane EC and turn Left onto the
centerline of taxilane EA until its nosewheel is on the
"END OF TOW" marking behind stand 602. The
aircraft may breakaway from there. This alternate
pushback procedure can only be exercised if the
Auxiliary Power Unit of the aircraft is unserviceable.

Standard pushback
approved.

The aircraft (on idle thrust) shall be pushed back


onto Twy U1 to face North (or South).

Pushback approved,
to face North (or
South).
Pushback approved,
to face North.

EAST CARGO

601, 602
603

604

611, 612

Standard pushback
approved.

Standard pushback
approved.

Standard pushback
approved.

Alternate pushback
approved.

T1 WEST

C1, C20,
C22, C23,
C24, C25
C26

The aircraft (on idle thrust) shall be pushed back


onto Twy WA to face North. The aircraft may
breakaway from there.
OR
The aircraft (on idle thrust) shall be pushed back
onto Twy WA to face South until its nose wheel is
at the intersection of the aircraft stand lead-in line
towed forward along the centerline of the taxilane
EC and turn left onto the centerline of taxilane EA
until its nose wheel is at the "END OF TOW" marking
behind aircraft stand 602.

Pushback approved,
to face South.

T1 CENTRAL

C11

The aircraft (on idle thrust) shall be pushed back


such that the pushback line is always kept midway
between the aircraft main gear until the nose wheel
of the aircraft is at the "EOP 21" position. The
aircraft shall then be towed forward until its nose
wheel is at the "EOT 22A" position.

Standard pushback
approved.

| JEPPESEN, 1999, 2014. ALL RIGHTS RESERVED.

WSSS/SIN
APRON/ACFT
STANDS
C13

D32

C15, D34

C16, C17
C18
C19

JEPPESEN
8 JUN 12

10-9L1

SINGAPORE, SINGAPORE
CHANGI

PUSHBACK PROCEDURES
The aircraft (on idle thrust) shall be pushed back
to face North such that the pushback line is always
kept midway between the aircraft main gear until its
nose wheel is at the "END OF PUSH (Stopbar 22)"
position. The aircraft shall be towed forward until
its nose wheel is at the "END OF TOW (Stopbar
22A)" position.
OR
Alternate Pushback Procedure
The aircraft (on idle thrust) shall be pushed back
onto Twy N2 to face South followed by Twy N3 until
the nose of the aircraft is behind the stopbar line
behind the aircraft stand D35. The aircraft may
break away from there.
OR
Alternate Pushback Procedure
The aircraft (on idle thrust) shall be pushed back
onto Twy N2 to face South followed by Twy N1 until
the nose of the aircraft is behind the stopbar line
behind the aircraft stand C16. The aircraft may
break away from there.
The aircraft (on idle thrust) shall be pushed back
to face North such that the pushback line is always
kept midway between the aircraft main gear until its
nose wheel is at the "END OF PUSH (Stopbar 22)"
position. The aircraft shall be towed forward until
its nose wheel is at the "END OF TOW (Stopbar
22A)" position.
OR
Alternate Pushback Procedure
The aircraft (on idle thrust) shall be pushed back
onto Twy N2 to face South followed by Twy N3 until
the nose of the aircraft is behind the stopbar line
behind the aircraft stand D35. The aircraft may
break away from there.
OR
Alternate Pushback Procedure
The aircraft (on idle thrust) shall be pushed back
onto Twy N2 to face South followed by Twy N1 until
the nose of the aircraft is behind the stopbar line
behind the aircraft stand C16. The aircraft may
break away from there.
The aircraft (on idle thrust) shall be pushed back
facing North until its nose wheel is at the
intersection of the lead-in line and Twy N2 centerline.
OR
Alternate Pushback Procedure
The aircraft (on idle thrust) shall be pushed back
onto Twy N2 to face South followed by Twy N3 until
the nose of the aircraft is behind the stopbar line
behind the aircraft stand D35. The aircraft may
break away from there.
OR
Alternate Pushback Procedure
The aircraft (on idle thrust) shall be pushed back
onto Twy N2 to face South followed by Twy N1 until
the nose of the aircraft is behind the stopbar line
behind the aircraft stand C16. The aircraft may
break away from there.
The aircraft (on idle thrust) shall be pushed back to
face North (or South) until its nose wheel is at the
intersection of the lead-in line and Twy N1 centerline.
The aircraft (on idle thrust) shall be pushed back
to face North until its nose wheel is at the
intersection of the lead-in line and Twy N1 centerline.
The aircraft (on idle thrust) shall be pushed back
to face North along Twy N1 until the "END OF
PUSHBACK" position.

PHRASEOLOGY USED
BY SINGAPORE
GROUND
Standard pushback
approved.

Pushback approved,
onto Twy N3 to
face South.

Pushback approved,
onto Twy N1 to
face South.
Standard pushback
approved.

Pushback approved,
onto Twy N3 to
face South.

Pushback approved,
onto Twy N1 to
face South.
Standard pushback
approved.
Pushback approved,
onto Twy N3 to
face South.

Pushback approved,
onto Twy N1 to
face South.
Pushback approved,
to face North (or
South).
Standard pushback
approved.
Standard pushback
approved.

| JEPPESEN, 2007, 2012. ALL RIGHTS RESERVED.

WSSS/SIN
APRON/ACFT
STANDS
D30

D35, D36

D37
D38

JEPPESEN
8 JUN 12

10-9L2

SINGAPORE, SINGAPORE
CHANGI

PUSHBACK PROCEDURES
The aircraft (on idle thrust) shall be pushed back
such that the pushback line is always kept midway
between the aircraft main gear until its nose wheel
of the aircraft is at the "END OF PUSH (Stopbar 20)"
position. the aircraft shall then be towed forward
until its nose wheel is at the "END OF TOW (Stopbar
22A)" position.
The aircraft (on idle thrust) shall be pushed back
to face North (or South) until its nose wheel is at
the intersection of the lead-in line and Twy N3
centerline.
The aircraft (on idle thrust) shall be pushed back to
face North until its nose wheel is at the intersection
of the lead-in line and Twy N3 centerline.
The aircraft (on idle thrust) shall be pushed back to
face North along Twy N3 until the "END OF
PUSHBACK" position.

PHRASEOLOGY USED
BY SINGAPORE
GROUND
Standard pushback
approved.

Pushback approved,
to face North (or
South).
Standard pushback
approved.
Standard pushback
approved.

T1 EAST

D40,
D42,
D46,
D48,

D41,
D44,
D47,
D49

The aircraft (on idle thrust) shall be pushed back to


face North (or South) until its nose wheel is at the
intersection of the lead-in line and Twy A6
centerline.

Pushback approved,
to face North (or
South).

The aircraft (on idle thrust) shall be pushed back


such that the pushback line is always kept midway
between the aircraft main gear until its nose wheel
is at Stopbar 12. This is marked as "END OF
PUSHBACK" on the ground. The aircraft shall then
be towed forward to Stopbar 9. this is marked as
"END OF TOW" on the ground.
The aircraft (on idle thrust) shall be pushed back
until its nose wheel is at the intersection of the
lead-in line and Twy B2 centerline. The aircraft shall
then be towed forward to Stopbar 9. This is marked
as "END OF TOW" on the ground.
The aircraft (on idle thrust) shall be pushed back
until its nose wheel is at Stopbar 9. This is marked
as "END OF TOW" on the ground.
The aircraft (on idle thrust) shall be pushed back
until its nose wheel is at "END OF PUSHBACK" 8
position.
OR
The aircraft (on idle thrust) shall be pushed back
onto Twy B1 until its nose wheel is at "END OF
PUSHBACK" 13A position.
OR
The aircraft (on idle thrust) shall be pushed back
onto Twy B3 until its nose wheel is at "END OF
PUSHBACK" 7A position.
The aircraft (on idle thrust) shall be pushed back
until its nose wheel is at the intersection of the
lead-in line and Twy B1 centerline. The aircraft shall
then be towed forward to Stopbar 13. This is marked
as "END OF TOW" on the ground.
The aircraft (on idle thrust) shall be pushed back
until its nose wheel is at Stopbar 13. This is marked
as "END OF TOW" on the ground.

Standard pushback
approved.

T2 CENTRAL

E1

E2

E3
E4

E5, E6

E7

Standard pushback
approved.

Standard pushback
approved.
Standard pushback
approved.
Pushback approved,
to pushback onto
Twy B1.
Pushback approved,
to pushback onto
Twy B3.
Standard pushback
approved.

Standard pushback
approved.

| JEPPESEN, 2007, 2012. ALL RIGHTS RESERVED.

