Escolar Documentos
Profissional Documentos
Cultura Documentos
26
Wheeled Armored
Combat Vehicle
OVERVIEW
Being the latest member of the PARS family, the PARS 4X4
has been designed to undertake special operational roles
such as advanced surveillance, anti-tank and command &
control. The vehicle was designed in a way to meet all the
operational requirements that might be required in the
theatre.
The PARS 4X4 has a power-to-weight ratio of 25-30 Hp/ton ,
a silhouette of just 1.9 m and amphibious capabilities. The vehicle with its crew of 5 can operate in water that is deep and
fast-flowing without any preparation. In the water, the vehicle
can perform pivot turns and even move backwards when required. The increased maneuvering capability in the water is
due to the two water jets located at the rear of the vehicle.
The PARS 4X4 can operate on any rough terrain with a reduced
break of angle, low center of gravity, fully independent suspension system, ABS-assisted hydraulic disc brakes, low ground
pressure and increased angles of approach and departure. The
PARS 4X4 can climb slopes of 70% and hold on slopes of 40%,
and it can pass over 50 cm vertical obstacles with ease. The
hydraulic recovery winch system located at the front of the
vehicle has the ability to provide self-recovery when required.
The mobility of PARS 4X4 has been increased via the central
tire inflation system, and it also has a run-flat capability. The
PARS 4X4 has a top speed of 120 km/h on asphalt and a range
of 700 km. The vehicle can switch from 4X4 mode for rough
terrain to 4X2 mode for use on a highway. The PARS 4X4 has an
automatic transmission and an axle lock for slippery surfaces
and soft soil.
Mobility
25-30 Hp/ton
120 km/h
Engine
Diesel
Swimming
Crew
Range
700+ km
Length
<5m
Angle of Approach
54
Width
< 2.5 m
Angle of Departure
42
< 1.9 m
Gradient
70%
Air Transportation
Side Slope
40%
Transmission
Fully Automatic
Vertical Obstacle
50 cm
Trench
90 cm
Turning Radius
<7m
Number of Axles
Driven Axles
All
Suspension
Brakes
Service
Parking
Electrical System
PARS 4X4
Command Control Vehicle
with 12.7 mm RCWS
PARS 4X4
Armored Tactical Vehicle
with 7.62 mm, 12.7 mm MG or
40 mm Grenade Launcher
PARS 4X4
Reconnaissance and
Surveillance Vehicle
PARS 4X4
Anti Armor with Remote
Controlled ATGM System