Escolar Documentos
Profissional Documentos
Cultura Documentos
Use the command ip address-summary to ensure that Router A recognizes the 2.2.2.0
network.
EIGRP supports VLSM and will automatically recognize the 2.2.2.0 network.
EIGRP does not support VLSM, therefore cannot be used with discontiguous networks.
when a neighboring router that is currently being used for packet forwarding fails
when the feasible distance reported by the next hop router is less than the advertised
distance to the destination
when the advertised distance reported by the next hop router is less than the feasible
distance to the destination
What action does an EIGRP router take to find a feasible successor for a network?
It transitions from passive to active state for that network and queries its neighbors.
It transitions from active to passive state for that network and queries its neighbors.
Refer to the exhibit. Which configuration statement for the serial interface on Router C is
true assuming a multipoint configuration?
It sends partial updates only to the routers that need the information.
It sends full updates only to the routers that need the information.
A network administrator notices the above line within the show ip route output of RTA.
Given this information, which statement is true?
RTA automatically inserted this summary when the command network 2.1.0.0 was
entered in router mode.
Which two statements describe the purpose of the EIGRP network command? (Choose
two.)
Determines which networks are advertised within an EIGRP update across the network.
RTC will enter a route to 2.1.0.0/16, sourced from the null0 interface, into its route table.
RTC will accept the 2.1.0.0/16 route and assign it an administrative distance of 90.
RTD will accept the 2.1.0.0/16 route and assign it an administrative distance of 5.
RTD will receive two routes, the summary route of 2.1.0.0/16 and the automatic classful
route of 2.0.0.0/8.
Refer to the exhibit. RTA cannot form a neighbor relationship with RTB. What should be done to
resolve this problem?
The subnet mask for network 10.1.1.0 on RTB must be configured as a wild mask.
The bandwidth for the serial0 interface on RTB must be set to 64 kbps.
The EIGRP hello interval for the serial0 interface on RTB must be set to 10 seconds.
Which statement best describes a route marked as active in the EIGRP topology table?
The netw
ork
administrator wants RTA to send only the summarized route of 10.10.0.0/16 to RTB.
Which configuration will accomplish this?
RTA(config-router)# no auto-summary
Authentication will fail because the key chain names do not match.
What are two effective ways to prevent the EIGRP stuck in active problem? (Choose
two.)