WSSS/SIN
APRON/ACFT
STANDS
F30

F31

F32
F33

F34, F35

F36

JEPPESEN
1 FEB 13

10-9L3

SINGAPORE, SINGAPORE
CHANGI

PUSHBACK PROCEDURES
The aircraft (on idle thrust) shall be pushed back
such that the pushback line is always kept midway in
between the aircraft main gear until its nose wheel is
at Stopbar 11. This is marked as "END OF
PUSHBACK" on the ground. The aircraft shall then be
towed forward to Stopbar 9. This is marked as "END
OF TOW" on the ground.
The aircraft (on idle thrust) shall be pushed back
until its nose wheel is at Stopbar 10. This is marked
as "END OF PUSHBACK" on the ground. The aircraft
shall then be towed forward to Stopbar 9. This is
marked as "END OF TOW" on the ground.
The aircraft (on idle thrust) shall be pushed back
until its nose wheel is at Stopbar 9. This is marked
as "END OF PUSHBACK" on the ground.
The aircraft (on idle thrust) shall be pushed back
until its nose wheel is at Stopbar 8. This is marked
as "END OF PUSHBACK" on the ground.
OR
The aircraft (on idle thrust) shall be pushed back
onto Twy B1 until its nose wheel is at Stopbar 13A.
OR
The aircraft (on idle thrust) shall be pushed back
onto Twy B3 until its nose wheel is at Stopbar 7A.

PHRASEOLOGY USED
BY SINGAPORE
GROUND
Standard pushback
approved.

Standard pushback
approved.

Standard pushback
approved.
Standard pushback
approved.
Pushback approved,
to pushback onto
Twy B1.
Pushback approved,
to pushback onto
Twy B3.

The aircraft (on idle thrust) shall be pushed back


until its nose wheel is at the intersection of the
lead-in line and Twy B3 centerline. The aircraft shall
then be towed forward to Stopbar 7. This is marked
as "END OF TOW" on the ground.
The aircraft (on idle thrust) shall be pushed back
until its nose wheel is at Stopbar 7. This is marked
as "END OF PUSHBACK" on the ground.

Standard pushback
approved.

The aircraft (on idle thrust) shall be pushed back


until its nose wheel is at Stopbar 14. This is marked
as "END OF PUSHBACK" on the ground. The aircraft
shall then be towed forward to Stopbar 15. This is
marked as "END OF TOW" on the ground.
The aircraft (on idle thrust) shall be pushed back
with the main gear mid-point following the pushback
line until its nose wheel is at position EOP 19.
The aircraft (on idle thrust) shall be pushed back:
- with the main gear mid-point following the main
gear pushback line onto Twy A6 centerline. The
aircraft shall then be towed forward to Stopbar 16
on Twy A5. This is marked as "END OF TOW" on the
ground.
OR
- with the main gear mid-point following the main
gear pushback line until its body is aligned with
Twy A6 centerline.
OR
Alternate Pushback Procedure for aircraft wingspan
of more than 213ft (65M):
The aircraft (on idle thrust) shall be pushed back
with the main gear mid-point following the main
gear pushback line until its nose wheel is at the
"END OF PUSH 19A" position behind aircraft Stand
E24. The aircraft shall then be towed forward to
"END OF TOW 18B" behind aircraft Stand E26.

Standard pushback
approved.

Standard pushback
approved.

T2 NORTH

E8

E10
E11

Standard pushback
approved.
Standard pushback
approved.

Pushback approved,
onto Twy A6.

Pushback approved,
onto Twy A6.

| JEPPESEN, 2007, 2013. ALL RIGHTS RESERVED.

WSSS/SIN
APRON/ACFT
STANDS
E12

E20

E22

E24, E24L/R
E26
E27, E28

JEPPESEN
1 FEB 13

10-9L4

SINGAPORE, SINGAPORE
CHANGI

PUSHBACK PROCEDURES
The aircraft (on idle thrust) shall be pushed back:
- until its nose wheel is at the intersection of the
lead-in line and Twy A5 centerline. The aircraft shall
then be towed forward to Stopbar 16. This is marked
as "END OF TOW" on the ground.
OR
- onto Twy A6 until its nose wheel is at the
intersection of Twy A5 and A6 centerline.
The aircraft (on idle thrust) shall be pushed back
with the main gear mid-point following the main
gear pushback line until its nose wheel is at Stopbar
17. The aircraft shall then be towed forward to
"END OF TOW" Stopbar 18A. Aircraft may
breakaway from here.
The aircraft (on idle thrust) shall be pushed back
with the main gear mid-point following the main
gear pushback line until its nose wheel is at Stopbar
19. This is marked as "END OF PUSHBACK" on the
ground. The aircraft shall then be towed forward to
Stopbar 18. This is marked as "END OF TOW" on the
ground.
The aircraft (on idle thrust) shall be pushed back
facing North until its body is aligned with Twy A6
centerline. Aircraft may breakaway from there.
The aircraft (on idle thrust) shall be pushed back to
face North until its body is aligned with Twy A6
centerline.
The aircraft (on idle thrust) shall be pushed back to
face North (or South) until its body is aligned with
Twy A6 centerline.

PHRASEOLOGY USED
BY SINGAPORE
GROUND
Standard pushback
approved.

Pushback approved,
to pushback onto
Twy A6.
Standard pushback
approved.

Standard pushback
approved.

Standard pushback
approved.
Standard pushback
approved.
Pushback approved,
to face North (or
South).

T2 SOUTH

F37

F40, F52

F41, F42

F42

The aircraft (on idle thrust) shall be pushed back


with the main gear following the main gear pushback
gear pushback line, until its nose wheel is on the
"END OF TOW (EOP)" Stopbar 4 behind aircraft
Stand F42.
OR
The aircraft (on idle thrust) shall be pushed back
with the main gear following the main gear pushback
gear pushback line, until its nose wheel is on the
"END OF TOW (EOP)" Stopbar 5 on Twy C1.
The aircraft (on idle thrust) shall be pushed back
until its nose wheel is at Stopbar 2. This is marked
as "END OF PUSHBACK" on the ground. The aircraft
shall then be towed forward to Stopbar 3. This is
marked as "END OF TOW" on the ground.
The aircraft (on idle thrust) shall be pushed back
until its nose wheel is at the intersection of the
lead-in line and Twy C2 centerline. The aircraft shall
then be towed forward to Stopbar 4. This is marked
as "END OF TOW 4" on the ground.
OR
The aircraft (on idle thrust) shall be pushed back
onto Twy C6 until its nose wheel is at the
intersection of Twy C2 and Twy C6 centerline.
OR
Alternate Pushback Procedure for aircraft wingspan
of more than 213ft (65M):
The aircraft (on idle thrust) shall be pushed back
until its nose wheel is at the "END OF PUSH 4A"
position. The aircraft shall then be towed forward to
with its nose wheel following the towed forward line
until its nose wheel is on the "END OF TOW 4B"
position behind aircraft Stand F59.

Standard pushback
approved.

Pushback approved,
to face East on
Twy C1
Standard pushback
approved.

Standard pushback
approved.

Pushback approved,
to pushback onto
Twy C6.
Pushback approved,
to pushback onto
Twy C6.

| JEPPESEN, 2009, 2013. ALL RIGHTS RESERVED.

WSSS/SIN
APRON/ACFT
STANDS
F50

F52L
F52R

F54

F56, F56L,
F56R

F58, F60
F59, F59L,
F59R

1, 2

3, 4, 5, 6,
7, 8, 9, 10

11,12,13

14

JEPPESEN
15 FEB 13

10-9L5

SINGAPORE, SINGAPORE
CHANGI

PUSHBACK PROCEDURES

The aircraft shall be pushed back with the main gear


following the main gear pushback line, facing South
until its nosewheel is on the "END OF PUSH" Stopbar
1 marking painted on the ground behind aircraft stand
F50. The aircraft shall then be towed forward with
the nosewheel following the tow-forward line until
its nosewheel is on the "END OF TOW" Stopbar 3
marking painted on the ground behind aircraft stand
F52.
The aircraft (on idle thrust) shall be pushed back to
face South until its nosewheel is at the intersection
of the aircraft push back line and Taxilane C6.
The aircraft (on idle thrust) shall be pushed back to
face South until its nosewheel is at the intersection
of the aircraft push back line and Taxilane C6. The
aircraft shall then be towed forward until its
nosewheel is on the "END OF TOW" position.
The aircraft (on idle thrust) shall be pushed back
until its nosewheel is at a point on Twy C6 in
line with the mid-point of aircraft stands F52 and
F54. It shall breakaway from this position.
The aircraft (on idle thrust) shall be pushed back
to face South until its nosewheel is at the
intersection of the aircraft pushback line and taxilane
C6. The aircraft shall then be towed forward until its
nosewheel is abeam stand F56.
The aircraft (on idle thrust) shall be pushed back to
face North (or South), on Twy C6 centerline.
The aircraft (on idle thrust) shall be pushed back to
face North on taxilane C6 centerline until its
nosewheel is abeam Bay F60.
OR
The aircraft (on idle thrust) shall be pushed back
to face South on taxilane C6 centerline.
BUDGET TERMINAL
The aircraft (on idle thrust) shall be pushed back to
face West onto Twy L7 until its nosewheel is at the
stopbar marked "END OF PUSH" behind aircraft stand
2. The aircraft may breakaway from there.
Simultaneous pushback is not permitted for aircraft
stands 1, 2 and 3.
OR
The aircraft (on idle thrust) shall be pushed back
onto Twy L5 to face North until its nosewheel is
behind the stopbar behind aircraft stand 3. The
aircraft may breakaway from there. Simultaneous
pushback is not permitted for aircraft stands
1, 2 and 3.
Pushback from aircraft stands 1 and 2 to face South
is not permitted.
The aircraft (on idle thrust) shall be pushed back
onto Twy L5 to face North or South until its
nosewheel is at the intersection of the aircraft stand
lead-in line and the centerline of Twy L5. The
aircraft may breakaway from there. There shall be
no simultaneous pushback of aircraft unless there
is at least one aircraft stand separation.
Simultaneous pushback is not permitted for aircraft
stands 1, 2 and 3.
The aircraft (on idle thrust) shall be pushed back
onto Twy L5 to face North or South until its
nosewheel is at the "END OF PUSH (EOP)" position
and the centerline of Twy L5. The aircraft may
breakaway from there. There shall be no simultaneous
pushback of aircraft unless there is at least one
aircraft stand separation.
The aircraft (on idle thrust) shall be pushed back
onto Twy L5 to face North until its nosewheel is at
the "END OF PUSH (EOP)" position and the centerline
of Twy L5. The aircraft may breakaway from there.
There shall be no simultaneous pushback of aircraft
unless there is at least one aircraft stand separation.

