Escolar Documentos
Profissional Documentos
Cultura Documentos
Analog/GeoCENTREX
Calling Line Identification Presentation
on Call Waiting (CLIPCW)
A30828-X1150-B408-1-7629
Information
Analog/GeoCENTREX
Trademarks:
All designations used in this document can be trademarks, the use of which by third parties for their
own purposes could violate the rights of their owners.
A30828-X1150-B408-1-7629
Information
Analog/GeoCENTREX
Contents
1
Definition . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Mode of operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Administration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
A30828-X1150-B408-1-7629
Information
Analog/GeoCENTREX
A30828-X1150-B408-1-7629
Information
Analog/GeoCENTREX
1 Definition
The Calling Line Identification Presentation on Call Waiting (CLIPCW) feature expands the possibilities of the Call Waiting (CW) feature. The subscriber for whom a call
is waiting receives a display of the call data of the waiting subscriber as additional information.
Requirements for the CLIPCW feature are the Calling Line Identification Presentation
(CLIP) feature as well as the activated Call Waiting (CW) feature and authorization for
FSK transmission.
Network
node
12345
12345
Telephone /
FSK call data
Waiting
subscriber
Add-on equipment
MDTOG
Operator benefits
enhanced acceptance for the Call Waiting (CW) feature
more successful calls and therefore higher total charges
Subscriber benefits
enhanced protection against undesired calls by improved calling subscriber identification
improved service
Availability
Analog
ISDN
Subscriber
---
GeoCENTREX subscriber
---
Called
subscriber
CLIPCW use
---
CLIPCW effect
---
A30828-X1150-B408-1-7629
Information
Analog/GeoCENTREX
Interactions
For interaction with other features, see Feature Interactions.
Standards
The feature is based on the following standards:
ETS 300648
ETS 300659-2
2 Mode of operation
With the Calling Line Identification Presentation on Call Waiting (CLIPCW) feature,
a subscriber receives information about another subscriber who would like to set up a
connection to the subscriber during an existing call. The network node transmits the call
data of the waiting subscriber after the call waiting tone. The feature uses the FSK method (frequency shift keying) for transmission. A modem tone generator (MDTOG) is used
as the signal source. The speech path is briefly interrupted for the duration of nonrecurring transmission. A special information tone or a spoken announcement is not made
available for the subscribers during the transmission.
The maximum length of the data to be transmitted is 20 digits.
Should the feature be authorized, it will be active permanently.
Transmission is possible if the calling and the called subscriber are in the same network
node or if the signaling systems MFC-R2, SS7 or QSIG are available between the network nodes.
To display the call data, the waiting subscriber needs a terminal with an FSK receiver
and a display or corresponding subscriber add-on equipment (CPE).
To protect data transmissions (e.g. fax, modem), the feature Voice Data Protection
(VDP) can be use. The transmission of CLIPCW data will be prevented.
Capacity
The percentages indicate the number of authorized subscribers for the feature within the
network node and their simultaneous application.
Analog
ISDN
Authorization
Use
Authorization
Use
Subscriber
100%
*)
---
---
GeoCENTREX subscriber
100%
*)
---
---
A30828-X1150-B408-1-7629
Information
Analog/GeoCENTREX
FAIO
FAIS
FAU
Activate
---
---
---
Deactivate
---
---
---
Enter data
---
---
---
Delete data
---
---
---
Assign authorization
---
---
Remove authorization
---
---
---
---
---
---
---
---
---
---
---
Use
---
---
---
A30828-X1150-B408-1-7629
Information
Analog/GeoCENTREX
5 Administration
The operator can perform all administration functions on the NetManager by means of
user-friendly applications or MML commands.
Feature authorization
The network operator assigns authorization for the feature when requested by the subscriber.
Subscriber access types
The feature can be used with the following types of subscriber access:
Type
Subscriber
GeoCENTREX
Analog
ISDN
Analog
ISDN
Main station
---
---
Basic access
---
---
---
---
PBX
---
---
---
---
---
---
---
---
PBX line
---
---
---
---
---
---
---
---
---
---
Coinbox
---
---
---
---
---
---
---
---
MLHG line
---
---
---
---
---
---
---
---
---
---
---
---
A30828-X1150-B408-1-7629
Information
Analog/GeoCENTREX
6 Requirements
Hardware
Modem tone generator (MDTOG) with FSK transmitters for:
transferring call data to an analog subscriber
On the subscriber side, an FSK receiver with display
Signaling
Signaling between the network nodes
Multi-frequency code (MFC)
Signaling system no. 7 (SS7)
ISDN user part (ISUP)
Telephony user part (TUP)
Subscriber signaling
Analog
Frequency shift keying (FSK)
Subscriber interfaces
The following interfaces for subscriber access can be used:
DLU
LTG
V5.1 interface
V5.2 interface
A30828-X1150-B408-1-7629