Escolar Documentos
Profissional Documentos
Cultura Documentos
17 in.
(431mm)
25 in.
(635mm)
17 in.
(431mm)
25 in.
(635mm)
17 in.
(431mm)
17 in.
(431mm)
IMPORTANT
Do not attempt to install guard until the appliance has been properly aimed and tested.
Lag shields are for use in concrete and the mortar joints of block or brick walls. For
wood installations drill pilot holes 13/64 diameter for lag screws only. Lag shields are
not required for this type of installation. Do not install guard on hollow backed drywall.
INSTALLATION INSTRUCTIONS
1. After alignment and test has been completed, use the guard as a template.
2. Center the guard over existing appliance. Slots must have openings
facing downward as shown.
3. Mark (8) mounting holes. Drill 1/2 in. diameter holes 1 1/2 in. deep.
4. Insert lag shields into holes flush or slightly below surface.
5. Install lag screws until approximately 3/4 in. remain outside of wall.
6. Place guard onto screws and tighten.
TO SERVICE CAMERA
Loosen the (8) lag screws and slide guard upward, use
caution not to hit or bump appliance.
NOTE
All specifications and information shown were current as of publication and are subject to change without notice.
9716IS MARCH2008
Corner Mount
Corner Mount
6.25 x 4 x 2.25
7 x 5.75 x 4.50
8.75 x 4 x 3.75
STI-9625
STI-9601
STI-9621
STI-9618
STI-9631
STI-9631-SS
STI-9631-R
STI-9632
STI-9632-SS
STI-9633
STI-9709
10.5 Diameter
10.5 Diameter Stainless Steel
10.5 Diameter Red
16.5 Diameter
16.5 Diameter Stainless Steel
20 Diameter
STI-9632
STI-9706
STI-9707
PIR GUARDS
STI-9618
STI-9619
STI-9620
STI-9621
STI-9622
STI-9623
STI-9624
STI-9625
STI-9640
10.7 x 14.6 x 4
8.7 x 17.7 x 5
13.8 x 21.7 x 5.9
10.75 x 24.75 x 11.25
5 x 13.5 x 4
7.9 x 6
3.7 x 3.5
5.9 x 4.9
3.86 x 6.18
7 x 8.43
STI-9615
STI-9664
STI-9649
STI-9717
STI-9720
STI-9730
STI-9796
STI-9880
STI-9881
STI-9705
STI-9796
STI-9880
JUNE2014