CHANGES: Pushback procedures for F56 and F59 aircraft stands.

PHRASEOLOGY USED
BY SINGAPORE
GROUND
Standard pushback
approved.

Standard pushback
approved.
Standard pushback
approved.

Standard pushback
approved.
Standard pushback
approved.

Pushback approved,
to face North (or
South).
Pushback approved,
to face North.
Pushback approved,
to face South.
Pushback approved,
to face West.

Pushback approved,
to face North.

Pushback approved,
to face North (or
South).

Pushback approved,
to face North or
South.

Pushback approved,
to face North.

| JEPPESEN, 2009, 2013. ALL RIGHTS RESERVED.

CHANGES: None.

clear of aircraft pushback from aircraft


stands C24, C25 & C26 until at end
of pushback.

clear of aircraft pushback from aircraft

stands A2, A3, A4, A5, B2, B4, B5 & B6

until at end of pushback.

stands F37 & F42 until at end of pushback.

clear of aircraft pushback from aircraft

until at end of pushback.

stands E6/F35 (Code E) & E7/F36

clear of aircraft pushback from aircraft

stand D49 until at end of pushback.

clear of aircraft pushback from aircraft

Aircraft taxiing on Twy NC3 are not

10-9L6

Aircraft taxiing on Twy EP are not

Advisory

Advisory

15 FEB 13

Aircraft taxiing on Twy C1 are not

Rwy 02C/20C

JEPPESEN

Advisory

until at end of pushback.

N01 21.6 E103 59.4

stands A9, A10, A13, A14, A15, A16 & A17

stand C26 until at end of pushback.

clear of aircraft pushback from aircraft

Aircraft taxiing on Twy NC3 are not

Advisory

Apt Elev

clear of aircraft pushback from aircraft


Rwy 02L/20R

Aircraft taxiing on Twy WA are not

Aircraft taxiing on Twy WA are not

Aircraft taxiing on Twy WA are not

Advisory

Advisory

Advisory

AERODROME ADVISORY CHART

WSSS/SIN
22'
SINGAPORE, SINGAPORE
CHANGI

| JEPPESEN, 2009, 2013. ALL RIGHTS RESERVED.

JEPPESEN

WSSS/SIN

SINGAPORE, SINGAPORE

10-9L7

8 JUN 12

CHANGI

E4

B1

13A

R
IE
TP
S
EA

H
UT
SO

3A

F40

F36

F52R
F52
F52L

E5

203

C3

C7

F60

C1

F59

C6

F42

C2

F37

T2 SOUTH APRON

F41

F54
F56
F58

F35

EP

F50

F34

B3

F33

7A

B2

T2 CENTRAL APRON

F32

F30

F31

12

10

TERMINAL 2

11

E3

E2

E1

E4

PUSHBACK PROCEDURES

CHANGES: Pushback and tow forward lines behind F33 and E4 revised.

| JEPPESEN, 2008, 2012. ALL RIGHTS RESERVED.

JEPPESEN

WSSS/SIN

SINGAPORE, SINGAPORE

10-9L8

8 JUN 12

CHANGI

15
16

E11

17

E6

EA
ST
PI
E
NO
RT
H

E10

18A

18

13A
CHANGES: Pushback and tow forward lines behind F33 and E4 revised.

F33

F32

F31

F30

7A

B3

B2

T2 CENTRAL APRON

10

12 11

TERMINAL 2

B1

E3

E2

E1

E4

E4

13

E5

E20

19

E22

E7

EP

T2

NO

E24

RT
H

AP
R

ON

E12

A5

E26

E8

A6

E27

T2 NORTH APRON

A4

E28

14

A7

D40

A3

E3

PUSHBACK PROCEDURES

| JEPPESEN, 2008, 2012. ALL RIGHTS RESERVED.

WSSS/SIN

JEPPESEN
23 DEC 11

10-9M

.PARKING.

SINGAPORE, SINGAPORE

CHANGI

SAFEGATE AIRCRAFT DOCKING GUIDANCE SYSTEM - SAFEDOCK


1. INTRODUCTION
1.1 The Safegate Aircraft Docking Guidance System - SAFEDOCK is a fully
automatic aircraft docking guidance system installed at the fixed gates in
Terminals 1, 2, and 3 of Singapore Changi Airport. There are two types of
ADGS in Singapore Changi Airport, Safedock Type 1 (T1) ADGS and
Safedock Type 2 (T2) ADGS.
2. DESCRIPTION OF SYSTEM
2.1 The system is based on a laser scanning technique and it tracks both the
lateral and longitudinal position of the aircraft. This 3D technique allows the
system to recognize the incoming aircraft and check it against the one
selected by the operator to ensure that the pilot is provided with the correct
stop indication for the aircraft.
2.2 The system is operated only in Automatic Mode. When the system fails, the
aircraft is to be marshalled into the stand manually.
2.3 Azimuth guidance, continuous closing rate information, aircraft type, etc., are
shown to the pilot on a single display clearly visible for both pilot and
co-pilots. Figure A shows the Display and Laser Scanning Unit mounted on the
terminal or pole in front of the aircraft stand.
LED DISPLAY AND LASER SCANNING UNIT

Safedock Type 1 (T1)

Safedock Type 2 (T2)

Figure A

B767

Aircraft Type
Digital Countdown

9M

B767
9M

Azimuth Guidance
Lead-in line
LED Closing
Rate Field

3. DOCKING PROCEDURES

Safedock
Type 1 (T1)

Safedock
Type 2 (T2)

B767

B767

Figure 1
System tracking
for aircraft.

B767

B767

Figure 2
Acft tracked and
system identifying
acft.
( depicts flashing
red arrow.)
( or depicts
solid yellow arrow.)

B767

B767

Figure 3
LED closing rate
field starts
diminishing when
the acft is 15m
from stopbar at one
row for every 0.5m
that the acft moves
forward.

3.1 Check that the correct aircraft


type is displayed. The scrolling
arrows indicate that the system is
activated (see figure 1).
3.2 Follow the lead-in line.
3.3 When the solid yellow closing rate
field appears, the aircraft has been
caught by the scanning unit. The
scanning unit now checks that the
aircraft is the correct type and the
display provides azimuth guidance
information (see figure 2).
3.4 Look for the flashing red arrow and
solid yellow arrow which provide
azimuth guidance information. The
flashing red arrow shows which
direction to steer, while the solid
yellow arrow gives an indication of how
far the aircraft is off the centerline
(see figures 2 and 3).
CHANGES: Text, graphic.

9M

9M

| JEPPESEN, 1998, 2011. ALL RIGHTS RESERVED.

WSSS/SIN

JEPPESEN
23 DEC 11

10-9N

SAFEDOCK-Continued.

3.5 When the aircraft is 15m from the stop


position, closing rate information is given.
"Distance to go" is indicated by turning off
one row of LEDs (Laser Electronic Displays)
for every half meter that the aircraft
advances towards the stop position. From
15m to the stop position, a digital display
will indicate the distance from the stop
position for every 1m. At 3m from the stop
position, the display will indicate the
distance from the stop position for every
0.2m (see figures 3 and 4).
3.6 When the correct stop position is reached,
all of the LEDs for the closing rate field
will be off, the word "STOP" will appear in
the display. For Safedock TI ADGS, the word
"STOP" will be displayed in red with red
border. For Safedock T2 ADGS, the word
"STOP" will be displayed in yellow and two
red, rectangular fields will light in the
azimuth guidance area of the display
(see figure 5).
3.7 If the aircraft stops in the correct position,
"OK" will be displayed after a few seconds
(see figure 6).
3.8 If the aircraft has gone past the correct stop
position, the display will show "TOO FAR"
(see figure 7).
3.9 If some object is blocking the view towards
the approaching aircraft or the detected
aircraft is lost before 12m to the correct
stop position, the system will show "WAIT"
(see figure 8).
3.10 The aircraft must be identified at least 12m
before the correct stop position. Otherwise,
the display will show "WAIT", "STOP" and
"ID FAIL" (see figures 8, 9 and 10).

