Escolar Documentos
Profissional Documentos
Cultura Documentos
IM/MAC 2011/IMS455
COURSE
COURSE CODE
IMD259
DATE
JULY 2013
TIME
2 HOURS
FACULTY
INFORMATION MANAGEMENT
SEMESTER
PROGRAMME / CODE
INSTRUCTIONS TO CANDIDATES
1.
2.
3.
4.
Do not bring any material into the examination room unless permission is given by the
invigilator.
SECTION
Group:..
Name
Matrix No
A
B
C
TOTAL
MARKS
3. List four type of front panel connector available on the motherboard (8 marks)
a. .
b. .
c. .
d. .
168 pin
ROM
256 pin
peripheral
two
mouse
one
FDISK
none
CMOS
formatting
firmware
embedded
DISKCOPY
P1
P9
scandisk
144
operating system
rescue disk
backup
memory
four
PS/2
three
127
72
1. A (n) ___________ is a pointing device used to move a pointer on the screen and to make
selections on the screen.
2. A (an) _________ acts as a middleman between application and hardware
3. AT motherboard used ______________ power connector.
4. A (n) _________ is an extra copy of a file or files made to a different location or storage
media.
5. Small Outline DIMM are available in ______ and _____ pins
6. _________ IDE drive can be installed in a computer that has primary and secondary hard
drive controller.
7. The two most popular ways to house DRAM are 72-pin SIMMs and ______-pin DIMMs.
8. The process of preparing the disk to receive data is called ___________ the disk.
9. Normally, you will boot from a hard drive, but sometimes problems with the hard drive make
it necessary to boot from a floppy disk. Always have a bootable disk called a (n)
_______________ available for this purpose.
10. Using the ATA standard interface there could be no more than ________ hard drives on the
same interface.
11. __________ memory is buffer of sort between fast processor and slow memory that served
it.
12. Universal Serial Bus can support up to ___________ devices.
13. Non-volatile memory is also known as _______________.
14. ________ is a combination of hardware and software.
15. In order to enhance the motherboard capabilities you can add _________ devices into the
motherboard.
Parameters Checking
External Power Supply Connector
FDD Power connector
HDD Power connector
CD-ROM power connector
Front Panel connector
a.
Reset /Key
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
lock
b.
Speaker
c.
Switch
d.
LED Power
e.
HD Led
IDE1 connector
IDE2 connector
FDD connector
VGA head/port connector
Audio head/port connector
Serial port connector
Parallel port connector
Mouse port position is correct
CPU Fan power supply connector
CPU Installation
CD-ROM Installation
HD Installation
FDD Installation
Audio cable CD-IN connection
Motherboard Installation
Jumper on motherboard proper set
Jumper on CD-ROM proper set
Jumper on HD proper set
ALL hardware / components are
1
1
1
1
2
2
2
2
2
2
2
2
2
2
2
2
2
2
3
4
2
2
4
29
proper screwed
Memory modules are proper
installed
TOTAL
50
Mark/item
3
1
1
1
1
Marks get