Escolar Documentos
Profissional Documentos
Cultura Documentos
Specification
Advantages
Result
Compressive strength :
BS6319
66 N/mm2
Flexural strength
BS6319
50 N/mm2
Tensile strength
BS6319
28 N/mm2
Youngs modulus
(in compression)
16 GPa
Chemical properties
Nitocote RI
Preparation
Immediately prior to the application of Nitocote RI the floor is
to be heated with an HCA machine to the point where
contamination is burnt off, damp is dried out and the pores
are open.
The HCA machine is to burn octane gas only and is to be
supplied with compressed air at 100 psi from a 100 cfm
compressor or greater. In the case of heavily oil contaminated
floors the HCA machine is to make two passes, the first to
carbonise oil deposits and the second to heat and open the
concrete pores. The floor is to be cleaned of any loose deposits
between passes.
On relatively clean slabs a single pass of the HCA machine will
suffice. The HCA machine is to travel forward at such a rate
that the concrete laitance spalls but the coarse aggregate
exposed does not.
Mixing
The entire contents of the hardener container should be poured
into the base container and the two materials mixed thoroughly
for at least 2 minutes. The use of a heavy-duty slow speed,
drill fitted with a mixing paddle is desirable.
Application
Immediately after the HCA machine has moved forward the
Nitocote RI shall be applied in consecutive flood coats by
squeegee. The procedure shall continue to be applied until
such time as the substrate is saturated with resin.
Cleaning
Fire
Estimating
Flash points
Fosroc Solvent 102
Supply
Nitocote RI
:
Fosroc Solvent 102 :
Coverage
Nitocote RI
substrate dependent
33oC
Disposal
Spillages of component products should be absorbed onto
earth, sand or other inert material and transferred to a suitable
vessel. Disposal of such spillages or empty packaging should
be in accordance with local waste disposal authority
regulations.
Storage
Shelf life
Additional Information
Precautions
n
n
n
n
DUBAI
ABU DHABI
BAHRAIN
KUWAIT
OMAN
QATAR
Al Gurg Fosroc
Al Gurg Fosroc
YBA Kanoo
Boodai
GETCO
Tadmur
TEL : 738200
FAX : 732828
Important note
Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard terms and conditions of sale, copies of which
may be obtained on request. Whilst Fosroc endeavours to ensure that the technical information on this data sheet is correct at the time of printing, it is the
customers responsibility to satisfy himself, by checking with the company that this information is still current at the time of use, that the product is suitable for
the intended application, and that the actual conditions of use are in accordance with those recommended. Because Fosroc has no control over the conditions of
use of its products, all recommendations or suggestions regarding the use of these products are made without guarantee.
www.fosrocgulf.com
UAE/0359/99/A