.PARKING.

SINGAPORE, SINGAPORE

CHANGI

Safedock
Type 1 (T1)
B767
1.8M

STOP

Safedock
Type 2 (T2)
B767

Figure 4
LED closing
rate field
getting
shorter
as acft
moves nearer
to stopbar.

STOP

Figure 5
Pilot to stop
acft when
"STOP" is
displayed.

1.8M

OK

OK

TOO
FAR

TOO
FAR

WAIT

WAIT

STOP

STOP

4. SAFETY MEASURES

4.1 Pilot should not turn an aircraft into the


parking stand if the docking system is not
activated or on seeing a wrong aircraft type
displayed on the system.
4.2 When using the docking system, pilots are to
taxi into the aircraft stand at minimum
speed. The system will display "SLOW
DOWN: to inform the pilot if the aircraft's
taxiing speed is too fast (see figure 11).
4.3 To avoid overshooting, pilots are advised to
approach the stop position slowly and
observe the closing rate information
displayed. Pilots should stop the aircraft
immediately when seeing the "STOP"
display or when given the stop sign by the
aircraft marshaller.
4.4 Pilot should stop the aircraft immediately if
the display goes black during the docking
process. The aircraft is to be marshalled into
the stand manually.
CHANGES: Text, graphic.

STOP

ID

ID
FAIL

Figure 6
Informs the
pilot that
everything
is in order
and he can
shutdown
engine.
Figure 7
Indicates that
the acft has
gone beyond
the stopbar.
Pilot to
check with
ground
engineer on
the next
move.
Figure 8
Pilot to hold
acft and wait
for other
instructions
from the
display.
Figure 9
'STOP' may
appear
suddenly in
the process
of docking.
Pilot to stop
immediately
and wait for
further
instructions.
Figure 10
Indicates
the system
failed to
identify the
acft.

FAIL

SLOW
1.8M

SLOW
DOWN

Figure 11
Informs the
pilot that the
acft traveling
speed is too
fast. Pilot to
slow down
the speed.

| JEPPESEN, 1998, 2011. ALL RIGHTS RESERVED.

WSSS/SIN

JEPPESEN
23 NOV 12

10-9P

.PARKING.

SINGAPORE, SINGAPORE
CHANGI

Aircraft types that can be parked at stands (o) are as follows:


TERMINAL 1 AIRCRAFT STANDS
Aircraft
Type
C1 C11 C13 C15 C16 C17 C18 C19 C20 C22 C23 C24 C25 C26
A300
A310
A319
A320
A321
A332
A333
A342
A343
A345
A346
A380
B707
B717
B727
B737
B747
B74S
B757
B762
B763
B772
B773
B773ER
B788
BA146
DC10
DC9
F100
IL62
IL86
IL96
L101
MD11
MD80
MD82
MD88

CHANGES: B788 aircraft stands C18 and C24 revised.

| JEPPESEN, 2004, 2012. ALL RIGHTS RESERVED.

WSSS/SIN

JEPPESEN
23 NOV 12

10-9Q

.PARKING.

SINGAPORE, SINGAPORE
CHANGI

Aircraft types that can be parked at stands (o) are as follows:


TERMINAL 1 AIRCRAFT STANDS (contd)
Aircraft
Type
D30 D32 D34 D35 D36 D37 D38 D40 D41 D42 D44 D46 D47 D48 D49
A300
A310
A319
A320
A321
A332
A333
A342
A343
A345
A346
A380
B707
B717
B727
B737
B747
B74S
B757
B762
B763
B772
B773
B773ER
B788
BA146
DC10
DC9
F100
IL62
IL86
IL96
L101
MD11
MD80
MD82
MD88
YK42

CHANGES: B788 stand D47 revised.

| JEPPESEN, 2004, 2012. ALL RIGHTS RESERVED.

WSSS/SIN

JEPPESEN
15 MAR 13

10-9R

.PARKING.

SINGAPORE, SINGAPORE

CHANGI

Aircraft types that can be parked at stands (o) are as follows:


TERMINAL 2 AIRCRAFT STANDS
Aircraft
Type
E1 E2 E3 E4 E5 E6 E7 E8 E10 E11 E12 E20 E22 E24 E24LE24R E26 E27 E28 F30
A300
A310
A319
A320
A321
A332
A333
A342
A343
A345
A346
A380
B707
B727
B737
B747
B74S
B757
B762
B763
B772
B773
B773ER
B788
DC10
DC9
F70
F100
IL62
IL86
IL96
L101
MD11
MD80
MD82
MD87
MD88
CHANGES: B788 added.

| JEPPESEN, 2004, 2013. ALL RIGHTS RESERVED.

WSSS/SIN

JEPPESEN
15 MAR 13

10-9R1

.PARKING.

SINGAPORE, SINGAPORE

CHANGI

Aircraft types that can be parked at stands (o) are as follows:


TERMINAL 2 AIRCRAFT STANDS (contd)
Aircraft
Type F31 F32 F33 F34 F35 F36 F37 F40 F41 F42 F50 F52 F52L/R F54 F56 F56L/R F58 F59 F59L/R F60
A300
A310
A319
A320
A321
A332
A333
A342
A343
A345
A346
A380
B707
B727
B737
B747
B74S
B757
B762
B763
B772
B773
B773ER
B788
DC10
DC8
DC9
F70
L101
MD11
MD87

CHANGES: B788 parking stand revised.

| JEPPESEN, 2004, 2013. ALL RIGHTS RESERVED.

WSSS/SIN

JEPPESEN
14 MAR 14

10-9R2

.PARKING.

SINGAPORE, SINGAPORE

CHANGI

Aircraft types that can be parked at stands (o) are as follows:


TERMINAL 3 Aircraft Type / Stands
A1 A2 A3 A4 A5 A9 A10 A11 A12

A300, A310, A319, A320, A321


A332, A333, A343
A345
A346
A380
B737
B744
B74S
B757, B767
B772
B773, B773ER
B788
TERMINAL 3 (contd) Aircraft
Type / Stands
A300, A310, A319, A320, A321

A13 A14 A15 A16 A17 A18 A19 A20 A21

A332
A333, A343
A345
A346
A380
B737
B744
B74S
B757, B767
B772
B773, B773ER
B788
TERMINAL 3 (contd) Aircraft
Type / Stands
A300, A310, A319, A320, A321

B1 B2 B3 B4 B5 B6 B7

B8 B9 B10

A332, A333, A343, A345


A346, A380
B707
B737
B744
B74S
B757, B767
B772
B773, B773ER
B788
CHANGES: B788 added.

| JEPPESEN, 2004, 2014. ALL RIGHTS RESERVED.

WSSS/SIN

JEPPESEN
14 MAR 14

10-9R3

.PARKING.

SINGAPORE, SINGAPORE

CHANGI
BUDGET TERMINAL - Aircraft types that can be parked at stands (o) are as follows:
Aircraft Type / Stands
1
2 3 4 5 6 7 8 9 10 11 12 13 14
A319, A320, AT72, B737, DHC7
A321
REMOTE STANDS - Aircraft types that can be parked at stands (o) are as follows:
Aircraft Type / Stands 103 104 200 200L/R 201 202 202L/R 203 205 206 207 208 209

A300, A310
A319, A320
A321
A330, A342, A343, A345
A380
AT72
B707, B727
B737
B747, B74S, B788
B748
B757
B767, B772, B773, B773ER
DC8
DC10
DHC7
F70
IL62
L101
MD11
REMOTE STANDS - Aircraft types that can be parked at stands (o) are as follows:
Stands 300 301 302 303 304 305 306 307 308 309 310 400 401 402 403 404
Acft Type
A300, A310

A319, A320
A330, A342
A343, A345
AT72
B707
B727
B737
B747
B74S, B788
B757, B767
B772, B773
B773ER
DC10
DC8
F70
L101
MD11
CHANGES: Budget stands added.

| JEPPESEN, 2004, 2014. ALL RIGHTS RESERVED.

WSSS/SIN

JEPPESEN
22 NOV 13

10-9R4

.PARKING.

SINGAPORE, SINGAPORE

CHANGI

MARS STANDS - Aircraft types that can be parked at stands (o) are as follows:
Aircraft Type / Stands

101 101L 101R 102 102L 102R

A300
A310
A319
A320
A321
A332
A333
A342
A343
A345
A380
B737
B747
B748
B757
B762
B763
B772
B773
B773ER
B787-8

CHANGES: None.

| JEPPESEN, 2004, 2013. ALL RIGHTS RESERVED.

WSSS/SIN

JEPPESEN
22 NOV 13

10-9R5

.PARKING.

