Escolar Documentos
Profissional Documentos
Cultura Documentos
3. Determine the maximum bending moment, & Shear force which will
occur at 4m from the left support under the shown wheel load system.
If wheel loads are moving from left to right on a simply supported
span of 12m.
3.
4.
5.
6.
8.
9.
&
b)
&0
c)
&
d)
&0
A two span continuous beam ABC is simply supported at A and C is continuous over
support B. Span AB=6m and BC=6m. The beam carries a UDL of the2t/m over both
the spans. EI is a constant for all the beam. The fixed end moment at B in the span
BA or BC would be
[
]
a)12tm
b)9tm
c)8tm
d)6tm
In moment distribution method the sum of distribution factors of all the members
meeting at a joint is always
[
]
a) zero
b) <1
c) >1
d) =1
The carry over factor for prismatic member with far end fixed is [
]
a) -1/2
b) 1/2
c) 1/4
d) -1/4
The absolute stiffness of a prismatic member with one end hinged is [
]
a)
7.
b)
c)
a) 8t
b) 4t
c ) 2t
d )1t
10. The influence line for bending moment at section X (Mx), at a distance of 4m from
the left support of a simply supported girder AB is shown in figure .A uniformly
distributed load of intensity 2t/m longer than the span cross the girder from left to
right .The maximum bending moment at section X is equal to
[
]
a) 12tm
b)
24tm
c)
48tm
d)96tm
11. The basic principle used in propped cantilever beam is -------------------------12. Maximum bending of a fixed beam when it is subjected to UDL over the entire
length is -------------------------------13. For prismatic members, stiffness factor is -----------------------------------14. The carry over factor for prismatic member with far end simply support end is ------15. General slope deflection equation is ----------------------16. Advantage of Kanis method is --------------------------17. What is advantage of ILD ---------------------------------18. ILD for left support of a simply support beam is ---------------------------19. Rotation Factor is ----------------------------------20. Final moment at hinge support is ----------------------