SINGAPORE, SINGAPORE

CHANGI

Aircraft types that can be parked at stands (o) are as follows:


CARGO STANDS
Aircraft
Type
502 503 504 505 506 507 508 509 601 602 603 604 611 612
A300
A306
A310
A330
A332
A333
A342
A343
A345
A346
A380
B707
B727
B737
B744
B747
B748
B74S
B752
B753
B757
B762
B763
B767
B772
B772LR
B773
B773ER
B777F
DC8
DC10
IL62
IL86
L101
MD11

CHANGES: A330 cargo stands.

| JEPPESEN, 2013. ALL RIGHTS RESERVED.

SINGAPORE Approach (R)

LOC

TM

SINGAPORE Arrival (R)

120.3

SINGAPORE Tower

Ground

118.6

124.3

119.3

Final
Apch Crs

GS
ILS
Apt Elev
DA(H)
ANUMA
Rwy 02L
(3478')
(200')
MISSED APCH: Climb to 1000', then climbing LEFT turn to 4000' via
heading 335^ and PU R-356 to AKOMA (PU R-356/D20.0) and hold or as
directed by ATC.
ICW

110.9

023^

3500'

222'

22'

180^

D-ATIS

128.6

11-1

22'

3400'

090^

Alt Set: hPa

Rwy Elev: 1 hPa


Trans level: FL 130
Trans alt: 11000'
2. Simultaneous approaches authorized with Rwy 02R or 02C.
3. ILS DME co-located with glideslope. 4. Maritime vessels of variable heights in
water north and south of Rwy.

1900'

2100'

360^

25 NOV 11

CHANGI

BRIEFING STRIP

SINGAPORE, SINGAPORE
ILS DME Rwy 02L

JEPPESEN

WSSS/SIN

1. RADAR required.

20

Seletar

WS(D)-35
WS(P)-3

15

942'
WS(P)-49

10

ABVON
D0.7 ICW

ADNIK

1017'

S113.5JSJ
SINJON

ICW
ILS DME

023
^

AKIPO

WS(D)-4

D11.1 ICW

500

APIPA

D7.8 ICW

02 .9
3 3^

SIA
NE
O
IND

023^ 110.9 ICW

ANUMA

168^

01-10

TEKONG

116.5 VTK

CAUTION: Changi East Rwy


02R/20L is solely for use by
the Republic of Singapore
Air Force (RSAF) Aircraft
WS(R)-31
MALAYSIA
E
SINGAPOR
INDONESIA

440'

D4.6 ICW
WS(P)-24

VTK

656'

D20.0 PU

WS(D)-34
611'

Paya Lebar

WS(R)-38
WS(D)-33
523'
WS(D)-1
637'

01-20 550'

AKOMA

680'

SINGAPORE

WS(P)-36

356^

WS(D)-5
437'

MA
LAY
SIA

4000
PU
356^
115.1 176^

115.1 PU
PU

602'

hdg

335^

500'

PAPA UNIFORM

WS(R)-2

MISSED
APCH FIX

356^

WM(P)-228
630'

MSA VTK VOR

436'

Hang Nadim

D16.0 ICW

3500

ANUMA

104-00

620'

104-10

ICW DME

4.0

3.0

2.0

ALTITUDE

1290'

970'

660'

AKIPO

D11.1 ICW

3500'

535'

D16.6 ICW
D8.0 SJ/R-168

348^

103-50

LOC
(GS out)

SAMKO

1
4
D8 /1
4000

168^

1 FMS required for


holding during SJ VOR
outage.

D7.8 ICW

023^

ADNIK

D4.6 ICW

ABVON
D0.7 ICW

2500'

TCH 58'

1500'
3.3

Gnd speed-Kts

3.2

70

90

100

120

3.9

140

160

3.00^ 372 478 531 637 743 849


3.9 3:21 2:36 2:20 1:57 1:40 1:28

GS

1 FAF to MAP
MAP at ABVON/D0.7 ICW

ILS

DA(H)

FULL

PANS OPS

RVR
VIS

550m
800m

222'(200')

TDZ or CL out
RVR
VIS

ALSF-II
REIL
PAPI

PAPI

720m
800m

22'

1000' 4000' 335^


via
hdg
LT
CIRCLE-TO-LAND

STRAIGHT-IN LANDING RWY02L

LOC (GS out)

MDA(H)

ALS out
1200m

420'(398')

ALS out

RVR

Rwy 02L

0.5

VIS

720m
800m

RVR
VIS

1500m
1600m

A
B
C

1200m

RVR
VIS

1800m
2000m

NA

1 Timing not authorized when GS inop.

CHANGES: Tower frequency.

| JEPPESEN, 1998, 2011. ALL RIGHTS RESERVED.

SINGAPORE Tower

119.3

Final
Apch Crs

124.3

GS
CAT II ILS
Apt Elev
ANUMA
Refer to
Rwy 02L
(3478')
Minimums
MISSED APCH: Climb to 1000', then climbing LEFT turn to 4000' via
heading 335^ and PU R-356 to AKOMA (PU R-356/D20.0) and hold or as
directed by ATC.
ICW

110.9

023^

Alt Set: hPa

3500'

Rwy Elev: 1 hPa

Ground

118.6

Trans level: FL 130

22'

180^

LOC

TM

SINGAPORE Arrival (R)

120.3

22'

3400'

090^

Trans alt: 11000'

1. Special Aircrew and Acft Certificaton Required. 2. RADAR requried.

3. Simultaneous approaches authorized with Rwy 2R or 2C. 4. ILS DME co-located with
glideslope. 5. Maritime vessels of variable heights in water north and south of Rwy.

Seletar

WS(D)-35
WS(P)-3

20

WS(D)-33
WS(D)-1
637'

1017'

WS(P)-24

S113.5JSJ
SINJON

ICW

APIPA

ANUMA

D11.1 ICW

023.9^

168^

SIA
NE
O
IND

023^ 110.9 ICW

023
^

ILS DME

WS(D)-4

01-10

TEKONG

116.5 VTK

CAUTION: Changi East Rwy


02R/20L is solely for use by
the Republic of Singapore
Air Force (RSAF) Aircraft
WS(R)-31
MALAYSIA
E
SINGAPOR
INDONESIA

440'

WS(R)-38

656'

VTK

523'

10

01-20 550'

D20.0 PU

WS(D)-34
611'

Paya Lebar

350
0

15

942'
WS(P)-49

AKOMA

680'

SINGAPORE

WS(P)-36

356^

WS(D)-5
437'

MA
LAY
SIA

4000
PU
356^
115.1 176^

115.1 PU
PU

602'

hdg

WS(R)-2

335^

500'

PAPA UNIFORM

MSA VTK VOR


MISSED
APCH FIX

356^

WM(P)-228
630'

1900'

2100'

360^

SINGAPORE Approach (R)

128.6
BRIEFING STRIP

11-1A

25 NOV 11

CHANGI
D-ATIS

SINGAPORE, SINGAPORE
ILS DME Rwy 02L CAT II

JEPPESEN

WSSS/SIN

436'

Hang Nadim

D16.0 ICW

3500

535'

D16.6 ICW
D8.0 SJ/R-168

348^

103-50

SAMKO

1
4
D8 /1
4000

168^

1 FMS required for


holding during SJ VOR
outage.

104-00

620'

104-10

ANUMA

D11.1 ICW

3500'

023^
TCH 58'

Rwy 02L

10.9

Gnd speed-Kts
GS

70
3.00^ 372

90

100

120

140

160

478

531

637

743

849

ALSF-II
REIL
PAPI

PAPI

22'

1000' 4000' 335^


via
LT

hdg

STRAIGHT-IN LANDING RWY02L


CAT A B C

PANS OPS

RA 112'
DA(H) 122'(100')
RVR

CHANGES: Tower frequency.

350m

CAT II ILS

CAT D

RA 131'
DA(H) 127'(105')
RVR

350m

| JEPPESEN, 1998, 2011. ALL RIGHTS RESERVED.

LOC
ICE

Final
Apch Crs

108.3

023^

119.3
GS
LEPNA
(4485')

SINGAPORE Tower

118.6
ILS
DA(H)
(200')

4500'

215'

Ground

*118.25

Apt Elev

22'

Rwy 02C

15'

MISSED APCH: Climb to 3000' via heading 023^ and VTK R-023 to NYLON
(VTK R-023/D13.0) and hold or as directed by ATC.
Alt Set: hPa

Rwy Elev: 1 hPa

124.3
180^

SINGAPORE Arrival (R)

120.3

3400'

090^

1900'

2100'

Trans level: FL 130

Trans alt: 11000'

1. RADAR required.

2. Simultaneous approaches authorized with Rwy 2R or 2L. 3. ILS DME


co-located with glide slope. 4. Maritime vessels of variable heights in water north and south
of Rwy.

VTK
V116.5T K
TEKONG

MISSED
APCH FIX

WS(D)-34

023^

WS(P)-36

611'

NYLON

D13.0 VTK

CAUTION: Changi East Rwy


02R/20L is solely for use by
the Republic of Singapore
Air Force (RSAF) Aircraft

Paya Lebar
10

MSA VTK VOR

680'

hdg

Seletar

01-20 WS(R)-38

360^

SINGAPORE Approach (R)

203
^ VT
D1
3/1 02 K
023
9 1 3^
16.
^
300
5
0

D-ATIS

128.6
TM

11-2

25 NOV 11

CHANGI

BRIEFING STRIP

SINGAPORE, SINGAPORE
ILS DME Rwy 02C

JEPPESEN

WSSS/SIN

440'

523'

LAGUS
D0.7 ICE

LUXOL

D2.0 ICE

1017'

SJ
SINJON

MALAYSIA
RE
SINGAPO
INDONESIA

LASIN

113.5 SJ

D4.6 ICE

ICE
ILS DME

023^ 108.3 ICE

LEPNA

NOT TO
SCALE

during SJ VOR outage.

500

436'

Hang Nadim

LIDVA

104-00

D16.0 ICE

348^

D15.6 ICE
D8.0 SJ

4
D8 /1
168^
SJ
000
^4
113.5 168

SAMKO

104-10

LOC
(GS out)

4500

LEPNA

ICE DME

4.0

3.0

ALT

1290'

970'

LELON

D14.2 ICE

D7.8 ICE

4500' 023^

LASIN LUXOL

D4.6 ICE D2.0 ICE LAGUS


D0.7 ICE
LOC
(GS out)

2500'
6.4

Gnd speed-Kts

3.2

70

90

100

120

1500'

140

2.6

160

PAPI
REIL

1 FAF to MAP
MAP at LAGUS/D0.7 ICE

ILS
DA(H)

FULL

PANS OPS

A
B

RVR

VIS

STRAIGHT-IN LANDING RWY02C

215'(200')

720m
800m

1200m

420'

RVR
VIS

720m
800m

RVR
VIS

1500m
1600m

RVR
VIS

1800m
2000m

TCH 59'

Rwy 02C

15'

3000' 023^ VTK


via
and 116.5
hdg
R-023
CIRCLE-TO-LAND

660'

MDA(H)
(645')
Without LUXOL/D2.0 ICE

ALS out

1200m

0.5

PAPI

LOC (GS out)

MDA(H)
(405')
With LUXOL/D2.0 ICE

ALS out

1.3
ALSF-I

3.00^ 372 478 531 637 743 849


3.9 3:21 2:36 2:20 1:57 1:40 1:28

GS

01-10

1 FMS required for holding

D14.2 ICE
.8
0
2
3
^
4

023
^

LELON

D7.8 ICE

ALS out
RVR
VIS

720m
800m

1800m
2000m
2400m

RVR
VIS

RVR
VIS

1500m
1600m B

2800m

3200m

NA

Timing not authorized when GS inop.

CHANGES: Tower frequency, notes.

| JEPPESEN, 1998, 2011. ALL RIGHTS RESERVED.

SINGAPORE Approach (R)

128.6

SINGAPORE Arrival (R)

120.3

LOC
ICC

Final
Apch Crs

109.7

203^

119.3

SINGAPORE Tower

118.6

GS
ELALU
(4485')

ILS
DA(H)
(200')

4500'

Ground

*118.25
22'

124.3

Apt Elev

215'

RWY 20C

MISSED APCH: Climb to 4000' via VTK R-203 to ESLUX (D6.7 VTK). At

180^

D-ATIS
TM

11-3

22 JUL 11

CHANGI

15'

3400'

090^

ESLUX (1000' or above) turn LEFT heading 130^ to intercept VTK R-158
to EXOMO (VTK R-158/D22.0) and hold or as directed by ATC.
Alt Set: hPa

Rwy Elev: 1 hPa

Trans level: FL 130

2100'

Trans alt: 11000'

1. RADAR required. 2. Simultaneous approaches authorized with Rwy 20L or 20R. 3. ILS DME
co-located with glide slope. 4. Maritime vessels of variable heights in water north and south
of Rwy.

203

500'

^
NOT TO
SCALE

ICC
V116.5T VTK
K
ILS DME

203^ 109.7 ICC


M
SI AL
NG A
A YSI
PO A
RE

0 23

450
0

10

ELALU

D14.2 ICC

01-30

203.8^

D16.0 ICC

4500

91

D1

EGORA

3/1

20 3

D16.7 ICC
D13.0 VTK

573'

MSA VTK VOR

^ V
T
023K
16. ^
30 0
5
0

NYLON

1900'

360^

BRIEFING STRIP

SINGAPORE, SINGAPORE
ILS DME Rwy 20C

JEPPESEN

WSSS/SIN

ELBEB

D7.8 ICC
602'

TEKONG

ELMIN

D4.6 ICC

Seletar

627'

680'
WS(D)-34

WS(P)-36

611'

ESBIT

D0.7 ICC

Paya Lebar

104-10

CAUTION: Changi East Rwy


02R/20L is solely for use by
the Republic of Singapore
Air Force (RSAF) Aircraft

01-20

LOC
(GS out)

MISSED
APCH FIX

INDONESIA
3.0
970'

2.0
650'

ICC DME
ALTITUDE

4.0
1290'

ELALU

ELBEB

ESBIT

2500'

TCH 58'

1500'

15'

0.5

Gnd speed-Kts

70

3.9

90

100

120

3.2

140

1 FAF to MAP

ALSF-II
PAPI
REIL

MAP at ESBIT/D0.7 ICC

ILS

DA(H)

FULL
PANS OPS

RVR

VIS

550m
800m

215'(200')

TDZ or CL out
RVR
VIS

4000'

720m
800m

VTK

via

116.5

R-203

STRAIGHT-IN LANDING RWY20C

ESLUX

CIRCLE-TO-LAND

LOC (GS out)

MDA(H)

ALS out

A
B

6.4

160

3.00^ 372 478 531 637 743 849


3.9 3:21 2:36 2:20 1:57 1:40 1:28

GS

4500'

203^

D4.6 ICC

D0.7 ICC
RWY 20C

D14.2 ICC

D7.8 ICC

ELMIN

00
^ 40

104-00

VTK ^
158 .5
6
^ 11

dg

920'

D22.0 VTK
338

13
0^ h

158

D6.7 VTK

EXOMO

SIA
LAY
E
MA
POR
GA
SIN

ESLUX

440'

8^
VTK 5 15
116.

WS(R)-38

ALS out

RVR
VIS

1200m

420'(405')

720m
800m

1200m

RVR
VIS

1500m
1600m

RVR
VIS

1800m
2000m

NA

1 Timing not authorized when GS inop.

CHANGES: Tower communications, aircraft speed restriction note removed.

| JEPPESEN, 1998, 2011. ALL RIGHTS RESERVED.

128.6

SINGAPORE Arrival (R)

120.3

LOC
ICC

Final
Apch Crs

109.7

203^

SINGAPORE Tower

119.3

*118.25
Apt Elev 22'

GS
CAT II ILS
ELALU
(4485') DA(H) 115'(100') RWY 20C

RA 102'

4500'

Ground

118.6

MISSED APCH: Climb to 4000' via VTK R-203 to ESLUX (D6.7 VTK). At

124.3
180^

SINGAPORE Approach (R)

15'

3400'

090^

ESLUX (1000' or above) turn LEFT heading 130^ to intercept VTK R-158
to EXOMO (VTK R-158/D22.0) and hold or as directed by ATC.
Alt Set: hPa

Rwy Elev: 1 hPa

Trans level: FL 130

2100'

Trans alt: 11000'

1. RADAR required. 2. Simultaneous approaches authorized with Rwy 20L or 20R. 3. ILS DME
co-located with glide slope. 4. Maritime vessels of variable heights in water north and south
of Rwy.

M
SI AL
NG A
A YSI
PO A
RE

0 23

450
0

203

500'

NOT TO
SCALE

ICC
V116.5T VTK
K
ILS DME

203^ 109.7 ICC

203.8^

10

ELALU

D14.2 ICC

01-30

D16.0 ICC

4500

91

D1

EGORA

3/1

20 3

D16.7 ICC
D13.0 VTK

573'

MSA VTK VOR

^ V
T
023K
16. ^
30 0
5
0

NYLON

602'

TEKONG

Seletar

627'

680'
WS(D)-34

WS(P)-36

611'

Paya Lebar

104-10

01-20

104-00

VTK ^
158 .5
6
^ 11

dg

920'

D22.0 VTK
338

13
0^h

00
^ 40

D6.7 VTK

EXOMO

SIA
LAY RE
MA
PO
GA
SIN

ESLUX

8^
VTK 5 15
116.

440'

158

CAUTION: Changi East Rwy


02R/20L is solely for use by
the Republic of Singapore
Air Force (RSAF) Aircraft

WS(R)-38

1900'

360^

D-ATIS
TM

11-3A

22 JUL 11

CHANGI

BRIEFING STRIP

SINGAPORE, SINGAPORE
ILS DME Rwy 20C CAT II

JEPPESEN

WSSS/SIN

MISSED
APCH FIX

INDONESIA

ELALU

D14.2 ICC

4500'

203^
TCH 58'

RWY 20C
Gnd speed-Kts
GS

15'

14.0

70
3.00^ 372

90

100

120

140

160

478

531

637

743

849

ALSF-II
PAPI
REIL

4000'

VTK

via

116.5

R-203

ESLUX

STRAIGHT-IN LANDING RWY20C

CAT II ILS

RA 102'
115'(100')

PANS OPS

DA(H)

RVR

350m

CHANGES: Twr comms, acft speed restriction note removed, profile, minimums.

| JEPPESEN, 1998, 2011. ALL RIGHTS RESERVED.

SINGAPORE Arrival (R)

120.3

LOC
ICH

Final
Apch Crs

108.9

203^

SINGAPORE Tower

119.3
GS
IGULA
(3487')

ILS
DA(H)
(200')

3500'

Ground

118.6 *118.25
Apt Elev

213'

Rwy 20R

124.3
180^

SINGAPORE Approach (R)

17'

13'

3400'

MISSED APCH: Climb straight ahead to 5000'. On crossing SJ R-146,

090^

proceed direct SAMKO holding area and hold or as directed by ATC.

Alt Set: hPa

Rwy Elev: 1 hPa

Trans level: FL 130

1900'

2100'

Trans alt: 11000'

1. RADAR required.

2. Simultaneous approaches authorized with Rwy 20L or 20C. 3. ILS DME


co-located with glide slope. 4. Maritime vessels of variable heights in water north and south
of rwy.

500

.9
2
0
3
3
^

30
00

VT
02 K
1163^
.5
9

D1

WM(D)-230

3/1

3500

20
3^

IPNAK

D16.0 ICH

MSA VTK VOR

02
3^

NOT TO SCALE

360^

D-ATIS

128.6
TM

11-4

8 JUN 12

CHANGI

BRIEFING STRIP

SINGAPORE, SINGAPORE
ILS DME Rwy 20R

JEPPESEN

WSSS/SIN

NYLON

203
^

10

D16.2 ICH
D13.0 VTK

01-30

IDVAS

ICH
ILS DME

D7.8 ICH

203^ 108.9 ICH


5

IGULA

D11.1 ICH

during SJ VOR outage.


621'

500'

VTK

IDURO

TEKONG

D4.6 ICH

MALAYSIA
SINGAPORE

116.5 VTK

104-10
MISSED
APCH FIX

680'

Seletar

Paya Lebar Aero

611'

SJ
SJ

WS(D)-34

SJ
168^
113.5

D0.8 ICH

CAUTION: Changi East Rwy


02R/20L is solely for use by
the Republic of Singapore
Air Force (RSAF) Aircraft

761'

104-00

LOC
(GS out)

3.0
970'

2.0
650'

ICH DME
ALTITUDE

4.0
1290'

IGULA

IDVAS

IDURO

D0.8 ICH

13'

Gnd speed-Kts

0.6

70

2500'
1500'

3.8

90

100

120

3.2

140

160

3.3

HIALS

GS

3.00^ 372 478 531 637 743 849 REIL


3.9 3:21 2:36 2:20 1:57 1:40 1:28 PAPI
1 FAF to MAP
MAP at IDUNA/D0.8 ICH
STRAIGHT-IN LANDING RWY 20R

ILS

PANS OPS

DA(H)

A
B
C
D

FULL
RVR

720m

VIS

800m

PAPI

SJ

5000'on

crossing 113.5

R-146

SAMKO

CIRCLE-TO-LAND

LOC (GS out)

213'(200')

MDA(H)

ALS out
1200m

3500'

203^

TCH 57'

Rwy 20R

D11.1 ICH

D7.8 ICH

D4.6 ICH

IDUNA

D8.0 SJ

4
D8/1
5000

440'

168^

WS(R)-38

SAMKO

348^

SIA
L AY E
MA
PO R
GA

SIN

01-20

SJ 6 ^
14 13.5
1

IDUNA

WS(P)-36

1 FMS required for holding

RVR
VIS

720m
800m

1200m

420'(407')

ALS out

1500m
1600m
RVR 1800m
VIS 2000m
RVR
VIS

A
B
C
D

NA

Timing not authorized when GS inop.

CHANGES: Communications, rwy and apt elevation, notes, lighting.

| JEPPESEN, 1998, 2012. ALL RIGHTS RESERVED.

SINGAPORE Approach (R)

SINGAPORE Arrival (R)

120.3

119.3

Final
Apch Crs

118.6 *118.25
17'

Procedure Alt
LNAV/VNAV
Apt Elev
DA(H)
C~2LF
RNAV
Rwy 02L
(2483')
(513')
MISSED APCH: Climb to 1000', then climbing LEFT turn to 4000' via
heading 335^ and outbound PU VOR R-356 to AKOMA (PU VOR
R-356/D20.0) and hold or as directed by ATC.

023^

2500'

Ground

530'

124.3
180^

128.6

SINGAPORE Tower

17'

3400'

090^
2100'

Alt Set: hPa


Rwy Elev: 1 hPa
Trans level: FL 130
Trans alt: 11000'
1. Minimum temperature for which Baro-VNAV operations are authorized: 15^C.
2. Maritime vessels of variable heights in water north and south of runway.
WM(P)-228
621'

AYSI

20

WS(D)-5

AKOMA

Seletar
942'

15

656'

RW~2L

WS(R)-38

538'

CAUTION: Changi East Rwy


02R/20L is solely for use by
the Republic of Singapore
Air Force (RSAF) Aircraft

637'
920'

(IF)

SAPAX

290^
.5

3900

168^

1SANAT
4000

535'

4000

4000

620'

348^

SJ

104-00

SAPAX

4000'

023^
2000'

2500'
[3.00
^]

1000'

70

90

100

120

140

160

478

531

637

743

849

LNAV/VNAV

530'(513')

MDA(H)

ALS out

PANS OPS

2000m

2800m

CHANGES: Hold designation revised.

0
ALSF-II

REIL
PAPI

PAPI

17'

1000' 4000' 335^


via
hdg
LT
CIRCLE-TO-LAND

LNAV

580'(563')

ALS out

RVR
VIS

Rwy 02L

5.0
5.0

372

MDA

2.6
7.6

7.6 6:31 5:04 4:34 3:48 3:15 2:51


STRAIGHT-IN LANDING RWY02L

DA(H)

RW~2L

1670'

[TCH 50']

4.4

[3.00^]

C~2LS

660'

12.0
Descent angle
MAP at RW~2L
C~2LF to MAP

104-10

C~2LF

3900'

SANAT
SAMKO

Gnd speed-Kts

1 Max IAS 220 Kts.

1 SAMKO

0.4 NM
to SAPAX

Hang Nadim

436'

(IAF)

D14.0

01-00

(IAF)

5. 9

390

013^
4

01-10

168^

E
POR
A
G
SIN ESIA
ON
IND

WS(D)-4

C~2LF

023
^

10

SJ
SINJON

113.5 SJ

WS(R)-31

MALAYSIA
SINGAPORE
INDONESIA

C~2LS

WS(P)-24

V116.5T VTK
K
TEKONG

WS(P)-3

D20.0 PU

WS(D)-34
611'

Paya Lebar Aero

WS(D)-35

WS(P)-49

01-20

WS(P)-36

356^

hdg

MAL

PU 4000
356^
115.1 176^

115.1 PU
PU

WS(R)-2

335^

500'

PAPA UNIFORM

MSA VTK VOR

MISSED
APCH FIX

356^

620'

1900'

360^

D-ATIS

TM

12-1

31 AUG 12

CHANGI

BRIEFING STRIP

SINGAPORE, SINGAPORE
RNAV (GNSS) Rwy 02L

JEPPESEN

WSSS/SIN

RVR
VIS
RVR
VIS

720m
800m
1500m
1600m
1800m
2000m

RVR
VIS

1500m
1600m

A
B

2400m

2800m

NA

| JEPPESEN, 2007, 2012. ALL RIGHTS RESERVED.

SINGAPORE Approach (R)

SINGAPORE Arrival (R)

120.3

119.3

Final
Apch Crs

118.6 *118.25
17'

Procedure Alt
LNAV/VNAV
Apt Elev
DA(H)
C2~RF
RNAV
Rwy 20R
(1987')
(517')
MISSED APCH: Climb STRAIGHT AHEAD to 5000'. On crossing SJ VOR
R-146, proceed direct to SAMKO holding area and hold or as directed
by ATC.

203^

2000'

Ground

530'

124.3
180^

128.6

SINGAPORE Tower

13'

3400'
2100'

203^

20

Alt Set: hPa


Rwy Elev: 0 hPa
Trans level: FL 130
Trans alt: 11000'
1. Minimum temperature for which Baro-VNAV operations are authorized: 15^C.
2. Maritime vessels of variable heights in water north and south of runway.

1 Max IAS 220 Kts.

WM(D)-231

1900'

090^

360^

D-ATIS

TM

12-2

31 AUG 12

CHANGI

BRIEFING STRIP

SINGAPORE, SINGAPORE
RNAV (GNSS) Rwy 20R

JEPPESEN

WSSS/SIN

MSA VTK VOR

D19.0

WM(R)-229

(IAF)

1 NYLON
4.
1

110.5^
3
400

WM(D)-230

30216
00 ^

15

3400

(IF)

203
^

10

01-30
MA
LAY
S ING SIA
AP
O

1 BIPOP

000

3000

C2~RF

500'

621'

RE

620'

(IAF)

290.7^
3

NOMAK
573'

WM(D)-8

023^

3000

(IAF)

1 BIDUS

468'

30
00

VTK

01-40

103-50

RW2~R

SAMKO
D8.0 SJ

01-20

MISSED
APCH FIX

SJ

VTK
TEKONG

627'

116.5 VTK

611'

CAUTION: Changi East Rwy


02R/20L is solely for use by
the Republic of Singapore
INDONESIA
Air Force (RSAF) Aircraft
104-10 MALAYSIA

348^

5000

168^

D14.0
5

WS(D)-34

Paya Lebar
Aero

SJ 6 ^
14 3.5
11

SJ
SJ

168^
SJ
5
113.

104-00

WS(R)-31

104-20

NOMAK

C2~RF3.2 NM
2000'

RW2~R
6.0

90

100

120

140

LNAV/VNAV

530'(517')

PANS OPS

2000m

CHANGES: None.

2800m

REIL
PAPI

RVR
VIS
RVR
VIS

720m
800m
1500m
1600m
1800m
2000m

5000'

TO DISPLACED THR
SJ

113.5 SAMKO
R-146

cross

PAPI

CIRCLE-TO-LAND

LNAV

580'(567')

ALS out

RVR
VIS

B
C

MDA(H)

ALS out

12.0
HIALS

160

Descent angle [3.00^] 372 478 531 637 743 849


MAP at RW2~R
C2~RF to MAP
6.0 5:09 4:00 3:36 3:00 2:34 2:15
STRAIGHT-IN LANDING RWY20R
DA(H)

3000'
BIPOP
NYLON

6.0
6.0

70

2000'

1500'

MDA

13'

Gnd speed-Kts

3400'
BIDUS

203^

0^]
[3.0

[TCH 50']

Rwy 20R

to C2~RF

4.5 NM
to C2~RF

RVR
VIS

1500m
1600m

A
B

2400m

2800m

NA

| JEPPESEN, 2007, 2012. ALL RIGHTS RESERVED.

SINGAPORE Arrival (R)

120.3

VOR
VTK

Final
Apch Crs

116.5

023^

SINGAPORE Tower

119.3

(CONDITIONAL)

410'(395')

2500'

Rwy 02C

15'

3400'

090^

MISSED APCH: Climb to 3000' via heading 023^ and VTK R-023 to NYLON

VTK

360^
Trans alt: 11000'

MSA VTK VOR


MISSED
APCH FIX

680'

TEKONG

116.5 VTK
hdg

Seletar

WS(D)-34

611'

023^

WS(P)-36

Paya Lebar
WS(R)-38

01-20

D6.0

440'

523'

1900'

2100'

(VTK R-023/D13.0) and hold or as directed by ATC.


Alt Set: hPa
Rwy Elev: 1 hPa
Trans level: FL 130
1. Maritime vessels of variable heights in water north and south of Rwy.

10

124.3

*118.25
Apt Elev 22'

MDA(H)

Minimum Alt
D13.3 VTK
(2485')

Ground

118.6

180^

SINGAPORE Approach (R)

NYLON

D13.0 VTK
CAUTION: Changi East Rwy
02R/20L is solely for use by
the Republic of Singapore
Air Force (RSAF) Aircraft

203
^ VT
D1
3/1
0 K
023
9 1 23^
16.
^
300
5
0

D-ATIS

128.6
TM

13-1

25 NOV 11

CHANGI

BRIEFING STRIP

SINGAPORE, SINGAPORE
VOR DME Rwy 02C

JEPPESEN

WSSS/SIN

VTK

D8.0
VTK

1017'

MALAYSIA
RE
SINGAPO
INDONESIA

SJ
SINJON

113.5 SJ

D13.3

023
^

VTK

01-10

(IF)

D16.6
VTK

SJ
168^
113.5

1 FMS required for holding

250
0

023.4^

D8
168^

NOT TO
SCALE

SAMKO

VTK DME

13.0

12.0

11.0

10.0

9.0

8.0

2420'

2100'

1790'

1470'

1150'

830'

VTK

3.3

Gnd speed-Kts
Descent Gradient
MAP at D6.0 VTK

D8.0

2500'

023^

2500'

5.2%

90
474

100
527

120
632

140
737

D6.0
2.0

0.4

ALSF-I
160
843 PAPI
PAPI
REIL

410'

MDA(H)
(395')
With D8.0 VTK

RVR

PANS OPS

VIS

720m
800m

RVR
VIS

1500m
1600m

C
D

RVR
VIS

1500m
1600m

CHANGES: Tower frequency.

RVR
VIS

1800m
2000m

15'

660'

MDA(H)
(645')
Without D8.0 VTK

ALS out
A

Rwy 02C

3000' 023^ VTK


via
and 116.5 NYLON
hdg
R-023

7.3 6:15 4:52 4:23 3:39 3:08 2:44


STRAIGHT-IN LANDING RWY 02C

FAF to MAP

VTK
VOR

VTK

660'

5.3

70
369

104-10

ALTITUDE

D13.3 VTK

D16.6 VTK

Hang Nadim

104-00

D21.0 VTK
VTK R-203
348^

4
D8 /1
4000

during SJ VOR outage.

436'

ALS out
RVR
VIS

720m
800m

RVR 1500m
VIS 1600m

RVR
VIS

1800m
2000m

2800m

2400m

3200m

| JEPPESEN, 1998, 2011. ALL RIGHTS RESERVED.

SINGAPORE Approach (R)

SINGAPORE Arrival (R)

120.3

VOR
VTK

Final
Apch Crs

116.5

203^

SINGAPORE Tower

119.3
Minimum Alt
D2.6 VTK
(1985')

*118.25
Apt Elev 22'

MDA(H)

580'(565')

2000'

Ground

118.6

Rwy 20C

15'

124.3
180^

D-ATIS

128.6
TM

13-2

25 NOV 11

CHANGI

3400'

MISSED APCH: Climb to 4000' via VTK R-203 to ESLUX (D6.7 VTK).
At ESLUX (1000' or above) turn LEFT heading 130^ to intercept
VTK R-158 to EXOMO (VTK R-158/D22.0) and hold or as
directed by ATC.

090^

1900'

2100'

360^

BRIEFING STRIP

SINGAPORE, SINGAPORE
VOR DME Rwy 20C

JEPPESEN

WSSS/SIN

Alt Set: hPa


Rwy Elev: 1 hPa
Trans level: FL 130
Trans alt: 11000'
1. Maritime vessels of variable heights in water north and south of Rwy.

0
^
0 23

000

2 .9
2 03^

10

D9.1
VTK

500'

M
SI AL
NG A
A YSI
PO A
RE

203
^

01-30

NOT TO
SCALE

(IF)

573'

VTK

D2.6

TEKONG

602'

VTK

116.5 VTK

WS(D)-34
680'

WS(P)-36

611'

D3.0

Paya Lebar
0

VTK
CAUTION: Changi East Rwy
02R/20L is solely for use by
the Republic of Singapore
Air Force (RSAF) Aircraft

01-20

ESLUX

dg

VTK
1180'

203^

15'

3.0

0.5

70

90

100

120

140

160

369

474

527

632

737

843

VTK

MDA(H)

PANS OPS

2000' 203^VTK2000'
6.5

ALSF-II
PAPI
REIL

4000'

580'(565')

116.5

R-203

ESLUX

20C

ALS out

RVR 720m
VIS 800m

RVR1500m
VIS 1600m

RVR1500m
VIS 1600m
RVR 1800m
VIS 2000m

2400m

CHANGES: Tower frequency, notes.

VTK

via

5.6 4:48 3:44 3:22 2:48 2:24 2:06


STRAIGHT-IN LANDING RWY

D9.1

D2.6

2.6

Descent Gradient 5.2%


MAP at D3.0 VTK

D2.0 BEFORE VTK


1820'

1180'

Gnd speed-Kts

FAF to MAP

D1.0 BEFORE VTK


1500'

VOR

VTK

MISSED
APCH FIX

VTK ^
158 .5
16
^ 1

D1.0 AFTER VTK


860'

D3.0

D22.0 VTK

INDONESIA

104-00
VTK DME
ALTITUDE

EXOMO

338

920'

13
0^h

00
^ 40

D6.7 VTK

158

SIA
LAY
MA
OR E
G AP

440'

104-10

SIN
8^
VTK 5 15
116.

WS(R)-38

Rwy 20C

627'

203^

Seletar

30 0

D1

D13.0 VTK
VTK R-023

3/1

NYLON

20 3

MSA VTK VOR

2800m
| JEPPESEN, 1998, 2011. ALL RIGHTS RESERVED.

Você também pode gostar